Professional Documents
Culture Documents
Page no.
Specifications
Know your Hindustan Ultra gas water heater & Customer responsibility 6-7
Dear Customer,
Thank you!
Product dimensions
Installation
8-11
Operation
11
12-13
Maintenance
14
Troubleshooting
15
Warranty
16
You are now the proud owner of Hindustan Ultra instant gas water heater.
Please read all the instructions given in this Use and Care manual carefully, prior
to using your Hindustan Ultra instant gas water heater, to get the best mileage
and trouble free operation.
Lilac International
{` JmhH$
Y`dmX!
h_| Iwer h H$s AmnZo qhXwWmZ AQ>m BQ>oQ> Jg dmQ>a hrQ>a MwZm.
A~ Amn qhXwWmZ AQ>m BQ>oQ> Jg dmQ>a hrQ>a Ho$ _m{bH$ h, {Og na
Amn Jd H$a gH$Vo h.
AnZo qhXwWmZ AQ>m BQ>oQ> Jg dmQ>a hrQ>a H$a BVo_mb ew H$aZo go
nhbo Bg BVo_mb Ama XoI^mb _ZwAb _| {XE J`o g_V {ZX}em| H$mo
`mZnydH$ nT>o Vm{H$ AmnH$mo BgH$m b~m gmW Ama {eH$m`V a{hV H$m_H$mO
H$m nyam bm^ {_b gHo$.
bm`bH$ BQ>aZeZb
02
AZwH$_
n> H$.
{d{ZYmaU
6-7
bJmZm-{~R>mZm
8-11
MmbZ
11
12-13
aIaImd
14
g_`m g_mYmZ
dm>aQ>r
15
16
03
SPECIFICATIONS
Description of item
Model
10
480x290x140
LPG: 28 m bar
PNG : 18 m bar
Temperature control
Exhaust
Flue
Ignition
Power
Water pressure
Connector specification
1. Pleasing aesthetics.
2. Automatic ignition, just turn the water flow knob on, to
get hot water from the out let. Turn the water flow knob
back, to switch off the unit.
3. Independent control of water flow and gas flow makes
water temperature easy to regulate.
4. A burner selector knob allows selection of 1 or 2 or both
burners, depending on the ambient temperatures,
thus saving energy cost.
5. A built in gas regulator, makes combustion more stable
6. A built in oxygen depletion monitor automatically shirts
off the unit, when low residual oxygen levels
(60% of normal) is detected in the room
(Only Selected Model)
{d{ZYmaU
CnmX H$m {ddaU
_mS>b
aoQ>oS> C_m BZnwQ>-{H$bmodmQ> _|
aoQ>oS> J_ nmZr H$s gbmB
(Vmn_mZ d{ 25 g|{Q>JoS>) {bQ>a/{_{ZQ>
CnmX _mnOmoI
D$MmB * MmS>mB* JhamB ({__r.)
aoQ>oS> Jg Xm~
Vmn_mZ {Z`U
EOmQ>
BpZeZ
epV
Ob Xm~
H$ZoQ>a
{d{ZYmaU
IMPORTANT INFORMATION:
Gas Water Heaters should be installed in well-ventilated locations.
It is recommended to install a Flue Pipe to discharge the exhaust gases outside.
04
05
H$.
10
16
15
Automatic Instant Gas Water Heater
14
13
9
1
WINTER
12
SUMMER
2
MAX
GAS CONTROL
MIN
Gas Inlet
Drain Valve
Battery Case
10
Flue Outlet
11
12
Inlet Vent
13
Front Cover
14
Back Cover
15
Air Vent
16
AZw. H$.
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
11.
12.
13.
14.
15.
16.
MAX
WATER FLOW
g
iewme etye/HeeF&He keer efveeefcele He mes peebe kejW. eoer GveceW keesF& Kejeyeer nes lees iewme etye/HeeF&He yeoues, ee keesF& mebosn nes lees
g
iewme Jee@j nerj kes DeemeHeeme F&ueske^erke keveskeMeve nes lees DeeHekes F&ueske^erefMeevemes yebo kejeSb.
Fig.1 (aoIm{M 1)
Product Dimensions
290
89
mekelee nwb.
g
iewme Jee@j nerj kees nj ceefnvesceW efveeefcele Hemes efkemeerYeer iewme Jee@j nerj skeveerefMeevemes meefJe&efmbeie kejeSb.
g
iewme Jee@j nerj eeuet kejles mecee Henues iewme keer yeoyet peebe kejW.
60
15
140
g
efveeb$eCe vee@ye ceewmece kes Devegmeej mecej ee efJebj Hej ner jKeW. Deiej vee@ye efyeeceW jn peelee nw lees ie@me efueke nes kej
480
g
iewme efuekespe, iewme egye / HeeF&He, jsieguesj, efmeueW[j Deewj jyej nesme ee ie@me keveskeMeve F. keesF& Yeer ogIe&vee nesves mes
518
MIN
WINTER
MIN
MAX
SUMMER
MIN
GAS CONTROL
g
DeHevee iewme Jee@j nerj kee Fmlesceeue Meg kejves mes Henues Fmlesceeue Hegmleerkee ceW efoes iees mecemle efveoxMeesb kees OeeveHetJe&ke
MAX
WATER FLOW
15
60
53 53
iewme Jee@j nerj kes Ghej ee meceerHe keHe[e, leesefueee ee Deve pJeueveefMeue HeoeLe& ve jKesW.
Fig.2 (aoIm{M 2)
06
Ghej efoes iees iewme Jee@j nerj kesW efveece Deewj Fmlesceeue Hegmleerkee ceW efoes iees mecemle efveoxMeesb kee Heeueve eoer venerR efkeee ieee
g
lees nesvesJeeueer ogIe&vee Deewj vegkemeeve kes efpeccesoej Kego DeeHe nesWies.
07
H$.
bJmZm-{~R>mZm
gmdYmZr
CAUTION
g
dmQ>a hrQ>a H$mo ghr VarHo$ go bJmZo Ho$ {bE, Vm{H$
g
Consult the local gas authorities, for proper
installation to ensure safety.
g
Do not install the water heater in bedroom,
basement, bathroom, or room with bad ventilation.
The room for installation shall have adequate
provision for cross ventilation (FIG, 3)
g
A flue pipe connected to the flue duct of the unit
conveys the flue gases out of the room. However, the
accessories, like pipes, bends etc. is not in the scope
of supply of the product,
descriptions given here are
guide lines, for those who
would like to connect the
flue pipes.
g
The flame check window of
the water heater shall be
at the eye level (about 1.50m1.60m above the floor.
(FIG.4), kept away from
inflammables (FIG. 5).
No electric lines or
equipments shall be run /
placed above the water
heater. The heater shall be
kept at least 400mm away
from any electrical appliance.
g
by Jg H$mo
Fig.3 (aoIm{M 3)
1500/1600mm
g
Do not install the water heater
where adverse or strong wind
may blow, causing flame to be
putout or cause incomplete
combustion.
WINTER
MIN
SUMMER
MAX
MIN
GAS CONTROL
MAX
WATER FLOW
Fig.4 (aoIm{M 4)
g
dmQ>a hrQ>a
>45
>150
Automatic Instant Gas Water Heater
WINTER
MAX
GAS CONTROL
WINTER
SUMMER
MIN
MAX
WATER FLOW
WINTER
MIN
MAX
GAS CONTROL
SUMMER
MIN
MAX
WATER FLOW
RUBBER WASHER
GAS PIPE
WATER VALVE
GAS VALVE
GAS-IN
COLD WATER IN
RUBBER WASHER
>150
MIN
WALL
>150
INSTALLATION METHOD
475mm
MIN
MAX
GAS CONTROL
SUMMER
MIN
MAX
WATER FLOW
FLAMEOROOF BOARD
Fig.5 (aoIm{M 5)
08
Fig.8 (aoIm{M 8)
09
H$.
g
`y {~R>mZm (dH$pnH$)
g
Flue installation (Optional):
As this water heater is flue type, the waste gas
exhaust pipe may be installed (FIG. 9), however the
flue tubes are not currently in the scope of supply
HOLDER STAND
DUCT CAP
ROOF
DUCT HOLDER
Operation Method
MmbZ {d{Y
gw{ZpMV H$a|
g
gw{ZpMV H$a|
g
>1200 MM
FLUE DUCT
DUCT HOLDER
>250 MM
EXHAUST FAN
HEIGHT OF FLAME
CHECK WINDOW
10 MM
DRAIN HOLE
1550 - 1650 MM
WATER HEATER
AIR INLET
>0.06m
Fig.9 (aoIm{M 9)
Basic requirements:
~w{Z`mXr Amd`H$VmE
Flue tubes
`y Q>wg
g
The horizontal part of the flue shall have a 1% down
inclination, and there shall be a 10 mm hole at the
bottom of the vertical section of the flue outside the
room, for draining water drops.
g
`y Ho$ jo{VO
2. BpZeZ
nmZr Ho$ ~hmd VWm BgHo$ Vmn_mZ H$mo {Z`{_V H$aZo Ho$ {bE
g
nmZr Ho$ ~hmd Ho$ Zm~ H$mo Kw_mBE. ~Za H$s dmbm H$mo
{Z`{_V H$aZo Ho$ {bE dmbm {Z`U Zm~ H$mo Kw_mBE Bggo
J_ nmZr Ho$ Vmn_mZ na ^r {Z`U ahoJm.
~Za {Z`U
g
g
The outlet of the flue shall have a windproof cap,
which should not be clogged.
g
`y Ho$ AmCQ>boQ>
10
`oH$ ~ma BVo_mb H$aZo Ho$ ~mX bo_ H$mo ~wP OmZo H$s
g
use. Always turn off the gas valve when not in use
(FIG.11)
OmM H$aZm `mX aI|. O~ dmQ> hrQ>a H$m BVo_mb Z H$a aho
hm|, Jg dmd H$mo ~X H$a X|.
(aoIm {M 11)
Jg Q>y~ H$s {Z`{_V $n go OmM
g
H$aVo ah|, `m|{H$ b~o
g_`
VH$ BVo_mb Ho$ ~mX `h nwamZr nS> gH$Vr
h VWm Bg_| Xama| nXm hmo gH$Vr h. AJa
Fig.12 (aoIm{M 12)
For LPG users, if the flame of the
g
Xama| nXm hmo J`r hm| Vmo Bgo ~Xb X|.
heater is not stable, it may be caused by a defective
gm_m` MmbZ pW{V`m| _| EH$ gmb Ho$ ~mX Q>y~ H$mo ~Xb
pressure regulator connected to the outlet of the
XoZm Mm{hE.
Check the gas tube regularly, as it
g
may age and crack after long
period of use. Replace it if
cracked. Under normal operations,
the gas tube should be replaced
yearly.
POWER SWITCH
DONT TOUCH
DO NOT HANG
THINGS
OVERHEAD
12
ALKALI
FLAMMABLE
LIQUID
After use and turning off the gas valve, drain out
g
the hot water in the gas water heater until cold w a t e r
flows out. Then turn off the water valve.
g
O~ ~mW$_
14
TROUBLE SHOOTING
PRPBLEM
POSSIBLE CAUSES
RECOMMENDED ACTION
Unsuccessful Ignition
mecemee meceeOeeve
mecemee
mebYeeefJele keejCe
megOeej Gheee
DemeHeue eppeJeueve
cegKe iewme jsieguesj JeeuJe / heeveer kes veue kee yebo nesvee
yewjer kee ef[meepe& nesvee
iewme heeF&he ces nJee kee nesvee
iewme keer mehueeF& ve nesvee
heeveer kee kece oyeeJe
Demeeceeve eppeJeueve
leLee/DeLeJee iesme keer yeoyet ee
heerueer ueew
15