Professional Documents
Culture Documents
2
3
2 X n F
a X
n-1 X
n
(A) XoX1X3X5 + X2X4X5 ... Xn 1 + ... Xn 1Xn
(B) XoX1X3X5 + X2X3X4 ... Xn + ... Xn 1Xn
(C) XoX1X3X5 ... Xn + X2X3X5 + ... Xn + ... + Xn 1Xn
www.examrace.com
Q.30 The digital block shown below realized using two positive edge triggered D-flip-flop.
Assume that for t < t
0
, Q
1
= Q2 = 0
S U U U ~ ~
to ~ ~ ~ to ~ ~
The circuit in the digital block is given by
1
(A) X
1
(B) X
1
(C) X
1
(D) X
-
-
-
___,
-
~
Dt Ql
Ql
Dt Ql
Ql
Dt Ql
Ql
y
1-
D2 Q2
t--
y
_j
Q2
,----
D2 Q2
-
y
,...-
-
Q2
D2 Q2
-
y
-
Q2
Q.31 A 555 IC is connected as shown below. The range of oscillation frequency is
+lOV
Rt=lOkO
~ = 10 kO
R:!= 10 kO
1
I 0.01 ~ F
...
0.01 ~ ....
(A) 607kHz < j < 1.41 kHz
(C) 627Hz < j < 4.81 kHz
(B) 208kHz < j < 496 kHz
(D) 5kHz< j < 9.4 kHz
www.examrace.com
Q.32 If the input X
3
X
2
X
1
X
0
to the ROM shown below are 8- 4- 2- 1 BCD numbers,
then output Y3 Y2 Yt Yo are
Xa x2 xl Xo
I I I I
BCD to Decimal Decoder
D
0
D
1
D
2
D
3
D
4
D
5
D
6
D
7
D
8
D
9
..AAA
vv ..
--w ..
--'\IV".,
-w ..
...
(A) 2-4- 2 -1 BCD number
(C) excess 3 code converter
(B) gray code number
(D) none of the above
Q.33 Consider the following assembly language program:
MVI B, 87H
MOV A, B
START : JMP NEXT
MVI B, OOH
XRAB
NEXT:
OUT PORT1
HLT
XRAB
JP START1
OUT PORT2
HLT
The execution of the above program in an 8085 will result in
(A) an output of 87H at PORT1
(B) an output of 87H at PORT2
(C) infinite looping of the program execution with accumulator data remaining at
OOH
(D) infinite looping of the program execution with accumulator data alternating
between OOH and 87H.
Q.34 Consider the following system
a. T(s ) = (s+3)(s+6)
c T(s) =
20
s
2
+ 6s+ 44
e.T(s)= (s +
5
)
(s + 10)
2
10 (s + 7)
b. T(s) = (s+10)(s+20)
d.T(s)=
8
+
2
s
2
+ 9
www.examrace.com
Consider the following response
1. Over damped 2. Under damped
3. Under damped 4. Critically damped
The correct match is
1 2 3 4
(A) a c d e
(B) b a d e
(C) c a e d
(D) c b e d
Q.35 An ufb system is given as G(s) = K/
1
-
3
8
~ Indicate the correct root locus diagram.
. s s+ .
J...J J...J
(A) (B)
(C) (D)
Q.36 For dyjdx=x+y
2
, given that y=1 at x =O. Using Runge Kutta fourth order
method the value of y at x = 0.2 is (h = 0.2)
Q.37
(A) 1.2735 (B) 2.1635
(C) 1.9356 (D) 2.9468
The general solution of d
2
~ - ddy - 2y = 10 cos x is
dx x
(A) y = c
1
e x + c
2
e
2
x - 3 cos x - sin x
(C) y = C1 e x + c2 e
2
x - 3x + sin x
11
(B) y = C1 ex + c2 e
2
x - 3 cos X
(D) y = c
1
ex + c2 e
2
x - 3 cos x - sin X
Q.38 [
2
~ ( sec
2
~ + 2 tan dx is equal to
(A) e
11
(C) e
(B) e ~
11
(D) e4
Q.39 A speaks truth in 75% and B in 80% of the cases. In what percentage of cases are
they likely to contradict each other narrating the same incident?
(A) 5% (B) 45%
(C) 35% (D) 15%
www.examrace.com
Q.40 All transistor in the N output mirror shown below are matched with a finite gain
and early voltage VA = oo. The expression for each load current is
v+
v
(A) Iref
(
(1 + N))
1 + + 1)
(C) ( N))
1 + (,B + 1)
Q.41 Consider the common-source circuit shown below The transistor parameters are
VTN = 0.8 V, Kn = 1 mA/V2 and A= 0. The small-signal voltage gain is
(A) -10.83
(C) -5.76
+5 v
-5 v
(B) -8.96
(D) -3.28
Q.42 In the following circuit, transistors Q
1
and Q
2
has following parameters
Cf} = Cf\ =
20
'
(VrH)
1
= (VrH)
2
= 1 V,
www.examrace.com
+5V +5V
The voltage \11, \12 and 1;3 respectively are
(A) 1 V, 1 V, -1.1 V V
(C) 2 V, 1 V, 1.32 V
(B) 1 V, 2 V, 1 V
(D) 1 V, 1 V, -1.32 V
Q.43 The parameters of the transistor in the circuit shown below 100 and VA= 100
v.
+5V
10 kO
0.35mA I
-5 v -
The small-signal voltage gain Av = vo/ Vs is
(A) 80
(C) 40
(B) -80
(D) -40
Q.44 Two random variable X and Y have the density function
fx,Y(x,y)
0 < x < 2 and 0 < y < 3
elsewhere
The X and Y are
(A) Correlated but statistically independent
(B) U ncorrelated but statistically independent
(C) Correlated but statistically dependent
(D) U ncorrelated but statistically dependent
Q.45 In the following circuit the 30 V source has been applied for a long time. The switch
is opened at t = 1 ms.
www.examrace.com
t= 1 IDS
At t = 4 ms the vc(4 ms) is
(A) 8.39 mV
(C) 1.13 mV
25 kO
(B) 2.59 V
(D) 2.77 V
Q.46 The 300 D lossless line shown in fig. is matched to the left of the stub. The value of
ZL is
S.C.
(A) 1- jl.37
(C) 300 + j413
(B) 1 + jl.37
(D) 300 - j413
Q.47 The collector current of bipolar is Ic = 2 rnA. If output resistance is greater than
10 kD. Then what is the value of early voltage VA
(A) VA < 20 v (B) VA< 10 v
(C) VA>10V (D) VA>20V
Common data for Question 48-49 :
In the following circuit shown below, the 80 V source has been applied for a long
time. The switch is opened at t = 90 ms
133.3 n
Q.48 At t = o+ the current i
1
(o+) is
(A) 0.25 A
(C) 0.05 A
t= 90 ms
0.25vc
(B) 0.17 A
(D) 0.2 A
www.examrace.com
Q.49 At t = 80 ms the current i
1
(80 ms) is
(A) 20.3 rnA
(C) 1.84 rnA
Common data for Q. 50-51
(B) 8.25 rnA
(D) 6.98 rnA
A random noise X(t) having a power spectrum Pxx(w) =
3
J is applied to a
differentiator that has a transfer function H(w) = jw.
49
+
The output is applied to a network for which h(t) = u(t) ee
7
t
Q.SO The average power in X( t) is
(A) 5/21
(C) 5/42
Q.51 The power spectrum of Y( t) is
4w
2
(A) (49+w2)3
42w
3
(C) (49+w2)2
Statement for Linked Answer Q. 52-53 :
(B) 5/24
(D) 3/ 14
(D) None of the above
Consider a linear system whose state space representation is i( t) = Ax( t). If the initial
stale vector of the sys tern is x ( 0) ~ [. \], then the system respo;"e is x ( t) ~ [ _ e
2
, 1
. If the initial state vector of the system eh anges to x ( 0) ~ [ _
2
], then the system
response hccomc_s x( t) ~ [ e c', 1
Q.52 The eigenvalue and eigenvector pairs ( >.,, v,) for the system are
(A) ( -1,[ \])and( -2,[
1
2
]) (B) ( -1,[ \])and(z.[
1
2
])
(C) (-1,[!
1
])and( 2,[!
2
]) (D) ( 2,[!
1
])andH!
2
])
Q.53 The system matrix A is
(A) [ 01 :1
(B) [ \ \1
(C) [ \ . \]
(D) [ 02 13]
www.examrace.com
Statement for Linked Answer Q. 54-55:
Q.54
Q.55
A signal x( t) = sin c( 4000t) is ideally sampled with a sampling int erval Ts = 0.25 ms
Which of the following is spectr um of the sampled signal s(f)
s(J)
(A)
(B)
(C)
-7
II L
25
j II
-3 -2 0
s(J)
1
2 3
7 !(kHz)
------------=0------- !(kHz)
s(f)
11 11 haL-, 11 I
-7 -3 -2 -0.5 0.5 2 3 7
s(J)
(D) Jl rJ m p4 p7 ftk&)
In the above question if sampling interval Ts = 0.4 ms. then output spectrum will be
s(f)
(A)
(B)
lll.Sj II
!(kHz)
s(fJ
1
----------'-0------- !(kHz)
www.examrace.com