Professional Documents
Culture Documents
1.Basic memory ccell of dynamic RAM a. Capacitance b. Flip flop c. Transistor d. Transistor with Capacitor
2.Ideal Power Supply has a. Zero internal resistance b. High O/P resistance c. High I/P resistance d. Low O/P resistance
3.Which type of transmission line will have max. value of characteristic impedence a. Open Wire line b. Coaxial Cable c. Twin lead line d. None
4. For same peak value of current, which waveform will have least RMS value a. Sine b. Square c. Triangular d. Full wave rectified wave
a. Voltage b. Condutance c. Magnetic Flux Linkage d. Capacitance 6.Similarly..............In F-I analogy displacement is analogous to a. Charge b. Resistance c. Inductance d. Current
8.The output at X acts as. a. OR gate b. AND gate c. XOR gate d. XNOR gate
9.The CRO in X-Y mode gives the following figure. If the signal applied to the Y-plate is 2sin(wt) then the signal applied to the X-plate is a. 2 sin (wt) b. 2 sin (wt + p/4) c. 2 sin (wt p/4) d.2v 2 sin (wt + p/4)
3.What elements does the network contain? An RLC network with 2 poles on the negative side and 2 zeroes on the +ve side (formin' a square) was given a. LC b. RC c. RL d.RLC 4.When transistor is in saturation a.EB jn. is forward biased, CB reverse biased b. EB ,CB reverse c. EB, CB forward d. EB reverse ,CB forward biased 5.ECL is a high speed switching device because it operates in a. between sat. and cut off region b. bet. cutoff and active c. active d. bet sat and active rgns. 6. XOR equilavent circuit using NAND gates was given 7. Open wired gate ckt. for XNOR. 8.Four waveforms were given and the ones with odd harmonics were to be found out(those with non zero values at origin)
9.Advantage of look ahead carrygenerator a.fewer gates. b.speed c. accuracy d.cheaper. 10.Resolution of TV screen depends on a.frames scanned per second b.video bandwidth c. video amp o/p d..... 11.Dynamic RAM uses a.transistor b.capacitor c.transistor as capacitors. d. flipflops 12.capacity of a memory chip is 256 x 1 bit how many chips do we use for 1MB memory a.32 b.24 c.12 d.8
13.with a sinusoidal i/p a RLC series ckt. with voltage across each element was given. (3V across R,14V across L,10 V across C) find the total voltage. 14.A switch between a resistor and a capacitor in series was given and the charging and discharging time was asked. 15.Floating pt. is not used in hardware 'coz a.costly b.slower c.can't be implemented in hardware d 16.Two's complement of 0100
17.Bit-slice processor is used for a. half bit resolution b. operations like make,shift c. DSP applications. d. 8,16,32 bit parallel operations 18.Spatial-temporal code conversion uses a.Shift registers b.Combinaitonal logic ckts. c.Flipflops d.... 19.Which is true? a.Transparent latch uses D ff b.JK ff uses racing condition for for storin 2 bits. c. Master slave ff s r used for storin 2 bits. d.... 20. In TV, equalizin Pulses r given during a. vert. blankin b.hor. blankin c.serrations. d...... 21.Two ffs with common clock pulse and the o/p of 2nd ff inverted and given as an i/p to first ff was given.it represents a a.up down counter b.shift register c.2-1 scalar d.4-1 scalar 22.CDMA advantage and disadvantage. 23.Transfer Fn. of an op-amp ckt. given.