Professional Documents
Culture Documents
This document is intended to provide customers with brief descriptions on the product and to assist customers to get started. For detail information and operations of the product, please refer to the users manual in the product CD.
1.
Packaging
Atop Wireless Serial Server x 1 5 pins Terminal Block for Serial Connector x 1 3 pins Terminal Block for Power Connector x 1 Mini DIN to DB-9 Cable x 1 Wall mount kits x 2 Atop Wireless Serial Server quick start guide x 1 Product CD containing configuration utility x 1 Product Warranty card x 1 Optional Accessories Power Adapter with Terminal block output 12V1.25A (1) US315-12 (US) Switching adapter (2) US315-12 (EU) Switching adapter
2.
Hardware Description
Fig.1 shows the interfaces of Serial Servers ConnectorsLEDs & the factory switch settings.
LED Indicator Mode Switch Mini-Din Pin Assignment Mode Switch Table Serial Port Mini DIN Connector
2.1. Interfaces
UTP Connector
Note: One can press the reset button for 3 second to reset the settings to default value
Description
No data is transmitting on Ethernet Data is transmitting on Ethernet
Description
No data is transmitting on COM port Data is transmitting on COM port
Description
Jumper JP1 pin1 and pin2 are short to disable AP firmware in the flash memory. AP firmware is running
3.
SW1 OFF ON
Table 1. MODE Switch Combinations Plug in Serial Server to DC-9-30V power source with 3-pin terminal block connector. Connect Serial Server to ones Ethernet network. Use a standard straight-through Ethernet cable. Connect Serial Servers serial port to a serial device; make sure the connector and wiring of RS-232 or RS-485 is correct.
Note Buzzer will beep and the RUN LED will blink if Serial Servers functions normally.
4.
Software Setup
Default IP address Interface Ethernet port Device IP 10.0.0.50.100 Subnet mask 255.255.0.0 Gateway IP 10.0.0.254
Default User Name/Password User Name admin Password Null (leave it blank)
4. The following configuration operations are totally the same as those configure by telnet. 5. After finishing console settings, power off GW51C-MAXI Serial Server, put SW1 and SW2 back to previous
setting.
5.
Pin Assignments
provides Mini DIN connector to DB9 connector cable, the pin assignments is shown in the following table and RS-485 2 or 4 pins assignments of DB9 connector are different from those of Mini DIN connector.
N/A (reserved) DATA+ N/A SG (Signal Ground) N/A DATAN/A (reserved) N/A
6.
+886-3-550-8137 +86-21-6495-6232