You are on page 1of 43

GeoScience Limited

HYDROCARBON PRODUCTION FROM FRACTURED


BASEMENT FORMATIONS

INTRODUCTION
This is a compilation of public-domain information about commercial hydrocarbon reservoirs
in fractured crystalline basement formations from approximately 30 different countries.
Although basement reservoir plays have been exploited for decades, since the mid-90s there
has been increasing interest and exploitation due to a number of factors working together.
These include the impetus derived from major discoveries in Vietnam and Yemen; the
advent of new downhole tools (especially borehole image logs and full waveform sonic
logging), seismic techniques (eg shear-wave attributes) and sophisticated drilling methods;
and the arrival of elevated oil prices to allow re-appraisal of basement projects previously
discounted as difficult or uneconomic.
Perhaps the best known basement reservoir examples are offshore Vietnam, where the Cuu
Long Basin comprises 95% of the countrys hydrocarbon production and 85% of this value
comes from the fractured granitic basement, and in the Yemen (e.g. DNO in Block 43, Nexen
in Block 14, Total in Block 10, and OMV in Block S2). Other significant discoveries have been
made in Argentina at the Cuyo Field and the Neuquen Field, both producing from fractured
volcanics.
We also know of one company (Hurricane Exploration) specifically set up recently to appraise
and develop basement plays, and they are having success on the UK Continental shelf West
of Shetland.
By definition (see below), this review concentrates only on those reservoirs found in igneous,
metamorphic and volcanic rocks. Although largely a historical review we have tried to make
new information available on a regular basis, and we are currently at Version 9 of an evolving
document started in the mid-90s. It is made available for personal interest and education
only and should not be republished or distributed in any way. Data has not been cross-
checked in detail against multiple references so use with care. In addition, some of the
information, for example on production, will be out of date since it is based on historical
sources.
Information updates, corrections and comments are welcome. We know from our own
work that there are several fields that are not included here because no information
has been released in the public domain. If you can provide information or examples
that we can use in the compilation we will be delighted to continue developing the
resource.
Compiled by Jon Gutmanis, Tony Batchelor, Lucy Cotton, Jo Baker and colleagues at
GeoScience Limited.
Updated October 2012

Version 10

October 2012

GeoScience Limited
FRACTURED BASEMENT RESERVOIRS -
DEFINITION AND HISTORICAL BACKGROUND
A large proportion of the world's proven oil reserves have been found in reservoir rocks that
are naturally fractured (Waldren & Corrigan, 1985; Nelson, 1985; Aguilera, 1995; Nelson,
2001). Nelson (2001) listed some 370 fields where natural fractures are important for
production, a significant proportion being in basement settings, and also stated that "...in BP
Amoco alone, current and future fields in various types of fractured reservoirs are estimated
to account for some 21 billion barrels of oil equivalent (BBOE)".
Basement reservoirs are a subset of naturally fractured reservoirs, and various definitions of
'basement rocks' exist (see for example Landes et al 1960, P'An 1982, Koning & Darmono
1984, Aguilera 1995c and North 1990). The definition that we think is most appropriate in
the context of hydrocarbon exploration is that of Landes et al (1960):
any metamorphic or igneous rock (regardless of age) which is unconformably overlain
by a sedimentary sequence
North (1990) however took a different view, considering basement rocks to include those of
sedimentary origin if they have little or no matrix porosity. This definition would be quite wide
including fields hosted, for example, in the Cambro-Ordovician quartzitic sandstones of
Algeria.
Basement reservoirs have been known about for decades but were often passed over as 'of
no economic potential'. Yet they are commonly distributed in hydrocarbon regions of the
world. As early as 1948, Eggleston (1948) reviewed oil production from basement rocks in
California and found that 15,000 bpd were in production, representing about 1.5% of total
Californian production at the time. Soon afterwards Hubbert and Willis (1955) produced a
comprehensive list of fractured reservoirs in the United States.
Landes (1959) speculated that many oil discoveries had been missed because of inadequate
exploration of the barely scratched basement by unsuccessful wildcats. According to Landes
et al (1960), about 100 million bbl had been produced by that time from various basement
formations worldwide, with initial productions being as high as 17,000 bpd. In their view
basement hydrocarbon accumulations were not freaks to be found solely by chance but
normal concentrations of hydrocarbons obeying the rules of origin, migration and entrapment
and should be explored for with the same professional skill and zeal as accumulations in the
overlying sediments. They suggested that the potential offered by fractured basement plays
was of sufficient magnitude to justify attempts to discover them by design rather than by the
previous situation of discovery by accident (drilling too deep).
Kenney (1996) noted that all the oil fields in the West that produce from crystalline
basements were discovered by accident whereas in Russia and some of the other countries
of the Former Soviet Union (FSU) drilling into crystalline basements has been carried out
intentionally (although a literature search reveals that citations of producing fields in
basement are actually few and far between). Until more recent years perhaps, many oil
companies stopped drilling as soon as basement rocks were intersected. Aguilera (1995a)
suggested drilling at least 300m into basement especially if the cover rocks contain oil and
believed that fractured reservoirs contain significant volumes of undiscovered hydrocarbons
which may have been missed by a failure to intersect the mainly vertical to sub-vertical
fracture system (Aguilera 1996).

Version 10

October 2012

GeoScience Limited

BASEMENT RESERVOIR CHARACTERISTICS
A recent GeoScience review of the geology and production characteristics of basement
reservoirs was presented at the International Petroleum Technology Conference (IPTC) in
Qatar (December 2009). Based on many reservoir appraisal and development projects
carried out by GeoScience as well as a large volume of published information, it contains a
summary of possible charging mechanisms, methods of reservoir characterisation, controls
on reservoir quality as well as some case histories and proposed development strategies.
Download it here:
Basement Reservoirs
A Review of their Geological and Production Characteristics by J C Gutmanis
Some key points made in the IPTC presentation are:
Basement charging is most commonly thought to result from up-dip / lateral migration
from an adjacent kitchen area into structural highs (either fault blocks or buried hills).
But other mechanisms are distinctly likely to operate as well, such as downward
migration due to differential stresses between overburden and basement; and long-
distance lateral migration through active faults (which may explain oil seeps found at
depth within the Hercynian granite plutons of Cornwall for example)
o How was your basement reservoir charged ?
As a result, hydrocarbon charge distributions in basement may be unusual, (eg ? the
Lancaster discovery West of Shetland, see below) especially if sealing horizons are
present such as poorly fractured or highly mineralised layers. In addition, the OWC is
very often hard to establish
o Do you concur with this comment ?
Reservoir quality and production from basement plays usually relies on the presence
of a connected open fracture network because matrix porosity and permeability are
generally very small (typically <0.5%) except perhaps in localised weathered zones
(which may be 5 to 10%). Bulk fracture porosity values of between 0.1 and 1% are
typical for fractured reservoirs including basements (Nelson 2001, Narr et al 2006,
GeoScience unpublished review) and production usually depends on features offering
enhanced permeability such as fault damage zones, fracture corridors or extensive
weathered zones at top basement or within faults.
o But not all of them ! its important to identify the subset of dynamically active
and connected fractures
Lithology is also often an important control on reservoir quality, perhaps surprisingly in
what are normally assumed to be fairly uniform basement rocks. However there is
growing evidence that granitic lithologies offer better prospects because they tend to
have better connected fracture systems compared to layered metamorphics which
have more limited fracture dimensions (see Figure 5 in the download).

Version 10

October 2012

GeoScience Limited
o Dont assume all basements are granitic metamorphic formations especially
when altered may be distinctly tight
Tectonic and fracture history are almost always a crucial factor because fracture
porosity and permeability may be focussed on the youngest structures, and also on
those which are in a state of critical shear within the current stress field (see Figure 3
in the download).
o Bring in the geomechanics people to look at in-situ stress!

Version 10

October 2012

GeoScience Limited

COUNTRIES WITH HYDROCARBON FINDS IN BASEMENT RESERVOIRS
Examples of producing basement reservoirs covering many countries throughout the world
have been documented within the public domain. This compilation has attempted to refer to
hydrocarbon fields where production figures can be cross-referenced to published literature
or traceable sources.
Alaska
The McArthur River field, Cook Inlet, is producing hydrocarbons from J urassic tuffites and
volcanic sands (Aguilera, 1998. Pers. Comm.).
Algeria
Saharan plateau basaltic lavas are reported to contain hydrocarbons.
Argentina
Cuyo Field
Permian volcanics are found to host hydrocarbons generated from the lacustrine shales of
the Upper Triassic Cacheuta Formation. The volcanics consist of andesite sills, and serve as
a secondary hydrocarbon producer to the overlying Triassic alluvial sandstones (Mosquera,
2004)
Nirihuao
Although this area is currently lacking the identification of a viable source rock, geochemistry
demonstrates a potential for oil generation. Possible reservoir units at this location include
Eocene and Miocene volcanics, along with Palaeogene to Recent clastics and carbonates
(J acques, 2003).
Drilling at the Neuquen field discovered hydrocarbons in the Permo-Triassic basement.
Source rocks were identified as the Upper J urassic black shales of the Vaca Muerta
Formation, along with J urassic calcareous mudstones and Lower Cretaceous mudstones.
The target horizons were Miocene carbonates and sandstones, however hydrocarbons were
also found to be contained within a Miocene volcanic series (rhyolites, tuffs and tuffaceous
sandstones), along with the Permo-Triassic basement. Production from these units was
11000 bo/d in 1980 (Aguilera, 2000).
Brazil
Fractured volcanics (basalt) of the Badejo and Linguado fields (discovered in 1975) produce
hydrocarbons (Nelson, 2001). These fields are located in the Campos Basin, offshore Brazil.

Version 10

October 2012

GeoScience Limited
Canada
The Archaen 7-32-89-10 well at Fort McMurray yielded shows of high gravity oil about 260 m
to 290 m below top of granite.
Chile
Lago Mercedes Field
Lago Mercedes Well 1 was spudded on 17
th
J anuary 1991. It was located to test a
seismically defined structural culmination located along a blind thrust near the deep foreland
axis of the western Magallanes basin. The fault is responsible for a trap geometry that is
genetically related to, but fundamentally different from, the numerous un-rooted Tertiary folds
in the area (Dean et al, 1993).
Although the Lower Cretaceous Springhill Formation comprised the primary target, Dean et al
anticipated that the geometry of the fold allowed for the possibility of several fractured
intervals, including volcaniclastic rocks of the underlying J urassic Tobifera basement
sequence. The sequence was found to be productive elsewhere along the eastern platform
of the basin (Dean et al, op cit).
During the drilling of the well, promising gas and condensate shows were observed in several
horizons. The most surprising of these shows later proved to be a Permo-Triassic grano-
diorite underlying the Tobifera. All the hydrocarbon bearing intervals exhibited minimal matrix
porosity but varying degrees of fracturing.
Testing of Well 1 yielded combined flow rates in excess of 12 MMCFD of rich gas and
1,140 bbl/day of condensate. The most abundant zone corresponded to an intensely
fractured and partially weathered interval. Additional testing was planned prior to any
estimate of recoverable reserves. China
China
Yaerxia Field, Yumen
The Yaerxia oil field in the J iuxi Basin (western part of J iuquan Basin) was the first basement
reservoir in China (Guangming & Quanheng, 1982; P'An, 1982). Oil is produced from
fractures in Palaeozoic metamorphic rocks. Oil production was up to 1,050 bbl/day at that
time.
Discovered in 1959, the Yaerxia basement oil field produces from the Quannaogou
Formation, which consists of phyllite, slate, and meta-sandstone. The rock is hard and
compact. Because the joints, faults, and fractures are well developed, production from some
wells is quite high. Highly productive wells (such as 114, 514, and 519) are all situated in the
vicinity of a fracture zone or at fault intersections.
During the period 1959 to 1979, 24 wells penetrated the Silurian (which is more than
19,700 ft thick) 21 of which indicated oil and gas. The depth of the wells ranged from 8,530 ft
to 10,500 ft (2,600 m to 3,200 m). Twelve wells had commercial value, six of which had initial
production of less than 70 bbl/day, and three wells produced 70 bbl/day to 350 bbl/day of oil.
Only two wells had initial production of 700 bbl/day to 1,050 bbl/day.

Version 10

October 2012

GeoScience Limited
Xinglongtai Oil and Gas Field
The Xinglongtai oil and gas reservoir is located in the middle of the west trough in the Lower
Liaohe depression. The 26,300 ft (8,000 m) deep Qingshui syncline is present to the south.
The reservoir rock is composed of Archeozoic slightly metamorphosed granite, Mesozoic
granitic breccia and extrusive rocks (andesite and basalt). Only the Archeozoic granite is
considered to be a basement rock here (P'An, 1982).
By the end of 1976, 8 productive wells had been drilled in the Xinglongtai oil field. A single
well drilled to the Mesozoic volcanic rocks was producing approximately 756 bbl/day. Oil
production from one particular well, which had been drilled into the granite and granitic
breccia, was between 210 bbl/day and 420 bbl/day. The Xinglongtai basement reservoir is a
high pressure, highly saturated reservoir with a hydrocarbon column of 2,300 ft (700 m). The
gas column is about 590 ft (180 m) with an oil column not less than 1,640 ft (500 m).
Dong Sheng Pu Buried Hill Field
The Dong Sheng Pu Buried Hill reservoir located in Xin Min County, Liaoning Province is a
fractured, metamorphic basement rock. The structural location of the Buried Hill reservoir is
the centre of the Da Ming Tun Depression with a minimum burial depth of 2,600 m (Ullah et
al, 1988).
Exploratory drilling began in October 1982 based on seismic data. In J anuary 1983, Well 3,
located above the crest of the Buried Hill, tested oil at a rate of 183.8 tons/day. By December
1987, there were 14 active producers and one observation well with cumulative volumes of oil
and gas of 1,050,000 tons and 65,500,000 m
3
respectively. Water injection was initiated in
October 1986 through four injectors with a cumulative volume of 290,000 m
3
(Ullah et al,
1988).
During late 1985 and early 1986, a detailed reservoir study was conducted to determine the
most appropriate method of developing and operating the field. Ullah et al state that a water
flooding scheme would produce the most efficient method of oil recovery compared to natural
depletion and gas injection. With water injection, oil production rates varied between 1,163
m
3
/day and 1,838 m
3
/day which relates to an estimated cumulative oil production, at the end
of the field's production life, of 25,390,000 m
3
.
Production from granites has also been reported at Bohai Bay field, and hydrocarbon shows
have also been reported in the Upper Basement in the Beibu Gulf (Roc Oil press-release,
03/05/04).
Other
Production has also been reported from fractured basement consisting of PreCambrian
gneiss at Wangzhuang field in China. Also from volcanics at Dujiatai, Qija, Shijutuo and
Shuguang (Lee, 1989), and from metamorphics at J inganpa.
Hydrocarbon exploration from volcanic formations in China has expanded in the last 50 years
and increased tenfold since the beginning of the 21
st
century. There are obvious differences
between hydrocarbon reservoirs in the east and west of China (Cai-neng et al., 2008).
Hydrocarbon reservoirs in the east are composed of Mesozoic-Cenozoic intermediate acidic
rocks, often forming a major source kitchen from a single eruption phase. Whereas,

Version 10

October 2012

GeoScience Limited
hydrocarbon reservoirs in the west are formed from multi eruptional stages of intermediate
basal volcanics from Palaeozoic intracontinental rifts or island arcs.
Volcanic reservoirs in China are successful because of 3 main factors: 1) they have a good
source-reservoir-cap rock association with near source (often vertical) migration and
accumulation. 2) The compaction resistance of the reservoirs is strong and 3). The source
rock is mainly composed of coals with a high evolution degree (Wenzhi, Z et al., 2009).
Bohai Bay Basin-Metamorphic field of J Z25-1S
J Z25-1S oilfield is an Archean buried hill reservoir in the Liaoxi low bulge, Bohai Sea.
Fractured reservoir systems are found throughout the Archean migmatization granitic gneiss,
an example of a metamorphic basement reservoir with potential.
Songliao Basin
The Songliao basin is situated in the East of China and is composed of lower Cretaceous
source rocks from the Shahezi formation, volcanic reservoir rocks from the Yingcheng
formation and a mudstone cap rock from the Donglouku formation. There are 2 productive
layers in the basin, a shallow middle layer hosting the Daqing Oilfield and a deeper layer
containing mainly gas. This deeper layer is riddled with large fault depressions (up to
1000km
2
) 6 of which are producing commercial amounts of oil and gas. Xushen 1 was the
first well to be sunk in the Songliao for volcanic gas exploration; it produced 54 x 10
4
m
3
from
the Yincheng formation of which there is an estimated 286.8 BCM of gas reserves remaining
in the field (Wen-zhi, 2008).
Cuba
The J atibanico Pool reserve of Cuba has over 1200 hydrocarbon producing wells penetrating
fractured serpentinites (Oil and Gas J ournal, 14
th
J uly, 1945, Vol. 44, p.92).
Hydrocarbons are also observed in the Pina reservoir, producing from Upper and Lower
Cretaceous tuffites (Villavicencio et al, 1994).
Exploration for oil in basement reservoir rocks in Cuba peaked in the 1920s. Serpentine was
the predominant reservoir rock in the area, with oil seeps following cracks and fissures made
by dykes of diorite (in Habana) or obsidian ( in Motembo), these fissures are thought to be
Eocene in age (Lewis, 1932). There were two main production fields within Cuba:
1) The Motembo field, situated on a serpentine highland with a vertical height of 325 feet
and a diameter of 3 miles. By the 1930s this field had produced 5000 barrels of oil
and was semi-commercial.
2) The Bacuranao field, discovered in 1915, 10 miles east of Habana. By the 1930s, 40
wells had been drilled in an area of 160 acres. These wells were owned by the Union
Oil Company and produced 30 barrels per day.
Asphalt from serpentine country rocks was also mined in large quantities. Particularly
lustrous wells included the Santa Eloisa (500 tons), La Esperansa and Chambas (Lewis,
1932).

Version 10

October 2012

GeoScience Limited
Egypt
The basement oil fields of Egypt are located approximately 196 km southeast of Suez on the
west shore of the Gulf of Suez. Oil is produced mainly from the Hurghada and Gemsah
fields. The Gemsah oil field is located on a granite buried hill. Oil is found in a coral reef that
lies above the granite ridge and is probably of Miocene age. However, it is not a basement
reservoir and has not been included in this compilation. The oilfields at the entrance to the
Gulf have been described by Salah & Alsharhan (1998). Basement fracture analogues for
the offshore oilfields have been described by Younes et al (1998).
The Gulf of Suez contains many recently discovered basement reservoirs, such as the Zeit
Bay field and the offshore Ashrafi field. These produce approximately 25, 000 barrels of oil
per day and are found in fractured basement reservoir rocks of granite and granodiorite
intrusions. Two fault sets are associated with the basement rocks, contributing to the
increased porosity and permeability of the reservoirs. The first fault set is parallel to the rift
(310-330) creating oblique and dip-slip normal faults, the second fault set strikes across the
rift at 055-065 and is related to block rotation (Younes et al., 1998).
Hurghada Field
The Hurghada field lies southeast of the Gemsah field and close to the shore of the Gulf of
Suez. It is a shallow, granite buried hill. Wells drilled through Miocene and Cretaceous strata
penetrated a granite core at depths of approximately 1,670 ft to 2,000 ft (510 m to 610 m).
Oil was found in the Cretaceous sandy shale, Nubian sandstone and in the weathered
surface of the granite (P'An, 1982). The Miocene strata are unconformable with the
Cretaceous beds and are less highly folded. The Hurghada field produces heavy oil (no
production rates available).
Zeit Bay Field
The Zeit Bay field is a northwest-southeast trending structure which measures approximately
2.5 km by 4.5 km located in the southwest corner of the Gulf of Suez (Khalil & Pigaht, 1991).
The field was discovered in 1981 when well QQ 89-1 found gas. In October of the same
year, the appraisal well, QQ 89-2, intersected a 830 ft thick oil leg 2 km south of well QQ 89-
1.
According to Zahran & Askary (1988), the Zeit Bay field fractured basement contains nearly
one-third of the total oil in place for the field and the flow rates per well varied from 700
bbl/day to 10,000 bbl/day. Due to its well established production potential, 60% of the field's
development wells were drilled down to the basement (Zahran & Askary, 1988). The Zeit
Bay basement consists of granitic rocks of pegmatitic to coarse porphyritic texture.
The reservoir in Zeit Bay is an hydraulically communicating sequence of PreCambrian
igneous and metamorphic rocks as well as sedimentary reservoirs (Khalil et al, 1993; El
Hamalawy et al, 1993). The 830 ft thick oil column covers the total reservoir sequence. The
field commenced production in 1984 reaching approximately 80,000 bbl/day (Salah
Alsharhan, 1998) and by 1991 it was estimated that 65% of the recoverable oil had been
produced (Khalil & Pigaht, 1991).
A significant proportion of early production was from basement wells with individual flow rates
of up to 10,000 bbl/day being recorded. Pressure maintenance by gas injection was

Version 10

October 2012

GeoScience Limited
implemented in 1987. Out of 36 production wells drilled in the Zeit Bay field, 24 wells
penetrated the fractured basement, 14 of these were completed as openhole basement
producers.
The Zeit Bay field basement can be classified into five rock types:
Basement wash (this overlies the basement rock; composed of granite,
feldspar, chlorite and clay)
Fractured granite
Meta-volcanics (composed of hornblende, magnetite, apatite and chlorite)
Meta-sediments
Dykes
Former Soviet Union Countries
There are said to be numerous fields in the FSU producing from fractured basement
reservoirs (Kenny, 1996), but very little detail has been published in the West. Kenny (1996)
states that more wells have been drilled into crystalline basements within the FSU than all
other nations combined with the consequence of greater production. For example, the
Caspian district has a total of eighty fields producing from crystalline basements. Unlike the
majority of drilling operations which cease as soon as basement rocks are encountered
(Aguilera, 1995b), Krayushkin et al (1994) state that all of the hydrocarbon fields within the
FSU producing from crystalline basements were developed intentionally.
Published articles from a working conference on oil in granite held in Kazan, Tatarstan,
Russia in late 1997, (see latest reference section), refer to basement oil shows in the
Chibuiuskoye, Verkhnechutinskoye and Iskosgorinskoyeoil fields, together with the
Zelenetsky, Chernorechensky, Lekkemsky and Timansky oil productive areas. Production
statistics from individual wells or fields were not made available.
One such example is discussed by Krayushkin et al (1994) involving an exploration project on
the flanks of the Dnieper-Donets Basin. An initial geological study of the sedimentary,
metamorphic and igneous rocks in the 'Northern Monoclinal Flank' of the Dnieper-Donents
Basin concluded that there was no potential for hydrocarbon production. The conclusion was
made because of the absence of any source rock and the presence of active, strongly
circulating artesian waters.
However, the exploration and drilling programme which followed the initial study resulted in
the discovery and development of 12 fields with oil reserves equal to 219 million metric tons
of oil equivalent, the major part of which, according to Krayushkin et al (1994), is produced
from the PreCambrian crystalline basement. However, this is difficult to demonstrate, partly
because of multiple completions in basement and overlying cover (Kitchka, pers. comm.,
1999).
The fields were discovered in an area covering 30-35 km by 400 km where the oil and gas
bearing rocks are Carboniferous sandstones and PreCambrian granites, amphibolites and

Version 10

October 2012

GeoScience Limited
schists of the crystalline basement complex. The exploration programme also resulted in the
discovery of a gas field with reserves of 100 billion cubic metres.
From a total of 61 wells drilled in a corridor 35 km wide by 400 km long, 37 produced
commercial quantities of hydrocarbons (an exploration success rate of 55%). Initial flows
from the productive wells varied between 40 and 350 metric tons/day of oil and 100,000-
1,600,000 m
3
/day of gas. Production interval depths within the PreCambrian basement
varied between 3,135 m and 4,041 m. Recently we have learnt of a new discovery in
PreCambrian basement called Goshinovskoye field (Kitchka, pers. comm., 2000). Near
Khark another corridor 30 km wide by 100 km long is associated with 3.5 Tcf reserves
(Kitchka, pers. comm., 1998)
Tatarstan
A well at Novoyelkhovskaya penetrated crystalline basement at 1845 m and significant
hydrocarbon shows have been reported below 4500 m (Kitchka, pers. comm., 1998)
Georgia - Samgori Field
The Samgori field is located near Tbilisi, in the Republic of Georgia. Production of more than
165 M bbl of oil has come from a middle Eocene laumontite tuff which is enclosed within a
thick layer of andesite-basalt tuffs and tuffites which act as a seal (Grynberg et al, 1993).
Productivity is dominantly controlled by fracture porosity and permeability. The fractured tuffs
are relatively isolated from the action of geostatic and geotectonic loads which would
otherwise have resulted in closure of fractures and microfractures. In addition, the fluid
pressure tends to maintain open fractures.
Georgia Ninotsminda Field
Located 25 km east of Tbilisi, the Ninotsminda Field represents the largest remaining oil
accumulation in Georgia. The field was discovered in 1979, and represents an anticlinal trap,
with production mainly from the fractured Middle Eocene volcaniclastics. The reservoir is
underpressured at 0.38 psi/ft, and is dominated by sub-vertical micro and macro fractures
that are most concentrated in the hinge area of the fold.
In 2000, a vertical well was drilled into the oil producing formation, with production tests
stabilising at a flow of 200 bo/d. After further work was carried out on the area, another
appraisal well was drilled in 2003, this time with a horizontal deviation in the oil-producing
strata. The oil flow using this method was 2200 bo/d.
The area is being extensively developed by the NOC (Ninotsminda Oil Company), with a 5
well prospect likely to increase production from 2000 to 4500 bo/d (Durglishvili et al., 2004).
Hydrocarbons have also been discovered in the Middle Eocene volcanic prospect at Nono
PSA, Patardzeuli and South Dome fields.
Kazakstan - Oimasha (Oymasha) Field
The Oimasha oil field is located in the South Mangyshlak Trough, in a sub-basin sometimes
referred to as the Peschanomyss-Rakushechnoe Uplift. The field was undeveloped as at

Version 10

October 2012

GeoScience Limited
1995. However, Well 12 tested approximately 1,382 bbl/day from fractured/weathered
granite at a depth of 3,720 m to 3,752 m. The granite intrudes into Early Palaeozoic
metamorphics (Reisser, 1996).
Greenland
Oil was first identified in 1992 in a basalt-hosted petroleum reservoir around Marraat Killiit on
Nuussuaq in West Greenland. Oil is held in vesicles and voids within the halyoclasts of thick
volcanic sequences overlying petroleum source rocks. Although discovered, hydrocarbons
are not being exploited from this reserve (Rogers et al., 2006).
India
An appraisal well was drilled in 1997 (Well PY-1-12) to confirm the significance of a 1980 gas
discovery reported by India's Oil & Natural Gas Commission (ONGC) (see J .Pet.Tech., Sept.
2001). The discovery, named PY-1, is in the Cauvery basin about 100 miles south of Madras
in the Bay of Bengal.
The reservoir, which is hosted in heterogeneous, PreCambrian, weathered granite and
sealed by Cretaceous to Eocene shales, lies on the crest of a northeast-southwest basement
ridge known as the Portonovo high (Anon, 1995). The field lies beneath approximately 250 ft
of water (see Oil & Gas J ., Nov. 1995).
It was estimated that PY-1 could yield as much as 116 BCF of gas and 1.16 M bbl of
condensate in primary production. Process facilities were designed on flow rate criteria of 53
MM scf gas and 600 bbl condensate (see J .Pet.Tech., Sept. 2001).
In 1980, the ONGC logged four productive gas wells in the PY-1 field, including the PY-1-1
discovery well. Production tests of the wells reportedly ranged as high as 13 MMCF/day.
The PY-1 field pay zone occurs in sections as thick as 200 ft and at depths of 5,000 ft to
5,500 ft. PY-1 is within, and surrounded by, Block CY-OS/2, a 3.8 million acre tract formerly
known as Block 17 (Anon, 1995).
Mangala Oil Field, northern Rajasthan
Cairn Energy (UK) completed their appraisal of Block RJ -ON-90/1 in October 2004 (see E&P,
Oct. 2004). Three exploration wells (Mangala-3, Mangala-5 & Mangala-6) encountered 125 m
of net pay in the high quality oil bearing Fatehgarh Sands, followed by a 30 m oil column
hosted by the underlying fractured basement.
Production tests on a 34/64 in. choke indicated a possible 2000 bo/d from the Fatehgarh
Sands, and 1084 bo/d from the underlying basement (with an associated 1490 b/d of water).
Production tests also established an API of 41.5, confirming the basement rock as a viable
exploration target in the heavily faulted areas of the basin.
Raageshwan, 75 km south of Mangala
Exploration wells drilled by Cairn Energy in 2004 encountered modest volumes of gas from
basement rocks, along with minor oil shows (untested). Gas was also found in fractured
volcanics at a depth of 3000 m, with production tests revealing a gas output of 1 MMcf/d

Version 10

October 2012

GeoScience Limited
(Cairn Energy press-release, 24/03/05).
Bombay High Field
The Bombay High Field was first discovered in 1974, 150km off the west coast of India. The
field contains both a limestone reservoir and a basement reservoir composed of basaltic and
granitic gneiss. The basement hydrocarbons are located at a depth of 1900m, note that the
granitic basement contains a higher fracture density and is therefore more lucrative than the
basaltic gneiss reservoir rock. By 1993, wells BH-36, BH-19 and II-7 had been drilled and
were successfully extracting oil from the basement at rates exceeding 1000 barrels per day
(Akbar et al., 1993).
Indonesia
Sumatra Beruk Northeast
The Beruk Northeast oil field of Central Sumatra was discovered in 1976 with the drilling of
the Beruk Northeast Well No. 1 into a Pre-Tertiary basement. The oil field is located within
the Central Sumatra BackArc Basin, one of a series of Tertiary basins oriented along the
western and southern margin of the Sudan Craton. In addition to Beruk Northeast, only four
other fields have been reported as producing from Pre-Tertiary basement in Indonesia.
Koning & Darmono (1984) state that oil production from Pre-Tertiary rocks is exceptional in
Southeast Asia.
The Beruk Northeast field is situated within a group of oil fields in the central area of the
Pertamina-Calasiatic-Topoco Coastal Plains-Pekanaru Production Sharing Block. The
basement rocks, which tested oil, consist of fractured metaquartzites, weathered argillites
and weathered granite. Beruk Northeast Well No. 1 was drilled to a total depth of 1,634 ft
into the basement. An openhole test of the basement flowed at 1,680 bbl/day. A thin Telisa
sand located approximately 100 ft above the basement was tested and flowed at 480 bbl/day.
By 1984, Beruk Northeast Well No. 1 had produced in excess of 1,100,000 barrels of oil,
640,000 barrels of water and 42 MMCF of associated gas. All production from the well has
been obtained through the naturally occurring fracture system in the Pre-Tertiary basement
metaquartzites (negligible matrix porosity exists from core studies). Subsequent
development wells have been less productive, possibly due to the poor characteristics of the
weathered argillite and granite reservoirs (Koning & Darmono, 1984).
In the Sei Teras field, South Sumatra, 15,000 barrels of oil and 1 BCF of gas has been
produced since 1977 from two wells in basement limestone and quartzite. Approximately
21 million barrels of oil and 14 BCF of gas has been produced from Pre-Tertiary rocks in the
Tanjung field, South Kalimantan (Koning & Darmono, 1984, after Tiwar & Taruno, 1979). The
basement rocks in this field consist of porphyritic extrusives (lava) and volcanics as well as
metamorphosed sandstones, shales and claystones. In both the Sei Teras and Tanjung
fields, the basement is locally deeply weathered and fractured (Koning & Darmono, 1984).
Sumatra - Suban gas field
The Suban field gas discovery occurred in 1999, when 3 wells were drilled by Gulf Indonesia
into fractured pre-Tertiary granites. The Durian Mabok 2 Well collected gas at a rate of 26
million cubic feet per day, leaving a remaining 5 trillion cubic feet; equivalent of 500 million

Version 10

October 2012

GeoScience Limited
barrels of oil (Koning, 2003). As of 2005, interest holders of the Suban gas field included
ConocoPhillips 54%, Talisman Energy Inc. 36% and PT Pertamina 10% (Oil and Gas
J ournal, 2007).
Sumatra - Tanjung field
Situated in the Barito basin, South Kalimantan. The Tanjung field is one of 7 productive fields
within the Talang Akar sandstone formation (Hassan and Soebandrio, 1988). Oil is produced
from pre-Tertiary rocks of metamorphosed sandstones, pyroclastics and volcanics, as well as
clays and shales. Since its discovery in 1938, the Tanjung field has produced over 21 million
barrels of oil (Koning, 2003). The discovery well, Tanjung labon 1 was not drilled until
1982, when it was inserted by Asamera (South Sumatra) Ltd.
Sumatra - Gunung Kemala Field
The Gunang Kemala field was discovered in 1938 when BPM drilled a folded structure in the
South Palembang Sub-basin (see PEG.GB, March 2005). Hydrocarbons were contained
within the sedimentary Talang Akar Formation, with production from this unit peaking in 1953
at 6610 bo/d.
In 2003 Pertamina drilled to 3500 m at a location around 3.5 km east of the previously
producing Grunung Kemala field. The wells primary target was the pre-Tertiary basement,
with drilling extending 600 m deeper than any previous wells. A 50 m interval of net pay was
encountered in the basement, with a tested flow of 500 b/d of 50 API crude and 9 MMcfg/d
of gas.
Gas was also discovered in the fractured basement of the Suban-Karan Ringin sub-block of
South Sumatra. The well was drilled to a depth of 2697m, and targeted the Batu Raja
Formation clastics, the Talang Akar Formation clastics and the fractured basement. 260 m of
net gas pay was discovered, although no details of the proportion of gas existing in the
basement are available.
J ava - J atibarang Field
The J atibarang field is located in Northwest J ava, approximately 200 km to the east of
J akarta. The field produces from eight shallow sedimentary zones, but major production
zones are in naturally fractured volcanic formations (Soewono & Setyoko, 1987). The
J atibarang volcanic formation consists of lava flows (andesite/dacite/basalt), tuff and
agglomerate/volcanic breccia. Oil was first discovered in the volcanic reservoir in November
1969 with the drilling of Well J TB-44, at a depth of 2,011 m (Sembodo,1973) and has been
developed since 1973. Initial production from 20 wells was approximately 40,000 bbls/day.
Since then, many wells have been drilled, the production of which varies from 250 bbls/day to
3,000 bbls/day. The depth of wells varied between 2,000 m and 2,300 m, with hydrocarbons
found between 1,900 m and 2,200 m (Sembodo, 1973). By April 1987, the cumulative
recovery of the J atibarang volcanic reservoir was 83.9 M bbls of net oil from 136 wells
(Soewono & Setyoko, 1987).
Kalan et al (1994) present the results of a geological investigation of the J atibarang Field
performed in 1991/1992 by Elf Aquitaine Indonesia. The investigation was part of a feasibility
study into the utilisation of horizontal drilling to improve production from the J atibarang
volcanics. The feasibility study concluded that the drilling of horizontal wells would provide

Version 10

October 2012

GeoScience Limited
increased recovery from the volcanic reservoir (actual production figures were not provided).
Fracturing in the volcanics is believed to be the most intensive in the tight folds of the Central
and Western Blocks which accounts for the good production (previously discussed above).
Kalan et al (1994) proposed the use of a horizontal well in the Eastern Block of the J atibarang
Field where the volcanic reservoir has produced less than expected due to lower intensity of
folding and fracturing.
Japan
Throughout J apan approximately 100 oil and gas fields had been discovered by 1991,
producing 1755 kilolitres of oil per day and 5.5 million cubic metres of gas per day (Kikuchi et
al., 1991). Many of J apans commercially productive reservoirs are deep seated volcaniclastic
reservoirs (otherwise known as green tuff) found in the backarc basins of island arc
settings. Volcanic reservoirs were first discovered in the Mitsuke field in 1958, important
fields at present include: Katakai, Kumoide, Sekihara, Fujikawa and Yoshii. Volcanic
reservoirs are found in two forms in J apan: Pillow-brecciated and high porosity lava facies
such as the Minami Nagaoka-Katakai gas fields in the Niigata region; or basalts, for example
the Yurihara oil and gas field in the Akita area (Kikuchi et al., 1991).
In western J apan gas is produced from granite at a depth of about 4300 m. The best well is
said to produce about 800 bbl of condensate per day (Russell and Warren Hunt, pers.
comm., 2000) and an unspecified, but large, gas flow. In the Nagaoka and Niigata fields
5400 bopd oil and 14 bcf gas is produced from green tuff and volcanic formations (Kitchka,
pers. comm., 2000).
Yufutsu
Yufutsu is a naturally fractured gas condensate reservoir, situated in Hokkaiddo, J apan. The
reservoirs basement rocks consist of Cretaceous granite overlain by an alluvial/fluvial
conglomerate of Eocene age. The field was discovered in 1989 and production commenced
in 1996, since then 12 wells have been drilled, operated by J apan Petroleum Exploration Co.,
LTD. (J apex). Yufutsu covers an area of 4km x 8km, starting at a depth of 3800 metres
(Ghorayeb et al., 2000).
Kenya
The Turkana Depression
Hydrocarbon exploration in the East African Rift Valley started during the 1970s.
Investigation into the Turkana Depression by Amoco Kenya Petroleum Company and project
PROBE revealed several N-S trending grabens with positive reservoir quality and source rock
potential. Clastic volcanic rocks, thought to have originated from the Samburu Basalts
Formation form part of the Auwerwer/Lomerimong reservoir section (Tiercelin, 2004).
Korea
Oil has been recovered from fractured granite.

Version 10

October 2012

GeoScience Limited
Libya
Nafoora-Augila Field
PreCambrian granite is the host for one of the primary oil producing reservoirs in the Nafoora-
Augila field which is one of the main giant fields in the Sirte Basin (Belgasem, 1991). The
Nafoora-Augila field is located in the northeast of Libya (southeast of the Amal field) and is at
the top of the Rakb High. The Nafoora-Augila area was originally a concession of Oasis Oil
Co., the owner of the Amal field. The company drilled two wells near the top of the High but
then abandoned the concession as the wells proved to be dry. The concession was then
obtained by Occidental Petroleum (UK) Ltd in 1966. The first successful well of Occidental
was Dl, which had an initial production of 14,800 bbl/day. Production came from porous
fossiliferous limestone perforated throughout the interval from 8,530 ft to 8,563 ft (2,600 m to
2,610 m). This reservoir rock was lower Rakb carbonate and was not a basement reservoir
(P'An, 1982). The fractured and weathered basement (a late PreCambrian or early Paleozoic
granite) is one of three producing horizons. Some of the oil wells started production from the
basement reservoir only while others produced from the basement and/or sedimentary
reservoirs. The basement rocks are gradations of granophyre, granophyric granite, granite
and rhyolite (Belgasem et al, 1990). The basement reservoir contains a large accumulation
of oil in fractures and weathered zones. However, due to the heterogeneous nature of the
reservoir, the porosity distribution is not well known.
The first basement reservoir encountered was Well D2 drilled on possibly the highest point of
the High. Well D2 produced at a rate of 7,627 bbl/day from devitrified rhyolite and highly
weathered and fractured granophyre. Well D9 also produced from the basement only with an
initial production of 1,500 bbl/day. The reservoir rock was weathered granite. Wells D3, D4,
D5 and D6 were all step out tests that became oil wells, the most productive being D5 which
produced at a stabilised rate of 14,140 bbl/day from two perforated intervals consisting of 59
ft (18 m) of carbonate rock and 39 ft (12 m) of granite. Well D6 produced from the basement
reservoir with an initial flow of 1,200 bbl/day. D8 was an openhole basement completion,
testing at 18,000 bbl/day from basement rocks and 36 ft (11 m) of perforated carbonate rocks
(P'An, 1982).
Mexico
Many thousands of oil seepages in Mexico are associated with various forms of
ferromagnesian igneous intrusions. Most of them occur in the Tampico embayment. The
Furbero oil field produces from a laccolith of gabbro and from the overlying shales. The
Fubero oil field is located in the canton of Papantla, State of Vera Cruz. A thick sill of gabbro
has been intruded into Tertiary shales. The sill is folded and follows bedding. Metamorphism
of the overlying shales has occured. Well No. 27 at 30 ft into the gabbro came in with an
initial production of 893 barrels and had produced over 200,000 barrels at a rate of 1000
barrels a day. Similarly, Well No. 28 initially produced oil from 157 ft into the intrusion
(DeGolyer, 1932).
Namibia
Kudu Field
Located 130km offshore Namibia, the Kudu field holds 1.3 trillion cubic feet of gas reserves
and an estimated 9 trillion cubic feet of possible reserves. Reservoir rocks include Lower

Version 10

October 2012

GeoScience Limited
Cretaceous Aeolian sandstone interbedded with Etendeka, volcanic rock (Rocha Mello et al.,
2011). The estimated production life span of the field is 25 years making it a hugely
important potential resource for Namibia. The drilling of the wild cat well Kudu 9A-1 block
2814A, led to the discovery of the Kuku field in 1974 by Chevron Texaco (Offshore
technology, 2012). Since then the field has had many different owners; at present Tullow Oil
is the operator with production being a joint venture between Namcor and one other (to be
announced later this year, 2012).
Morocco
Landes et al (1960) state that there are at least eight oil fields in northwestern Morocco which
produce from fractures in basement rocks. Lardenois et al (1956) refer to nine named fields
in basement. In a couple of the fields, the reservoir rock consists of fractured, pink
PreCambrian granite. In seven fields, the reservoir is a fractured chloritic quartzite and shale
or slate of Palaeozoic age which is also basement rock.
The basement rock accumulations are in upfaulted blocks that are marginal to a Mesozoic
sedimentary basin. It is assumed that the fractures in the PreCambrian granite and in the
Palaeozoic meta-sediments were filled with oil by lateral migration from the adjacent deeper
Mesozoic sediments. Although the source of oil in the basement rock is probably the
sediments in the adjacent Mesozoic basin, more oil has been produced from the basement
rocks than from the sediments. By the end of 1957, the basement reservoirs had produced
more than 3.75 million barrels of oil since discovery in 1947 (P'An, 1982).
New Zealand
Kora Oil Field
Located approximately 30 km north of New Plymouth and 30 km west of Awakino in the
northern Taranki Basin, New Zealand, the Kora oil field is a 10 km to 12 km diameter, 1 km
thick, subsurface, volcanic/plutonic complex (Russell, 1997; Bergman et al, 1992). The
basement rocks range from Mesozoic granitoids, most abundant in the southern part of the
basin, to Paleozoic forearc basin deposits.
Four wells were drilled at the Kora oil field. The Kora-1 wildcat exploration well was drilled
between 1987 and 1988 to a depth of 3,450 m with the primary reservoir target in the
Eocene/Oligocene Tangaroa Sandstone. Residual hydrocarbons were encountered in the
Tangaroa and produceable crude oil was found between 1,790 m and 1830 m in the Upper
Miocene volcanic interval. A further 3 wells (Kora-2, -3 and 4) were drilled to constrain the
hydrocarbon distribution at Kora and encountered only residual hydrocarbons in the upper
most volcanic rock intervals in Kora-2 and -3 (Bergman et al, 1992).
Bergman et al (1992) state that volcanic reservoirs are viable targets for hydrocarbon
reservoirs in the northern Taranaki Basin. Based on observations at Kora, the most
prospective volcanic reservoirs are those complexes more deeply buried in the axis of the
Taranaki Basin where the development of a suitable seal and the existence of thermally
mature Pakawau source rocks are most likely.
Pannonian Basin, Europe
The Pannonian Basin, bordered by the mountain ranges of the Alps, Carpathians, and

Version 10

October 2012

GeoScience Limited
Dinarides, is an inter-mountain basin which occupies the northern part of Yugoslavia, the
southeastern part of Austria, most of Hungary and a small part of western Romania. The
Pannonian basin is developed on the Hercynian folded basement rocks.
Yugoslavia
Oil in the Yugoslavian part of the Pannonian Basin is mainly produced from Upper Tertiary
reservoirs with a small part produced from fractures in basement rock (Filjak, 1969). The
basement is composed mainly of schists, granites, and gneisses of PreCambrian, early
Paleozoic, and late Paleozoic age. The main reservoir rocks of this field are the Miocene and
the basement crystalline schists. In many places in the Yugoslavian part of the Pannonian
Basin (especially the Banat depression), the Tertiary oil generating and oil bearing formations
directly overlie metamorphic basement rocks and are the most favourable areas for finding
basement reservoirs. The reason little oil has been produced in the past from the basement
is that it has not been an exploration target (P'An, 1982).
Romania
The Banat depression of northeastern Yugoslavia extends northeastward into western
Romania. In the Banat depression in Romania, some small basement oil and gas reservoirs
have been found. Oil is stored in the weathered zone of crystalline basement rocks (P'An,
1982).
Hungary
Exploration for hydrocarbon reservoirs within fractured and weathered zones of crystalline
basements is of great importance in Hungary (Kiss & Tth, 1985). The majority of
hydrocarbon reserves found in recent years have come from basement metamorphic
reservoirs. These metamorphic hydrocarbon-bearing formations are generally characterised
by complex lithology, low porosity and a heterogeneous distribution of pore sizes and
fractures (Kiss & Tth, 1985).
Except for a small part northeast of Budapest, almost all of Hungary is in the Pannonian
Basin. On the southeastern part of the Great Hungarian plain, there are 4 oil fields (Battonya,
Pusztafoldvar, Algyo, and Asotthalom) in which the major part of the oil is produced from
Tertiary rocks. Also in the Pannonian Basin, there are several examples of oil fields
producing from fractured metamorphic rocks (P'An, 1982). An example of which is the
Sarkadkeresztur field at the Hungarian/Romanian border (Matyas, 1996). There is also a
reservoir hosted in gneiss at Szeghalom (Nelson, 2001).
Other
The Zdanive-Krystalinkum field in the Bruno-Vistulicum area of the Czech Republic is said to
produce minor hydrocarbon from PreCambrian basement (Nelson, 2001). The basement
lithologies consist of Neoproterozoic igneous rocks overlain be Vandian greenschist-facies
metamorphic rocks. The area lies within the Moravian zone of the Carpathian Foredeep,
however there is a lack of published information on the area.
Russia
Petroleum ages in Russia extend over a 1000 million year time period with source rocks

Version 10

October 2012

GeoScience Limited
ranging from late pre-Cambrian to Miocene (Tull, 1997). Examples from the Pechora
Platform, the Riphean reservoirs and the Tatarsan Arch demonstrate how source rocks of
Permo-Carboniferious and Silurian-Lower Devonian are more petroliferous in Russia than the
more recent J urrasic-Quaternary source rocks.
Shaim Field
Located on the western side of the West Siberia basin on the Shaim uplift, the Shaim oil field
is situated on the eastern slope of the Ural Mountains. Oil was first found in a basement
fracture in 1959 (from Well 2). Well 7, on the west flank of the uplift, produced 25 bbl/day in
April 1960 from basement fractures. Well 11, also on the west flank, produced 28 bbl/day
from fractured basement rock. The basement rock consists of Paleozoic metamorphic and
igneous rocks mainly composed of sericitic/siliceous schists intercalated with fine sandstone,
fine conglomerate, marble, granite and gneiss (P'An, 1982). Well 6 on the east flank flowed
at 2,380 bbl/day in J une 1960 from the Vogulkin sandstone (Upper J urassic).
Oil from the very productive wells in the Shaim oil field does not come from basement rock.
The basement rock (producing from wells 7 and 11) yields only several tons of oil per day
(about 25 bbl/day).
Kola Peninsula
Hydrocarbons have been reported in the Nepheline-Syenite dykes of the Kola Alkaline
Province. These dykes were intruded into carboniferous schist, which is the likely source rock
for the methane-dominated inclusion.
The Tatarsan Arch
The South Tatarsan Arch is situated in the eastern third of the East European Craton in the
Volga-Ural region of Russia. This area hosts the large oil fields of Romashkino and Tatarstan
which are currently exploiting oil pools found within the Palaeozoic (Devonian and
Carboniferous) sedimentary strata overlying pre-Cambrian basement rocks (Plotnikova,
2006). As part of the Deep Drilling Program, wells Novoelkhovo-20009, (bottom hole depth
5881m) and Minnibaevo-20000 (bottom hole depth 5099m) were sunk into the South Arch
crystalline basement in order to assess the potential reservoir quality of the rocks (Plotnikova,
2009).
Fractured and fractured-brecciated reservoirs formed from geodynamic deformation since the
early Late Proterozoic were found between 5 and 7 km depth. These zones were created by
two phases of deformation. A compressional phase, creating catalastic and mylonitised
zones, followed by a decompressional phase allowing the fractures to open up and permit the
circulation of hydrothermal fluids. Friable rocks which are unable to be cemented because of
continued vertical geodynamic movements are common in these crystalline basement rocks
and provide excellent potential hydrocarbon reservoirs (Sitdikova and Izotov, 2006). The
sedimentary rocks of the Tatarsan Arch have proved to be highly productive with production
reaching 2.7 B t (2006), however the crystalline basement rocks of the area are yet to be
exploited but are deemed equally promising.
Thailand
Sirikit Oil Field

Version 10

October 2012

GeoScience Limited
The Sirikit field lies in the Phitsanulok Basin, one of a series of Tertiary rift-related structures
in central and northern Thailand. The tectonic history of the area is complex: the original,
extensional, half graben was deformed during deposition of the upper reservoir sequence by
left-lateral strike-slip faulting (Knox & Wakefield, 1983). During the Mesozoic, most of central
and western Thailand was affected by large, left lateral wrench faults and compressional
tectonics. More recently, most of the Thai region was rotated clockwise developing large
extensional (growth) faults and minor divergent wrench movement. These extensional
tectonics lasted throughout the Tertiary and caused the formation of the many relatively small
sedimentary basins in central and southwest Thailand. The pre-Tertiary structures in the
Sirikit field consist of block faulted and tilted basement rock in an upthrown position.
Basement in this field consists mainly of metamorphic clastic red beds
The Field has produced about 1.17 M bls of oil from basement so far (November 1998).
About 14 wells had been drilled into the pre-Tertiary basement (to 1995) many of which had
oil shows and two have been placed under production. Using the seismic data of the area, a
model was created of the Central Sirikit High. This part of the field has the only producing
well. 3 wells were drilled in this area, one has been in production since 1991, one was shut
in after it rapidly watered out and one only produced water. This proved the assumption that
hydrocarbon distribution was directly related to the fracture pattern.
A fracture simulation model using software packages (Frame and Poly3D) has come up with
a prediction of the fracture pattern of this field (Smitt, 1998).
United Kingdom
Clair Field and West of Shetland
Discovered in 1977, Clair oil field lies 75 km west of the Shetlands, offshore UK (UKCS), in
waters of up to 150 m in Block 206. Clair comprises an elongate NE-SW trending ridge of
Lewisian basement (the Rona or Clair Ridge) and an associated roll-over (or terrace)
containing a thick sequence of mainly Devonian continental red beds with lacustrine and
fluvial deposits (Coney et al, 1993). The first well (206/8-1A in 1977) tested oil at 1500
bbl/day from the red beds at the crest of the roll-over. Well 206/7-1 followed, producing oil at
960 bbl/day from the fractured basement on the ridge with the oil coming entirely through the
fractures. Ten further wells drilled between 1977 and 1985 indicated OIP of billions of
barrels. However, test results were disappointing. The success of the discovery wells
(206/8-1A and 206/7-1) was never repeated and commercial test production rates were never
achieved.
Two further appraisal wells were later drilled in 1991. The first, a horizontal well in the
fractured basement, tested at 2100 bbl/day after acid wash stimulation. The second well
tested the red beds on the flank of the roll-over and achieved sustained flow rates of 3000
bbl/day from two zones (Coney et al, 1993). An extensive fracture analysis was performed in
the horizontal appraisal well. The objective of the well layout was to cross-cut the fracture
zones located in the fractured basement which were believed to act as preferential drainage
paths for the hydrocarbons situated in the overlying and adjacent red beds source rock (Falt
et al, 1992).
In late 2001, BP and its partners decided to go ahead with development and since around
2005 there has been ongoing production, mainly with development wells in the Devonian
although it is likely that connectivity to the basement is present. A recent summary of the

Version 10

October 2012

GeoScience Limited
field geology is in Barr et al (2007), though dealing primarily with the Devonian.
As of 2011 the Clair field extends over an area of 54,300 acres and is primarily operated by
BP (28.6%) with co-venturers Shell (28%), ConocoPhillips (24%) and Chevron (19.4%).
Although exploration in this area has been ongoing since the 1970s, recent government
permission (2011) has been granted for production to start in 2016 on Clair Ridge
(ConocoPhillips, 2012). The total investment required for this venture including 40 years
production has been calculated at 4.5 billion, with estimated reserves of 640 million barrels
and peak production at 120,000 barrels of oil per day. BP Exploration will be the operating
company for Clair Ridge with 27.6215%, along with co-venturers ConocoPhilips (U.K) Limited
(24.0025%), Chevron North Sea Limited (19.4225%), Enterprise Oil Limited (Shell)
(18.6831%), Shell Clair UK Limited (Shell) (9.2900%) and Britoil plc (BP) (0.98%) (BP, 2011).
In 2009 Hurricane Exploration drilled the Lancaster well in Block 205/ 21a West of Shetlands,
announcing it as a light oil discovery in fractured basement which also sits on the Rona
Ridge. As of J une 2010 the well was being re-entered for testing and there was further
intention to drill the Whirlwind basement prospect further north along the Rona Ridge.
Other
The literature concerning hydrocarbons in the UK contains occasional references to trace
hydrocarbons found in the Cornubian granites of SW England. These Hercynian granites are
intruded into rocks of Devonian and Carboniferous age and minor traces of a 'mineral' pitch
are found on some fracture surfaces within the granite. No significant accumulations of
hydrocarbon have been found in any of the extensive mining activities (as deep as 1000 m) in
the region nor in boreholes as deep as 2800 m near the centre of the Carnmenellis granite.
All the mines in the region are now closed (the last one, South Crofty, was shut down in
March 1998) and the few samples that are accessible are at the Camborne School of Mines.
Massonat et al (1993) have described the geological and reservoir approaches to optimising
the oil recovery from a field in the United Kingdom (the authors did not name the field, then
owned by Elf). The reservoir consists of several hundred metres of sandstones,
conglomerates, siltstones, and shales with poor reservoir characteristics. The well
productivity is generally low. However, a vertical well has shown higher productivity coming
from both the sandstones and the underlying fractured granite basement. The authors
expect that a horizontal well within the basement and intersecting the major fracture
orientations could possibly produce hydrocarbons from the overlying and adjacent
accumulation with good productivity.
United States, California
Production has ceased in most fields, however Wilmington field (see below) in South
California is still active. There are approximately 300 million barrels remaining from the
original estimated reserves of 3 billion barrels, making it the 3
rd
largest oil field in the whole of
the USA.
Landes et al (1960) and Hubbert & Willis (1955) state that oil has been produced from
fractured basement metamorphic rocks in five fields of the Pacific Coast province, California.
These are Edison and Mountain View in the San J oaquin Valley, and Wilmington, El
Segundo, and Playa del Rey in the Los Angeles Basin. Few wells produce oil from the
basement rocks alone. Most are multiple completions in the basement schist and the

Version 10

October 2012

GeoScience Limited
overlying schist conglomerate.
McNaughton (1953) states that the first commercial oil production from basement
metamorphic rocks in California was probably in Placerita Canyon near Newhall. According
to Brown & Kew (1932, after McNaughton, 1953), small quantities of light-gravity oil were
produced from 5 wells drilled between 1899 and 1901. The basement complex in the vicinity
of the wells consisted mainly of schists.
The next discovery of oil in the basement complex was made in the Playa del Rey field at
Venice in 1929. Available descriptions of the Playa del Rey field have been limited.
Production was from a fractured schist reservoir with relatively low rates, approximately
400 bbl/day (Eggleston, 1948).
An important basement discovery was made in El Segundo field in 1937. It was accidental in
that the objective of the test well was the schist conglomerate capping the basement.
Examination of cores revealed that the well stopped in fractured schist containing oil. The
well was highly productive and the discovery was followed by intensive development of the
basement reservoir in the field.
Another basement pool was discovered in 1942 in the Santa Maria Valley field. The
discovery was also accidental, a fortunate consequence of ignorance concerning the exact
depth of the basement in the central part of the field (McNaughton, 1953). Similar exploration
in the Edison field southeast of Bakersfield disclosed oil in fractured metamorphic rocks in
1945. Intensive development of the basement reservoir followed this discovery with 103
wells being drilled into the basement and all but 6 were completed as commercial producers.
Oil production from these wells in the first 18 months after discovery amounted to 4,500,000
barrels. In 1947, the estimated reserve in the basement pool was 25 million barrels
(McNaughton, 1953).
Another basement oil reservoir that was discovered accidentally was in the Wilmington field
in 1945. Apart from the Santa Maria field (in which the oil is produced from sandstone), oil
from basement rocks was produced from fractures in schists (Aguilera & van Poollen, 1979).
Most of the oil-producing schists are in a relatively high position. They have usually
undergone weathering and erosion that has increased porosity.
Edison Field
Located in the southeastern San J oaquin Valley 18 km east of Bakersfield, Kern County,
California, the Edison Field was discovered in 1931. From 1931 to 1945 production from the
field was exclusively from two separate sands in the Tertiary sediments (Hubbert & Willis
1955). In J une 1945, one well was drilled through the entire sedimentary section, penetrating
100 ft (30 m) into the schist and encountered the basement reservoir complex. Slight traces
of oil were found in the sediments but more promising showings were observed in the
fractures of cores from the basement. A test was made and the well was completed in the
metamorphic rocks of the basement complex with the well initially flowing oil at 528 bbl/day.
Rapid development of the basement followed. Initial daily production in other wells varied
greatly. A few wells produced more than 2,000 bbl/day, most produced about 1,000 bbl/day.
The height of the oil column in the schist gradually increased from the southwest to the
northeast, the maximum being 1,000 ft (305 m). Wells with daily production of more than
1,000 barrels of oil were concentrated in the north-central part of the Edison field. By the end

Version 10

October 2012

GeoScience Limited
of 1955, the cumulative oil production from the fractured schist was more than 20 million
barrels (Eggleston, 1948; P'An, 1992). The estimated ultimate production was around
50 million barrels (Hubbert & Willis 1955).
El Segundo Field
El Segundo oil field, which was discovered in 1935, is located along the coast of Santa
Monica Bay, southwest of Los Angeles County. The field is divided into two areas by a
northwest trending zone of faulting. The eastern part produces from a basal conglomerate
made up of schist pebbles with the western part producing directly from fractures in the schist
itself.
The first well was drilled to the east of the faulted fracture zone. The daily production of oil
from the basal conglomerate was about 600 barrels. The western part of the field began
producing in 1937 from the fractured schist reservoir. The production rate was 4,563 bbl/day
at a depth of 7,253 ft (2,210 m). This discovery was accidental as the well was exploring for
the schist conglomerate. 66 wells were drilled in the development of the El Segundo field
with a wide variation in production from adjacent wells (Eggleston, 1948; Landes et al, 1960;
P'An, 1982).
Wilmington Field
The Wilmington oil field is located in the city of Wilmington and includes the harbour area of
Long Beach (the Los Angeles basin). The discovery well was completed in J anuary 1932
with oil production from the Union Pacific E-47 well during May 1945. The schist reservoir
was encountered at a depth of 5,787 ft (1,764 m). Production from well E-47 was initially 387
bbl/day. However, in 1946 rates of 1,200 bbl/day to 2,000 bbl/day were established from
wells producing from the schist reservoir. Wilmington has produced more than 22 million
barrels of oil from the basement reservoir (Cabeen & Sullwood, 1946; Landes et al, 1960;
P'An, 1982).
Eight productive zones are present in the Wilmington field. Of these, seven are in Pliocene
and Miocene sediments with the eighth in the fractured basement schist, known as 237
Basement (Robertson et al, 1987). The productive zone in the schist does not extend below
6,200 ft (1,890 m). The Wilmington field is the third largest oil field in the USA in terms of
cumulative production, at 2.8 billion barrels (Gibson, 1997).
United States, Central Kansas Uplift
There are more than 10 small basement oil fields producing from some 50 wells which lie on
the Central Kansas uplift (Hubbert & Willis, 1955; P'An, 1982; Aguilera, 1995a,c). Oil is
stored in the fissures of the PreCambrian quartzite and granite which constitute the buried
hills (or buried topography) of the uplift (Landes et al, 1960). By the end of 1952, the
cumulative production from the 10 oil fields was more than 1.5 million barrels (Hubbert &
Willis, 1955). The PreCambrian basement rocks consist mainly of quartzite, schist, gneiss
and granite which are overlain by about 500 ft of Cambro-Ordovician sediments.
Orth Field, Central Kansas (Rice County)
Discovered in 1933, the Orth field lies in northwestern Rice County. The oil was produced
from fractured PreCambrian quartzite on the summits of the buried hills. Each well produced

Version 10

October 2012

GeoScience Limited
an average of 120 bbl/day of oil with a maximum production of 939 bbl/day. About 1,243,000
barrels of oil had been produced from quartzite in 16 wells in the Orth field by the beginning
of J anuary 1952 (Walters, 1953; P'An, 1982).
Ringwald Field, Central Kansas (Rice County)
The Ringwald field, which lies approximately 2.4 km southwest of the Orth field, was
discovered in 1949. The structure and stratigraphy are similar to the Orth field. There is a
PreCambrian quartzite hill with Lansing-Kansas City limestones abutting and draped over it in
an anticlinal fold. The field contains 6 wells which are producing (or have produced) from
fractured PreCambrian quartzite. Daily production per well is low. After treatment by
hydrofracturing, the daily production reached 190 bbl/day.
The Silica field, which lies south of Ringwald, is another low producing reservoir in Rice
County. An average of 100 bbl/day were produced from irregularly distributed fractures in the
PreCambrian quartzite at a depth of 3,270 ft to 3,284 ft (997-1,001 m) (Walters, 1953; P'An,
1982).
Kraft-Prusa Field, Central Kansas (Barton County)
The Kraft-Prusa field, discovered in 1937, lies northwest of the Orth field and extends across
parts of three townships in the northeastern corner of Barton County. The field, which is
10 miles long and 3 miles wide, has a producing area of 15,000 acres (Walters, 1946;
Walters & Price, 1948). The Kraft-Prusa field, one of the major oil fields of the Central
Kansas uplift, is typical of that area in its stratigraphic and structural relationships but is
exceptional because of its high ratio of dry holes to producing wells (Walters & Price, 1948;
Landes, 1959b). The hydrocarbons occur in the Pennsylvanian Lansing-Kansas City
limestone, 'unconformity sand', Arbuckle dolomite and fractured PreCambrian quartzite.
There is no doubt that the oil in the PreCambrian quartzite belongs to a basement reservoir.
The fractures in the quartzite from which oil is produced probably originated as a system of
joints resulting from prolonged subariel weathering. It is estimated that less than 5% of the
wells drilled into quartzite have encountered fracture porosity. Characteristic of these
reservoirs (like other basement reservoirs) is the irregular distribution of porosity and
permeability. It is believed that the oil migrated from the overlying Pennsylvanian rocks into
fractures in the quartzite.
In 1945, the PreCambrian rocks at Kraft-Prusa were known to produce oil from only one well,
Oeser 'B' No.2 well. Wells drilled into the PreCambrian quartzite reached depths ranging
from 3,180 ft (969 m), producing 65 bbl/day, to 3,337 ft (1,017 m) which produced
108 bbl/day.
By the middle of 1952, about 11 PreCambrian basement reservoirs had been discovered in
the Central Kansas uplift. Most of the wells were drilled initially to prospect shallow oil
reservoirs but often oil was found in the basement rocks (Walters, 1953).
The Beaver, Bloomer, Trapp, Eveleigh, Silica and Heinz oil fields are all similar to the Kraft-
Prusa field in that there is some production from fractured PreCambrian quartzite occurring in
the buried hills in Barton County (Aguilera & van Poollen, 1979). Production from the fields
varies from 55 bbl/day, at a depth of 3,300 ft (1,006 m) to 434 bbl/day at a depth of 3,332 ft
(1,016 m).

Version 10

October 2012

GeoScience Limited
The Hall-Gurney and Gorham fields of Russell County (Central Kansas) are similar to each
other, each has several wells which produced from a fresh, pink, biotite-granite (355 bbl/day
at 3,244 ft and 306 bbl/day at 3,330 ft respectively). Drilling indicated that there was an
erratic distribution of oil in the granite. One well encountered significant porosity and oil 70 ft
below the top of the granite while many others failed to find any trace of hydrocarbons
(Walters, 1953; P'An, 1982).
United States, Arizona
The Dineh-Bi-Keyah oil field, Apache County, represents a stratigraphic accumulation of
hydrocarbon at the northwestern end of the Toadlena anticline, discovered in the early
1960s. The field produces from a sub-aerially fractured Tertiary syenite sill, with the
hydrocarbon sourcing from the surrounding bioclastic limestones (McKenny, J .W. & Masters,
J .A., 1968). Production peaked in 1967 at 3300 bo/d, however there is a lack of subsequent
published information on area.
United States, Nevada
The Eagle Springs oil field, discovered by Shell in the 1950's, produces from fractured
volcanics of Oligocene age. To date, 1.8 million barrels of oil have been produced from these
volcanics with an OOIP estimated at 40 million barrels (Snow, 2001). Oil is also being
produced from the Miocene aged Humbolt Basalt at the Blackburn oil field (Nelson, 2001).
United States, Oklahoma
The Ames impact structure in Oklahoma produces from fractured granite in the central uplift (
Rajmon 2005 Pers.Comm and J ohnson and Campbell 1997).
United States, Pennsylvania
Hydrocarbons are produced from the fractured Silurian Tuscarora Formation quartzites. The
accumulation is present in a folded structural trap at the Devils Elbow field (Nelson, 2001).
United States, Utah
A Tertiary basalt hosts hydrocarbons at the West Rozel field, Utah. Connectivity within the
crystalline reservoir is due to the presence of faulting and columnar joint sets (Nelson, 2001).
United States, Coastal Plains, Texas
The Thrall oil field in Williamson County, Texas was discovered in 1915. Oil is produced in
commercial quantities from pyroclastic rocks and serpentine within Cretaceous formations.
Since the first field, 7 additional fields have been discovered through the Gulf Coastal Plain of
Texas and these include Chapman, Hillbig Pool, Yoast, Lytton Springs, Dale, Buchanan,
Lytton- Springs townsite and Schimmel-Batts. The rock containing the oil was originally of
basaltic character but has been altered to chlorite or serpentine. It is probably extrusive in
origin but may be in small part intrusive. Production from the combined fields was over 13
million barrels of oil by 1931 (Shellard, 1931).
Oil is currently being produced at Fort Worth, Texas (Nelson, 2001), with the Burnett Oil
Company tapping a granite wash reservoir (Akota Formation). Production testing revealed a

Version 10

October 2012

GeoScience Limited
flow of 1400bbl of oil from an untreated interval between 2008 and 2011 m.
Venezuela
Reports from Le Vela (J une, 1999) say that Phillips have tested both the Cauderalito
Limestone and the fractured basement in well LVC-29 at a depth of 2826 m. Three Drill Stem
Tests were completed between 2363-2444 m producing a combined flow of 15.5 MM cf/day
of gas and 83 b/day condensate. A second sidetrack was underway. No details of the flows
from the basement were easily available.
La Paz Oil Field
Discovered in 1922, the La Paz oil field lies approximately 40 km west of Maracaibo City. Oil
was first produced from Guasare (Paleocene) sandstone, limestone and Eocene sandstone.
Initial production averaged about 500 bbl/day. As a result of deeper drilling, higher
production was obtained from Cretaceous limestone (Cogollo Group) from which initial
production averaged 5,000 bbl/day (Aguilera & van Poollen, 1979). The reservoir rock was
more than 1,650 ft (500 m) thick, the oil mainly stored in secondary voids, cracks, and
fissures (Smith, 1956; Landes et al, 1960).
Since oil was stored in Cretaceous limestone fissures, it was felt that if the underlying
strongly folded and faulted basement rocks were similarly fissured, they might also contain
oil. The granitic basement unit is part of a large inversion structure that was partially uplifted
during the Late Eocene (Nelson et al., 2000). The fractures within the basement unit are
associated Miocene-Pliocene inversion, with a secondary microporosity related to Eocene
upift. The first two wells purposely drilled into the basement were unsuccessful. The third
well (Well P-86) was completed in April 1953 to a total depth of 8,889 ft (2,709 m) which was
1,089 ft (332 m) below the top of the basement complex. Since then, at least 12 wells have
been drilled into the basement with an average penetration of 1,650 ft (503 m), the maximum
being 3,087 ft (941m). Average initial production, purely from the basement, was
3,600 bbl/day but one well had an initial yield of 11,500 bbl/day (Landes et al, 1960).
La Paz produces from granite in the cores of anticlines and the total reserve has been
calculated at 905 MM bbls (P'An, 1982).
Mara Oil Field
Considered as the 'champion' of basement producers (Landes, 1959), the Mara field lies
northeast of the La Paz field. The complex basement is composed of metamorphic and
igneous rocks. The metamorphic rocks are in the main slightly metamorphosed sediments
with hydrocarbon storage exclusively in fractures (Landes, 1959). Their age is uncertain,
possibly Silurian-Devonian. The igneous rocks are granitic and are believed to be Hercynian
in age. Cores of the basement show intense vertical fracturing and core recovery is often
poor. By 1956, the Mara field was producing from 29 wells in the basement reservoir at an
average depth of 1,190 ft (363 m). Initial production was about 2,700 bbl/day but one well
produced 17,000 bbl/day from the basement (Landes et al, 1960).
Although the oil in both the Cretaceous and basement is practically identical, bottomhole
pressure measurements in the Mara field indicate separate reservoirs. It is possible that the
well cemented basal sandstone or a 90 ft thick (27 m) marl and shale horizon, which occurs
about 76 m above the basement, may have acted as a partial seal.

Version 10

October 2012

GeoScience Limited
In J uly 1955, the Mara and La Paz basement reservoirs together were producing 77,000
bbl/day. The cumulative production for both the La Paz and Mara field by the end of J uly
1955 was over 31 million barrels.
La Vela Offshore Field
The La Vela Offshore Field is on the Northeast coast of the Paraguana Peninsula in Falcon
State. A total of 28 wells were drilled between 1972 and 1994, proving reservoirs in fractured
basement and overlying Tertiaries at depths up to 10,000 ft.
Vietnam
Cuu Long Basin
Exploration initiated in the 1970's resulted in the discovery of several oil and gas fields
(Dmitriyevskiy et al, 1993; Areshev et al, 1992) including White Tiger (Bach Ho), Dragon
(Rong) and Rang Dong fields. White Tiger has been a major producer and is the subject of a
recent paper by Cuong and Warren (2009) which covers the geology and production
characteristics. As of 2005 the basin represented 95% of total hydrocarbon production in
Vietnam, with 85% being produced from the fractured basement.
Vietsovpetro started producing oil from offshore S Vietnam in 1986. By the end of 1991,
about 100 wells had been drilled (85% of them by Vietsovpetro). Half the wells penetrated
the basement with cores recovered from 26 wells (mostly from White Tiger). By the mid-
1990's, the company was producing 180,000 bbl/day with 8,000 bbl/day from Dragon field
basement (George, 1995).
Recent production rates for White Tiger are listed at 202,000 bbl/d in 2004 (PESGB, J an.
2005) but declining to 140,000 bbl/d in 2009 (Cuong and Warren 2009), with a 25,000 bbl/d
decline between 2007 and 2008. The volume in place has been calculated at 1.59 billion
barrels of oil, with around 95% of this amount contained within the fractured basement.
In 1988, while testing in White Tiger (Well MSP-1-1), an oil flow of 1,500 m
3
/day was
achieved. The basement was then identified as an oil reservoir of significant importance.
Further drilling into the basement was undertaken, especially in the northern and central
blocks of White Tiger. The White Tiger area is divided into three fault-bounded blocks;
northern, central and southern. The basement was not penetrated in the southern block.
Traces of oil were also found in the basements of the Big Bear (South Con Son basin),
Dragon and Bavi (Areshev et al, 1992).
Granites constitute the basement in the central part of White Tiger and predominate in the
basement of the Dragon field. They also occur in the basement of the White Tiger northern
block, together with microcline, hornblende-biotite and biotite-granodiorites. Microcline,
hornblende-biotite and biotite-granodiorites also occur in the basement of the Bavi and Big
Bear structures.
The basement rocks of the southern Vietnamese shelf contain very large oil accumulations.
The White Tiger oil field is at a depth of 5,000 m, of which 4,000 m is fractured basement
granite with a pay zone interval of 1,000 m (Russell, 1997).
Well 17-VT-1XR (Vau Thieu), located in Block 17 offshore Vietnam (southwest of the White

Version 10

October 2012

GeoScience Limited
Tiger and Dragon oil fields), was originally drilled as an exploration well. The well was the
fourth exploration well to be drilled by Enterprise Oil in Block 17 (Anon, 1996a). The first 3
wells proved to be disappointing, especially when considering their proximity to the White
Tiger and Dragon oilfields (Anon, 1996a).
Well 17-VT-1XR was drilled to a TD of 2,389 m and was tested at 750 bbl/day of oil. The well
penetrated 430 m into the basement granite in the Cuu Long Basin (Enterprise Oil, 1996;
Anon, 1996b) and was abandoned as an oil discovery (Tang, 1996).
SOCO International achieved success in the SE Vietnam continental shelf, with Blocks 9-2
and 16-1 proving to be extremely fruitful. The Ca Ngu Vang discovery well was drilled in
2002 and encountered an oil column over 1000 m in height, mainly within a granitic basement
unit between 3696 m and 4567 m in depth. Testing in the discovery well recorded a flow of
3100 b/d of oil and 7.9 MMcf/d of gas. The subsequent appraisal well (spudded on 29
th

J anuary 2005) was drilled to 6000 m, with an 80 deviation to intersect the various fracture
orientations that exist in the basement (SOCO press-release, 23/07/03). A barefoot
production test carried out in this well had disappointing results, with the testing results of the
discovery well unable to be matched. No natural flow was recorded.
The Voi Trang vertical exploration well in Block 16-1 flowed 3500 b/d of 42 API crude from
the Oligocene and basement between 2086 and 2490 m. 250 b/d were produced from the
basement (SOCO press-release, 24/03/03)
Blocks 9-2 and 16-1 have provided several successful basement oil plays. Discoveries in the
Cuu Long basin include the Su Tu Den (Black Lion) field, with an estimated 200 MBBl of oil in
a granite reservoir, currently (2005) producing 10,000 bbl/d of 36 API crude from seven
production wells. The Su Tu Vang (Golden Lion) field also lies within the Cuu Long Basin,
with an estimated reserve of 100-400 MBBl of oil within the basement and Lower Miocene
sandstones (ConocoPhillips press-release, 18/11/03. In-depth analyses have discovered the
oil within the basement and the oil within the overlying sandstones to be virtually identical.
Migration models suggest that hydrocarbons migrate updip through faults into basement
horst blocks (Nielsen, L. & Abatzis, I., 2003).
Further major fields within the Cuu Long Basin include: the Sunrise field, NE of White Tiger,
also composed of fractured basement reservoirs, producing 60,000 bopd; The Black Lion
Field, a mixture of fractured basement reservoirs and Oligocene/Miocene sandstones with
approximate reserves estimated at 1730 million barrels of oil and 85 million cubic metres of
gas and the Ruby Field, dominantly Miocene sandstones and Oligocene volcanics, producing
20,000 bpod. Production in the Black Lion field is carried out by PetroVietnam Exploration
Production (50%), ConocoPhillips (23.25%), SK Corporation (9%) and Geopetrol (3.5%).
Nam Con Son Basin
The Nam Con Son Basin, which lies directly SSE of the Cuu Long Basin and contains similar
plays, was estimated to contain 4.5 Bboe equivalent to 20% of the countrys total
hydrocarbon reserves. It includes the Dai Hung Field (Big Bear), discovered in 1988 in Block
5-1A and which contains significant accumulations of oil and gas in a fractured granitic
basement (up to 100 million tonnes of oil), sourced from lacustrine shales. It was producing
around 25,000 bbl/d in the mid-1990s but had declined to 5400 bbl/d by the early 2000s
(Cuong and Warren 2009). In the mid-90s it had been forecast to produce 250,000 bbl/d.

Version 10

October 2012

GeoScience Limited
Other producing fields in the Nam Con Son Basin include the Lan Tay and Lan Do gas fields.
Combined estimated output from these fields is 95 billion cf/year, with an expected life span
of 20 years. The Hai Thach and Moc Tinh Fields also produce gas from the Cainozoic granite
basement (Petrovietnam press-release, 04/10/02)
Song Hong Basin
A largely unexplored basin with only a few wells, situated N-E of the Phu Khanh Basin.
Hydrocarbon reserves here are being exploited by Gazprom. The basin mainly produces
type III kerogen and is widely regarded as gas prone.
Gazprom are exploiting hydrocarbon reserves in the north of the Vietnamese continental
shelf. The Song Hong Basin formed in the Late Cretaceous to Early Tertiary is thought to
contain 10% of the countrys total hydrocarbon resources, with an estimated 2.5 Bboe in
place. The area represents a north-west/south-east trending rift zone, with dominant
hydrocarbon reservoirs likely to be buried basement hills and overlying sandstone formations.
20 Tcf of gas is thought to be contained within Block 112, with fields including Bach Chi
(White Lion), Zebra, Sky Lark, Seagull, Hangbird and White Elephant (Nielsen & Abatzis,
2003).
Phu Khanh Basin
The Phu Khanh Basin is the least explored Vietnamese hydrocarbon resource or potential
resource. It is situated offshore southern Central Vietnam in the narrowest part of the South
China Sea, south of the Song Hong basin and north of Cuu Long. There is currently no
production being carried out within the Phu Khanh Basin. However, evidence from oil seeps
in the nearby Dam Thi Nai lagoon (separated by a 700m wide fractured granite horst)
indicates an active petroleum system within the Phu Khanh Basin. Fyhn et al., 2009 suggest
that this basin could be a promising hydrocarbon play with both mature and post mature
potential source rocks within the area, from Miocene carbonates and sand deposited facies in
the east and fractured basement highs in the west.
Yemen
Yemen has attracted much interest from the oil community in recent years, with hydrocarbons
being discovered in both conventional and unconventional reservoirs. The geology of Yemen
is closely linked to the break-up of Gondwana during the Mesozoic (Harris et al., 2003). Major
rift basins, orientated north-northwest, south-southeast, developed during the Late J urassic
and Early Cretaceous. Thick accumulations of sediments were deposited in the basin areas,
overlying the igneous and high-grade metamorphic basement.
Exploratory drilling in Yemen began in 1961, with the first commercial oil discovery being
made in 1984 by Hunt Oil Co. in the Marib Al J awf Basin, western Yemen (Harris et al.,
2003). Production is mainly from the Cretaceous Quishn Sandstone unit, however another
dominant play is focussed on the fractured basement.
Kharir field
SOCO have been developing Kharir Field in the East Shabwa Block 10/10A, with four
deviated appraisal wells drilled since August 2004. The primary drilling target was the
fractured basement, with secondary targets lying in the overlying sedimentary sequence. As

Version 10

October 2012

GeoScience Limited
of 2005 production from the East Shabwa Development Area was 27,800 bo/d, with some
30% of this figure being produced from the basement (SOCO International press-release,
18/02/05 and 07/04/05).
Well KHA-401 was spudded on the 17
th
August, 2004 and drilled to a total depth of 3873 m.
Oil shows were encountered in two thin Cretaceous zones, and in 340 m of basement.
Testing revealed an uneconomic flow, and the well was plugged and abandoned in October
2004 (SOCO press-releases, 18/02/05 and 07/04/05).
Well KHA-402 was spudded on the 17
th
October 2004 and drilled to a total depth of 3441 m.
Following casing and long-term testing, flow stabilised at a rate of 710 bbl/d (SOCO press-
releases, 18/02/05 and 07/04/05).
Well KHA-403 was spudded on the 6
th
December 2004, with the purpose of delineating the
basement reservoir and evaluating possible reservoir development in the western extremes
of the structure (previously undrilled). The well was drilled to a total depth of 3383 m, and
produced a flow of 6500 bbl/d. The well is now connected to Kharirs main production facility
(SOCO press-releases, 18/02/05 and 07/04/05)
Well KHA-404 was spudded on the 1
st
February 2005, and drilled to a total depth of 3539 m.
Production tests carried out on the basement flowed 5500 bbl/d, with the well being
subsequently joined to Kharirs main production facility.
DNO have also had significant successes in Block 43. The Nabrajah wells have targeted both
the Qishn Formation sandstone and the Kohlan Formation dolomite, however significant
hydrocarbons have also been discovered in the basement. Production tests carried out in the
basement lithology flowed 5800 b/d of 38.6 API crude and 4162 Mscf/g of gas using an ESP.
Following a pressure build-up test, flow was 2812 b/d of 41.9 API crude, and 3054 Mscf/d of
gas with no pumping. Oil is also being produced from the basement in the neighbouring
Blocks 10 and 14 operated by Total and Nexen respectively (DNO press-release,13/04/05)
Many other basement exploration and development projects are underway as of 2012,
including OMV in Block S2 (de Kok et al 2009), Oil Search in Blocks 3 and 7 and J anah Hunt
in Block 5.
Habban Field
Situated in west-central Yemen, the Habban Field lies in the Arabian-Nubian Shield (670-
540Ma). Fracturing of the high grade gneiss or low-grade island arc basement rocks, allows
hydrocarbons to laterally migrate, creating a potential hydrocarbon reservoir in the crystalline
basement (Veeningen et al., 2012).

Updated October 2012



Version 10

October 2012

GeoScience Limited
REFERENCES

Akbar, M. Nurmi, R. Standen, E. Sharma, S. Panwar, P. Chaturvedi, J . G. and Dennis, B.
(1993). Middle East Well Review. No. 14. Pp. 27-43.

Aguilera,R. (1980). Naturally Fractured Reservoirs. Pennwell, Tulsa, OK., USA.

Aguilera,R. (1995). Naturally Fractured Reservoirs (Second Edition). Pennwell, Tulsa, OK,
USA.

Aguilera,R. (1995a). Naturally Fractured Reservoirs (Second Edition). Pennwell,Tulsa, OK,
USA, pp.59-60.

Aguilera,R. (1995b). Naturally Fractured Reservoirs (Second Ed.). Pennwell,Tulsa, OK,
USA, pp.61-63.

Aguilera,R. (1995c). Naturally Fractured Reservoirs (Second Ed.). Pennwell, Tulsa, OK,
USA, pp.447-448.

Aguilera R. (1996). Servipetrol Technical Notes on the Subject of 'Naturally Fractured
Reservoirs'. Technical Note No.3 - Undiscovered Naturally Fractured Reservoirs.
August.

Aguilera, R. (2000) Oil Production from Volcanics. www.agt.net/public/aguilera/oldtech.htm.

Aguilera,R., van Poollen,H.K. (1979). Naturally Fractured Reservoirs - 12. Studies Show
Occurrence of Fractured Reservoirs. The Oil and Gas J ournal, Vol.77, 21
st
May,
pp.70-76.

Anon (1995). Development Studied for Gas Field Off India. Oil & Gas J ., 6
th
Nov., pp.28-29.

Anon (1996a). International Update. Euroil, Vol.7, Iss.10, 10
th
Oct.

Anon (1996b). International Update. Euroil, Vol.7, Iss.11, Nov., 43.pp.

Anon (1997). Old Guard Stands Firm in Vietnam While Others Sound Retreat. Offshore,
Mar., 110.pp.

Areshev,E.G., Dong.L.E., San.N.T., Shnip,O.A. (1992). Reservoirs in Fractured Basement
on the Continental Shelf of Southern Vietnam. J . of Petroleum Geology, Vol.15, No.4,
Oct., pp.451-464.

Bailey, L., (UNOCAL Alaska). Personal Communication with Roberto Aguilera, 16
th
March,
1998. After www.agt.net/public/aguilera/oldtech.htm.

Bankwitz, P. & Bankwitz, E. (2004). The relationship of tilt and twist of fringe cracks in granite
plutons. Geological Society Special Publication, 231, pp 183-208.

Barr D, Savory K.E., Fowler S.R., Arman K. and McGarrity J .P. (2007). Pre-devlopment
farcture modelling in the Clair Field, west of Shetland. In: Lonergan L., J olly R.,
Rawnley K and Sanderson D.J . (Eds), Fractured Reservoirs. Geol. Soc. Lond. Spec
Pub. N0 270, pp 205-226.

Version 10

October 2012

GeoScience Limited
Belgasem,B.A., Barlai,Z. Rez,F. (1990). Interpretation of Well Logs in the Oil-Bearing
Reservoir, Nafoora-Augila Field, Libya. In: Proceedings 13
th
European Formation
Evaluation Symposium Transactions: Society of Professional Well Log Analysts,
Budapest Chapter, Paper No.OO, 1-23.

Belgasem,B.A. (1991). An Evaluation of an Oil-Bearing Granite Reservoir from Well Logs. In:
Proc. 13
th
Formation Evaluation Symp. Trans.:Canadian Well Logging Society, Paper
K, pp.1-28.

Bergman,S., Talbot,J .P. Thompson,P.R. (1992). The Kora Miocene SubmarineAndesite
Stratovolcano Hydrocarbon Reservoir, Northern Taranaki Basin, New Zealand. New
Zealand Oil Exploration Proc., pp.178-206.

Bojesen-Koefoed, J . A. Nytoft, H. P. and Thi Dau, N. (2009). Marine and Petroleum Geology.
Vol 26. Pp. 899-908.

Brenner, S.L. & Gudmundsson, A. (2004). Arrest and aperture variation of hydrofracture in
layered reservoirs. Geological Society Special publication, 231, pp 117-128.

British Consulate General (1996). Vietnam Market Summary: Oil, Gas and Petrochemicals.
Dec.

Brown,A.B. Kew,W.S.W. (1932). Occurrence of Oil in Metamorphic Rocks in San Gabriel
Mountains, Los Angeles County, California. Ibid, Vol.16, No.8, pp.777-785.

Cabeen,W.R. Sullwood,H.H. (1946). California Basement Production Possibilities. Oil
Weekly, 22
nd
J un., pp.17- 25.

Cai-neng, Z. Wen-shi, Z. Cheng-zao, J . Ru-kai, Z. Guang-ya, Z. Xia, Z. Xuan-jun, Y. (2008).
Formation and distribution of volcanic hydrocarbon reservoirs in sedimentary basins
of China. Petroleum Exploration and Development. Vol 35 (3). Pp. 257-271.

Coney,D., Fyee,T.B., Retail,P. Smith,P.J . (1993). Clair Appraisal: The Benefits of a Co-
operative Approach. In: Proc. 4
th
Conference Petroleum Geology of Northwest
Europe, pp.1409-1420.

Cuong T.X. and Warren J .K. (2009). Bach Ho field, a fractured granitic basement reservoir,
Cuu Long Basin, offshore SE Vietnam: a buried hill play. J . Petroleum Geol., V 32,
No 2, pp 129-156.

Dean,J .S., Wilson,J .T., Mainzer,G.F., Escobar,F. Agurrie,G. (1993). Preliminary Assessment
of the Lago Mercedes Discovery, Magallanes Basin, Chile. AAPGB, Vol.77/2, 313.pp.

DeGolyer,E. (1915). The Effect of Igneous Intrusions on Accumulations of Oil in the
Tampico-Tuxpam Region, Mexico. Econ. Geol., Vol.10.

DeGolyer.E. (1932). Oil Associated with Igneous Rocks in Mexico. AAPG, Vol.16, No.8,
pp.799-808.

De Kok J ., Neff P. and Clemens T. (2009). Oil recovery from a tight fractured basement field.
In: 71
st
EAGE Connference and Exhibition, Amsterdam, J une 2009. SPE-121107.


Version 10

October 2012

GeoScience Limited
Dmitriyevskiy,A.N., Kireyev,F.A., Bochko,R.A. Fedorova,T.A. (1993). Hydrothermal Origin of
Oil and Gas Reservoirs in Basement Rock of the South Vietnam Continental Shelf.
International Geology Review, Vol.35, No.7, pp.621- 630.

Durglishvili, G., Sharikadze, M., Suramelashvila, Z., Tavdumadze, I., Wall, G. (2004).
Fractured Reservoir International Conference, 16/17 Nov. 2004. Geological Society,
London.

Engelder, T. & Delteil, J . (2004). The orientation of single joint sets. Geological Society
Special Publication, 231, pp 285-297.

Eggleston,W.S. (1948). Summary of Oil Production from Fractured Rock Reservoirs in
California. AAPG Bull., J ul., pp.1352-1355.

El Hamalawy,F.A., Elsayed,G.A., Sweden,N.E.M. Barden,I.R. (1993). A Conventional
Reservoir Engineering Approach for Managing a Difficult Field. In: Proc. 68
th
Annual
Technical Conf. and Exhibition of the SPE, Houston, Texas, 3
rd
-6
th
Oct., pp.355-369,
(SPE 26405).

Enterprise Oil (1996). Annual Report and Accounts.

Falt,U., Guerin,G., Retail,P., Evans,M. (1992). Clair Discovery: Evaluation of Natural
Fracturation in a Horizontal Well Drilled in the Basement and Producing From
Overlying Sediments. In: Proc. European Petroleum Conf., Cannes, France, 16
th
-18
th

Nov., pp.11-21, (SPE 25016).

Fetter, m. De Ros, L. F and Rruhn, C. H. L. (2009). Petrographic and seismic evidence for
the depositional setting of giant turbidite reservoirs and the paleogeographic evolution
of Campos Basin, offshore Brazil. Marine and Petroleum Geology. Vol 26. Pp. 824-
853.

Filjak,R. (1969). Geology of Petroleum and Natural Gas from the Neocene Complex and Its
Basement in the Southern Part of the Pannonian Basin, Yugoslavia. The Exploration
for Petroleum in Europe and North Africa, London.

Flawn,P.T. (1965). Basement - Not the bottom but the beginning. AAPG, Vol.49, No.7, J ul.
pp.883-886.

Fyhn, M. B. W. Nielsen, l. H. Boldreel, L. O. Thang, L. D. Bojesen-Koefoed, J . Petersen, H. I.
Huyen, N. T. Duc, N. A. Dau, N. T. Matheisen, A. Reid, I. Huong, D. T. Tuan, H. A.
Hien, L. V. Nytoft, H. P. and Abatzis, I. (2009). Geological evolution, regional
perspectives and hydrocarbon potential of the northwest Phu Khanh Basin, offshore
Central Vietnam. Marine and Petroleum Geology. Vol 26. Pp.1-24.


George,D. (1995). PetroVietnam's Ho Si Thoang Outlines Successes, Predicts Future Gas
Industry. Offshore, Nov. pp.39-40.

Ghorayeb, K. Anraku, T. and Firoozabadi, A. (2000). Interpretation of the Fluid Distribution
and GOR Behaviour in the Yufutsu Fractured Gas-Condensate Field. Society of
Petroleum Engineers. 59437.


Version 10

October 2012

GeoScience Limited
Gibson,D. (1997). Some Interesting Oil Industry Statistics. Gibson Consulting.

Gold,T., Soter,S. (1980). The Deep-Earth-Gas Hypothesis. Scientific American, Vol.242(6),
pp.130-137.

Gold.T. (1985). The Origin of Natural Gas and Petroleum and the Prognosis for Future
Supplies. Ann. Review of Energy, Vol.70, No.1, pp.53-77.

Grynberg,M.E., Papava,D., Shengelia,M., Takaishvili,A., Nanadze,A., Patton,D.K. (1993).
Petrophysical Characteristics of the Middle Eocene Laumonitite Tuff Reservoir,
Samgori Field, Republic of Georgia. J . of Petrophysical Geology, Vol.16(3), pp.313-
322.

Guangming,Z. Quanheng,Z. (1982). Buried-Hill Oil and Gas Pools in the North China Basin.
AAPG Memoir 32, The Deliberate Search for the Subtle Trap, pp.317-335.

Harrelson,D.W. (1989). Hydrocarbon Occurrences in Igneous and Metamorphic Rocks: The
Plays of the 1990's. Trans. Gulf Coast Association of Geological Societies.
Vol.XXXIX.

Harris, R., Cooper, M., Shook, I. (2002). Focusing Oil and Gas Exploration in Eastern Yemen
by using Satellite Images and Elevation Data along with Conventional 2D Seismic.
World Oil, November 2002.

Howell, J . A. Schwarz, E. Spalletti, L. A. and Veiga, G. D. (2005). The Neuqun Basin: an
overview. Geological Society, London, Special Publications. Vol 252. Pp. 1-14.

Hubbert,M.K. Willis,D.G. (1955). Important Fractured Reservoirs in the United States. In:
Proc. 4
th
World Petroleum Congress, Rome, SectionI/A-1, pp.57-81.

Hunt,C.W. (1998). Anhydride Theory - A New Theory of How Petroleum and Coal are
Generated. Does Coal Generate Methane? Or Does Methane Generate Coal? (1998).
Private Communication, Mar.

J acques, J .M. (2003). A Technostratigraphic Synthesis of the Sub-Andean Basins:
Implications for the geotectonic segmentation of the Andean Belt. J ournal of the
Geological Society, September 2003.

J ohnsonn K. S. and Campbell J . A. (1997). Ames structure in northwest Oklahoma and
similar features: Origin and petroleum production (1995 symposium). Oklahoma
Geological Survey Circular 100. Norman, OK, United States: University of Oklahoma.
396 p.

Kaijun, T. Chunming, Z. Zuobin, L. Yingchun, Z. Hao, Z. Sainan, X. jianli, W. and Lingli, P.
(2012). Reservoir evaluation and fracture characterization of the metamorphic buried
hill reservoir in Bohai Bay Basin. Petroleum Exploration and Development. Vol 39. (1).
Pp. 62-69.

Kalan,T., Sitorus,H.P., Eman,M. (1994). J atibarang Field, Geologic Study of Volcanic
Reservoir for Horizontal Well Proposal. In: Proc. 23
rd
Ann. Convention, Indonesian
Petroleum Assoc., J akarta, Paper IPA94-1.1-186, pp.229-244.


Version 10

October 2012

GeoScience Limited
Kenney,J .F. (1996). Private Communication, J un.

Khalil,M.M. Pigaht,J . (1991). Petrophysical Approach to Description of a Producing Fractured
Basement Reservoir. In: Proc. SPE Middle East Oil Show, Bahrain, 16
th
-19
th
Nov.,
pp.903-914. (SPE 21444).

Khalil,M.M., Pigaht,J ., El Wazeer,F.M. (1993). Comparison of Petrophysical Method for
STOIIP in a Refined Estimation of Fractured Basement Reservoir. In: Proc. SPE
Middle East Oil Tech. Conf. & Exhib., Bahrain, 3
rd
-6
th
Apr., pp.453-463. (SPE 25653).

Kikuchi, Y. Tono, S. and Funayama, M. (1991). Petroleum resources in the J apanese island-
arc setting. Episodes. Vol 14. Pp. 236-241.

Kiss,B. Tth,J . (1985). Well Log Interpretation of Metamorphic Hydrocarbon-Bearing
Formations. EAEG Conf. Issue, First Break, Vol.3, No.5, May, pp.24-31.

Knox,G.J ., Wakfield,L.L. (1983). An Introduction to the Geology of the Phitsanulok Basin.
Conf. On Geology and Mineral Resources of Thailand, Bangkok, 19
th
-28
th
Oct.
Koning, T. (2003). Oil and gas production from basement reservoirs: examples from
Indonesia, USA and Venezuela. Geological Society of London, Special Publications.
Vol 214. Pp. 83-92.

Koning,T., Darmono,F.X. (1984). The Geology of the Beruk Northeast Field, Central
Sumatra: Oil Production from Pre-Tertiary Basement Rocks. In: Proc. Indonesian
Petroleum Assoc., 13
th
Ann. Convention, May, pp.385- 406.

Krayushkin,V.A., Tchebanenko,T.I., Klochko,V.P., Dvoryanin,Ye.S., Kenny,J .F. (1994).
Recent Applications of the Modern Theory of Abiogenic Hydrocarbon Origins: Drilling
& Development of Oil & Gas Fields in the Dneiper-Donets Basin. In: Proc. 7
th
Int.
Symp. on the Observation of the Continental Crust Through Drilling, Santa Fe, New
Mexico, DOSECC, pp.21-24.

Krishna,R.E. (1988). New Insight Into the Origin of Petroleum Hydrocarbons. J . Institute of
Engineering (India), Chemical Eng. Division., Vol.69(1), pp.10-14.

Kropotkin,P.N. (1986). Earth's Outgassing and Genesis of Hydrocarbons. J . of All-Union
Mendeleyev's Chem. Soc., Vol.31(5), pp.60-67.

Landes,K.K. (1959). Pet. Geology, Second Ed., J ohn Wiley & Sons, Inc.

Landes,K.K., Amoruso,J .J ., Charlesworth,L.J ., Heany,F. Lesperancep,J . (1960). Pet.
Resources in Basement Rocks, AAPG Bull., Vol.44, No.10, Oct., pp.1682-1691.

Lardenois,J .M., Levy,R.G., Rametti,C.J . (1956). Gisements de Petrole du Maroc. In: 20
th
Int.
Geol. Cong., Petroleoez Gas, Symp. T1, pp.191-212.

Lash, G., Loewy, S. & Engelder, T. (2004). Preferential jointing of Upper Devonian black
shale, Appalachian Plateau, USA: evidence supporting hydrocarbon generation as a
joint driving mechanism. Geological Society Special publication, 231, pp 129-151.

Lee,K.Y. (1989). Geology of Petroleum and Coal Deposits in the North China Basin, Eastern
China. USGS Bull., Vol.1871, 36.pp.

Version 10

October 2012

GeoScience Limited
Lewis, J , W. (1932). Occurrence of oil in Igneous Rocks of Cuba. Bulletin of the American
Association of Petroleum Geologists. Vol 16 (8). Pp. 809-818.

Marchal, D., Guiraud, M., Rives, T. & Den Driessche, J . (1998). Space and time propogation
processes of normal faults. Geological Society Special Publication, 147, pp 51-70.

Massonat,G., Guerine,G., Retail,P. Casey,B. (1993). Oil Recovery Through a Horizontal Well
in a Fractured Granitic Basement. AAPG Bull., Vol.77, No.9, 1645.pp.

Matthews, S. J . Fraser, A. J . Lowe, S. Todd, S. P. and Peel, F. J . (1997). Geological Society,
London. Vol 126. Pp. 89-106.

Matyas,J . (1996). Personal Communication to A.S.Batchelor.

McKenny, J .W. & Masters, J .A. (1968). Dineh-Bi-Keyah Field, Apache County, Arizona.
AAPG Bulletin, October 1968, V. 52, No. 10, pp 2045-2057.

McNaughton,D.A. (1953). Dilatancy in Migration and Accumulation of Oil in Metamorphic
Rocks. Bull. AAPG, Vol.37, No.2, Feb. pp.217-231.

McNaughton,D.A. Garb,F.A. (1975). Finding and Evaluating Petroleum Accumulations in
Fractured Reservoir Rock. Exploration and Economics of the Pet. Industry, Vol.13,
Matthew Bender & Co. Inc., pp.23-49.

Mosquera, A. (2004). Oil Play in the Pre-Cuyo Basement of the Huincul High, Los Bastos
Block, Southern Neuquen Basin, Argentina. AAPG Annual General Meeting, 2004.

Nelson,R.A. (1979). Natural Fracture Systems: Description and Classification. AAPG Bull.,
Vol.63, No.12, pp.2214-2221.

Nelson,R.A. (1982). An Approach to Evaluating Fractured Reservoirs. J . Pet. Tech. Sep.,
pp.167-2170.

Nelson,R.A. (1985). Geologic Analysis of Naturally Fractured Reservoirs. Gulf Publishing Co.
Book Division, pp.1-3.

Nelson, R.A. (2001). Geologic Analysis of Naturally Fractured Reservoirs. Gulf Publishing Co.
Book Division, 2
nd
Edition, 332.pp.

Nielsen, L.H., Abatzis, I. (2003). Petroleum potential of sedimentary basins in Vietnam; long-
term geoscientific co-operation with the Vietnam Petroleum Institute. Geological
Survey of Denmark and Greenland Bulletin, Nr.4, Review of Survey Activities, 2003,
pp 97-100.

North,F.K. (1990). Petroleum Geology. Second Ed., Unwin Hyman, Boston, pp.216-217.

P'an,C.H. (1982). Petroleum in Basement Rocks. AAPG Bull., Vol.66, No.10, Oct., pp.1597-
1643.

Petersen, H.I. Nytoft, H. P. and Neilsen, L. H. (2004). Characterisation of oil and potential
source rocks in the northeastern Song Hong Basin, Vietnam: indicators of a

Version 10

October 2012

GeoScience Limited
lacustrine-coal sourced petroleum system. Organic Geochemistry. Vol 38. (4). Pp.
493-515.

Phuong Tung, N., Hung, P.V., Vinh, N.Q., Long, B.Q.K., Phong, N.T.P. (2003) Perspective for
using Nd-Fe-B magnet as a tool for the improvement of the production and
transportation of Vietnamese crude oil with a high paraffin content. Physica B, 327, pp
443-447.

Pine,R.J ., Batchelor,A.S. (1984). Downward Migration of Shearing in J ointed Rock During
Hydraulic Injections, Int. J . of Rock Mechanics and Mining Science and
Geomechanical Abstracts, pp.249-265.

Plotnikova, I. N. (2006). Nonconventional hydrocarbon targets in the crystalline basement,
and the problem of the recent replenishment of hydrocarbon reserves. J ournal of
Geochemical Exploration. Vol 89. Pp. 335-338.

Plotnikova, I. N. (2009). Fractured Reservoirs and Crustal Fluids in the PreCambrian
Basement of the Volga-Ural Region. Geophysical Research Abstracts. Vol 11.

Porfir'ev,V.B. (1974). Inorganic Origin of Petroleum. AAPG Bull., Vol.58(1): 3-33.

Powers,S., Clapp,F.G. (1932). Nature And Origin of Occurrences of Oil, Gas, and Bitumen in
Igneous and Metamorphic Rocks. AAPG, Vol.16, No.8, pp.719-726.

Rajmon D (2005). Pers.Comm (email to GeoScience May 2005).

Reisser,K. (1996). Personal Communication to GeoScience.

Roberts,J .M. (1970). Amal Field, Libya. AAPG Memoir, Vol.14, pp.438-448.

Robertson,J .A., Blesener,J .A. Soo Hoo,S. (1987). Subzone Redevelopment of the Long
Beach Unit, Wilmington Oil Field: A Case Study. J . Pet. Tech. Oct., pp.1229-1236,
(SPE 15101).

Rocho Mello, M. Azambuja, N. Mohriak, W. Catto, A. and Francoli, J . (2011). Promising Giant
New Hydrocarbon Frontier: The Nambian Continental Margin. GeoExPro. Issue 6. Vol
8.

Rogers, K. L. Neuhoff, P. S. Pedersen, A. K. and Bird, D. K. (2006). CO
2
metosomatism in a
basalt-hosted petroleum reservoir, Nuussuaq, West Greenland. Lithos. Vol 92. Pp.
55-82.

Russell,R.O. (1995). Oil in Granite. Oil & Gas J ., 6
th
Feb.

Russell,R.O. (1997). Personal Communication.

Salah,M.G. Alsharhan,A.S., (1998). The PreCambrian Basement: A Major Reservoir in the
Rifted Basin, Gulf of Suez. J . Pet. Science and Engineering, 19, pp.201-222.

Sembodo (1973). Notes on Formation Evaluation in the J atibarang Volcanic Reservoir. In:
Proc. Indonesian Pet. Assoc., 2
nd
Ann. Conv., J un., pp.131-147.


Version 10

October 2012

GeoScience Limited
Shellard,E.H. (1931). Oil Fields in Igneous Rocks in Coastal Plain Of Texas. AAPG, Vol.16,
No.8, pp.741-768.

Sitdikova, L. M. and Izotov, V. G. (2006). Formation of hydrocarbon reservoirs in the deep
Earths crust. J ournal of Geochemical Exploration. Vol 89. Pp. 373-375.

Smith,J .E. (1956). Basement Reservoir of La Paz-Mara Oil Fields, Western Venezuela.
AAPG Bull., Vol.40, Feb., pp.380-385.

Snow,J .H. (2001). http://minerals.state.nv.us

Soewono, Setyoko (1987). Application of the Dual Porosity Concept for Well Log
Interpretation of J atibarang Volcanic Tuff. In: Proc.16
th
Ann. Conv., Indonesian Petr.
Assoc., J akarta.Paper IPA 87-22/10, Vol.2, pp.87-106.

Stearns,D.W. Friedman,M. (1972). Reservoirs in Fractured Rock. AAPG Memoir 16, pp.82-
100.

Steen, O., Sverdrup, E. & Hanssen, T.H. (1998). Predicting the distribution of small faults in a
hydrocarbon reservoir by combining outcrop, seismic and well data. Geological
Society Special Publication, 147, pp 27-50.

Szatmari,P. (1989). Petroleum Formation by Fisher-Tropsh Synthesis in Plate Tectonics.
AAPG Bull., Vol.73(8), pp.989-998.

Tang,P. (1996). Asia/Pacific - Vietnam Operators Making Discoveries. Offshore, Oct., 22.pp.

Tang,P. (1997). Asia/Pacific - Vietnam's Dai Hung Goes to Petronas Carigali. Offshore, Mar.,
14.pp.

Tiercelin, J -J . Potdevin, J -L. Morley, C. K. Talbot, M. R. Bellon, H. Rio, A. Le Gall, B. and
Vtel, W. (2004). Hydrocarbon potential of the Meso-Cenozoic Turkana Depression,
northern Kenya. I. Reservoirs: depositional environments, diagenetic characteristics,
and source rock-reservoir relationships. Marine and Petroleum Geology. Vol 21. Pp.
41-62.

Tiwar,S. Taruno,J . (1979). The Tanjung (South Kalimantan) and Sei TerasFields (South
Sumatra): A Case History of Petroleum in Pre-Tertiary Basement. In: Proc. of the
Committee for Co-ordination of J oint Prospecting for Mineral Resources in Asian
Offshore Areas (CCOP), 16
th
Session, 10-189, Bandung, Indonesia, pp.238-247.

Tull, S. J . (1997).The diversity of hydrocarbon habit in Russia. Petroleum Geoscience. Vol 3.
Pp. 315-325.

Uliana, M. A. Arteaga, M. E. Legarreta, L. Cerdan , J . J . and Peroni, G. O. (1993). Inversion
structures and hydrocarbon occurrence in Argentina. Geological Society Special
Publication. Vol 88. Pp211-233.

Ullah,S., Shen,T.Y., Mobarak,S.A., Carnes,A.C., Zhu,X.J ., Wu,Q.L., Houz,W., Wan,Z.M.,
Zhoa,C.L., Ding,F. (1988). Development Feasibility Study: Dong Sheng Pu Buried Hill
Reservoir. In Proc. SPE Int. Meeting on Petroleum Engineering, Tianjin, China, 1
st
-4
th

Nov., pp.273-284. (SPE 17577)

Version 10

October 2012

GeoScience Limited

Valchak, V. I. Evgrafov, A. A. Goryunov, N. A. and Babintsev, A. F. (2011). Geology and
petroleum potential of Riphean reservoirs in the southwestern Siberian craton.
Russian Geology and Geophysics. Vol. 52. Pp. 230-238.

Veeningen, R. Grasemann, B. Decker, K. Bischoff, R. and Rice, A. H. N. (2012). Fracture and
vein characterisation of a crystalline basement reservoir, central Yemen. Geophysical
Research Abstracts. Vol 14.

Villavicencio, B., Rodriguez de Villavicencio, M., Segura, R. (circa 1994). Evaluacion de
Rocas Vulcanogeno-sedimentarias en la Republica de Cuba.
www.agt.net/public/aguilera/oldtech.htm

Waldren,D. and Corrigan,A.F. (1985). An Engineering and Geological Review of the
Problems Encountered in Simulating Naturally Fractured Reservoirs. In: Proc. SPE
Middle East Oil Tech. Conf. & Exhib., Bahrain, 11
th
-14
th
Mar., pp.311-316. (SPE
13717)

Walters,R.F. (1946). Buried PreCambrian Hills in Northeastern Barton County, Central
Kansas. AAPG Bull., Vol.30, No.5, pp.660-710.

Walters,R.F. (1953). Oil Production from Fractured PreCambrian Basement Rocks in Central
Kansas. AAPG Bull., Vol.37, No.2, Feb., pp.300-313.

Walters,R.F., Price,A.S. (1948). Kraft-Prusa Oil Field, Barton County, Kansas. In: Structure
of Typical American Oil Fields, Vol.3, pp.249-280.

Wen-zhi, Z. Cai-neng, Z. Zhi-qiang, F. Su-yun, H. Yan, Z. Ming, L, Yu-hua, W. Tao, Y. and
Hui, Y. (2008). Geological features and evolution techniques of deep-seated volcanics
gas reservoirs, Songliao Basin. Petroleum Exploration and Development. Vol 35. (2).
Pp. 129-142.

Younes,A.I., Engelder,T., Bosworth,W. (1998). Fracture Distribution in Faulted Basement
Blocks: Gulf of Suez, Eygpt. M.P.Coward, T.S.Dalbatan, H.J ohnson (Eds.), Structural
Geology in Reservoir Characterisation, Geol. Soc., London, Special Publications, 127,
pp.167-190.

Zahran,I., Askary,S. (1988). Basement Reservoir in Zeit Bay Oilfield, Gulf of Suez. AAPG
Bull., Vol.72, No.2, 261.pp.

OTHER REFERENCES AND REVIEWS OF INTEREST (not cited in the text)

Allouani,R., Tremolieres,P., et al (1992). Le Gisement de Rourde el Baguel (Algerie):
Modelisation de la Fracturation Naturelle, Revue de IFP, Vol.47, No.4, pp.491-502

Almarza,R. (1992). Campos de La Paz - Mara, Petroleum (a Venezuelan J ournal), Dec.
No.56, pp.37-39.

Bakes, et al. Horizontal wells in Yemen Make a Marginal Field Economic. SPE paper 37058.


Version 10

October 2012

GeoScience Limited
Bert,A.K., Manwaring,M.S. (1987). Evaluation of New Completion Recommendation for
Fractured, Crystalline, Igneous Reservoir, Texas Panhandle. AAPG Bull., Vol.71,
No.2, 245.pp.

Boden,A., Eriksson,K.G. (1988). The Deep Gas Drilling in the Siljan Impact Structure,
Sweden, and Astroblemes in Series of Exploration of the Deep Continental Crust,
(Eds.), Vol.1, Springer-Verlag, Berlin, 364.pp.

Burima,B.A. (1996). Behaviour of SP Log in a Granite Reservoir, Geophysical Trans., (a
Hungarian J .), Vol.38, No.2-3, pp.167-189.

Chekunovm,A.V., et al. Oil and Gas Resources in the PreCambrian Basement of the East
European Platform, J . of Pet. Geology (in press, may be out of print now).

Dank,V. Petroleum Geology of the Pannonian basin, Hungary: An Overview, In: AAPG
Memoir 45, The Pannonian Basin - A Study in a Basin Evolution (L.H.Royden,
F.Horvath Eds.), pp.319-331.

George,D. (1996). Frontier Exploration: Remote and Deep Water Frontier Areas Seeing
More Exploration. Offshore, Apr., pp.40-44.

Guariguata,R.C., Richardson,S.A. (1960). Production Petrolifera del Basamento Enel Oeste
del Lago de Macaraibo. 3
rd
Cong. Ven. Geol. Mem., Tomo. 3, pp.985-1006.

Krayushkin,V.A. (1987). Oil and Gas in PreCambrian Rocks of the Dnieper-Donets Basin.
Translated from: O Neftegazononosnosti Dokembriyskikh Porod v Dneprovsko-
Donetskoy Vpadine. Doklady Akademi Nauk SSSR, Vol. 294, No.4, pp.931-933.
Khristoforova, N. N. and Khristoforov, A. V. (2006). Fluid migration and location of fractured
layers in crystalline basement by temperature logging in the Volga Region, Russia.
J ounal of Geochemical Exploration. Vol 89. Pp. 187-190.

Lukin,A.Ye. (1995). Natural Hydraulic Fracturing and Hydrogeological Inversion Phenomena
in Hydrocarbon Reservoirs at Great Depths. Geological J . of IGS NASU, Kiev, (1),
Nov. pp.61-66.

Murrey,G.E., Kaizoe,M.J ., McArthur,R.E. (1980). Indigenous PreCambrian Petroleum
Revisited. AAPG Bull., Vol.64, No.5, pp.597-618.

Pap,S., Soreg,V., Pap-Hasznos,I. (1992). Exploration of the Devavanya-Southbasement
Structure for Hydrocarbons - A Case History. Geophysical Trans., Vol.37, No.2-3,
pp.221-228.

Parnell, J . (1998). Migration of Biogenic Hydrocarbons into Granites: A Review of
Hydrocarbons in British Plutons. Marine and Petroleum Geology, Vol.5, Nov. pp.385-
396.
Pease, V. Dovzhikova, E. Beliakova, L. and Gee, D. G. (2004). Late Neoproterozoic granitoid
magmatism in the basement to the Pechora Basin, NW Russia: geochemical
constraints indicate westward subduction beneath NE Baltica. Geological Society,
London, Memoirs. Vol 30. Pp. 75-85.


Version 10

October 2012

GeoScience Limited
Petersilie,J .A., Sorensen,H. (1970). Hydrocarbon Gases and Bituminous Substances in
Rocks From Ulimaussaq Alkaline Intrusion, South Greenland. Gronlands Geologiske
Undersogelse Misc. Papers No.76, Kopenhagen, pp.59-76, (reprinted from lithos).

Saad,S.M., Darwich,T.D. (1995). Water Coning in Fractured Basement Reservoirs. SPE
Middle East Oil Show, Bahrain. 11
th
-14
th
Mar. SPE 29808.

Sandlin,G.L. (1992). Oil Production From Volcanic Rocks of the Balcanes Fault Region.
West Texas Geol. Soc. Bull., Vol.31, No.5, pp.5-9.

Schalla and J ohnson (Eds.) (1994). Oil Fields of The Great Basin. The Nevada Pet. Soc.

Sholten,R.B. (1950). Synchronous Highs: Preferential Habitat of Oil. AAPG Bull., No.8,
pp.138-144.

Sibbit,A.M. (1995). Quantifying Porosity and Estimating Permeability From Well Logs in
Fractured Basement Reservoirs. In: Proc. SPE Petro Vietnam '95, Ho Chi Minh City,
SR. Vietnam, 1
st
-3
rd
Mar. SPE 30157.

Smeiser,J .S., Wintermann,D. (1935). Character and Possible Origin of Producing Rocks in
Hilbig Oil Field, Bastrop County, Texas, USA. Bull. AAPG, Vol.19, pp.206-220.

Sullwold,H.H.,J r. (1957). Geology of West Edison Oil Field, Kern County, California, USA.
AAPG Bull., Vol.37, No.4, pp.797-820.

Taylor,S., Solomon,G., Tupper,N., Evanochko,J ., Horton,G., Waldeck,R., Phillips,S. (1991).
Flank Plays and Faulted Basement: New Directions for the Cooper Basin. The APEA
J ., Vol.31, pp.56-73.

Vanderhill,A., Berg,R.R. (1987). Depositional Environment and Reservoir Characteristics of
Middle Pennsylvanian Granite Wash, Northern Palo Durobasin, Oldham County,
Texas, USA. AAPG Bull., Vol.71, No.2, 244.pp.

Younes,A.I., Hurley,N.F. (1997). Characterisation of Fractured Basement Reservoirs (FBR).
AAPG Ann. Conv., Dallas, Texas, USA, 6
th
-9
th
Apr.


'Granite Production from the Bohai Bai field, China. (1985). Well Evaluation Conf.,
Schlumberger.

Symp. on Occurrence of Petroleum in Igneous and Metamorphic Rocks. (1932). AAPG Bull.,
Vol.16, No.8, pp.717-858.

A Preliminary Report on the Scientific Working Conf. on Oil in Granite held in Kazan,
Tatarstan, Russia. (1997). 18
th
-19
th
Dec. Featuring the Book: The Crystalline
Basement of Tatarstan and its Oil and Gas Potential. (1996). Eds. R.Kh.Muslimov,
T.A.Lapinskaya, Denta Publishing House, Kazan, 488.pp. Introduction and
Concluding Chapter translated and translations of Abstracts of 38 papers given in
Russian and 3 papers given in English.




Version 10

October 2012

GeoScience Limited
COMPANY WEBSITES

Amerada Hess [accessed 13/07/2012] - http://www.hess.com/operations/default.aspx
Clair Ridge - BP [accessed 26/07/2012]
http://www.bp.com/genericarticle.do?categoryId=2012968&contentId=7071792
ConocoPhillips [accessed 12/07/2012] -
http://www.conocophillips.com/EN/about/worldwide_ops/europe/Pages/UnitedKingdom.aspx
Offshore technology Kudu Gas Field, Orange Sub-Basin, Namibia. [accessed 26/07/2012]
- http://www.offshore-technology.com/projects/kudugasfieldnamibia/
Repsol: [accessed 23/07/2012] - http://www.repsol.com/es_en//default.aspx


Version 10

October 2012


Version 10

October 2012
GeoScience Limited
ABSTRACTS OF THE CONFERENCE PAPERS OF INTEREST INCLUDE:

8. The presence of oil and gas in the basement rocks in Timan ridge and Mesenskaya
syneclize, Russia. Teplov,E.L., Abramichev,A.P., "Uchtaneffegazgeologia" Uchta.

9. Thermal logging in exploration for reservoir zones in the crystalline basement.
Hairetdinov,R.S., Plotnikov,N.A. AO 'Tatneft' Almetievsk, AO 'Tatneftegoephysika',
Bugulma.

10. Using magnetic susceptibility and density data in crystalline basement rocks for
predicting the geological section. Stepanov,I.V., Stepanov,V.P., KGU, TGRU, Kazan.

11. The gabbro-diabasic Riphean formations of Tatarstan Republic as potential
hydrocarbon reservoirs. Nizamutdinov,A.G., Didenko,A.N., Kazan State University,
AO 'Tatneff'.

21. Anhydride theory: a new theory of how petroleum and coal are generated. Warren
Hunt,C., Anhydride Oil Corp., Canada.

24. Magnetic and petromagnetic characteristics of crystalline basement, Republic of
Tatarstan, Russia. Chernikov,A.P., Konduchina, GeologicalInstitute, Bashkir
Academy of Science, Ufa.

25. The tectonic structure of crystalline basement and its hydrocarbon potential in the
Tatarstan Republic, Russia. Stepanov,V.P, TGRU, Kazan.

28. Regional structure of crystalline basement based on complex analyses of gravity and
magnetic fields. Balashova,M.M., Chadaev,M.S. KAMMEGS Perm.

33. The physical and chemical properties of oils and their directions of migration in the
course of exploitation of the 'White Tiger' field, Vietnam. Kao Mi Loi, Xoang Din Tien,
Vietsovpetro, Vietnam.

34. South-Tatar arch: its oil and gas endowment and fault tectonics. Sharov,V.I.,
Trofimov,V.A., AO 'Tatneff' Almetievsk.

37. Tracing active faults in the upper crystalline basement of the Romashkinskoye oil field
using groups of earthquakes. Mirzoev,K.M., Stepanov,V.P., TGRU, Kazan.

38. On the formation of the chemical composition of fluids from the crystalline basement
in the Vorotilovskaya deep well in the Nizhny Novgoroddistrict and well #20000,
Tatarstan Republic, Russia. Trubchaninov,V.V. KAMMEGS, Perm.

39. The outlook for hydrocarbon entrapment in the weathered surface of crystalline
basement in the Pripetskaja trough. Bescopilni,V.N., Laptuchov,A.V., Belorusneff,
Gomel, Belorusia.

40. The internal basement structure over the region of the Romashkinskoye oilfield and its
implications for hydrocarbon accumulation. Alexandrov,V.K., Torfimov,V.A., AO
'Tatneffeximgeophysika'.

You might also like