Professional Documents
Culture Documents
1. How do you maintain the standards for interlaced scanning in a 525 line 60 Hz frequency system.[16]
3. Discuss the constructional details of silicon diode array vidicon and also its working.
[16]
4. Draw the figure of monochrome picture tube and explain its working. [16]
5. (a) Draw a block diagram of PAL-D decoder and explain the functions performed by each block.
(b) Write short notes on the types of RF Tuners. [10+6]
6. (a) With a neat circuit diagram explain the operation of tuned amplifier employing forward AGC.
(b) Discuss briefly about the slope detection of the FM signal. [8+8]
7. (a) With a neat sketch explain the operation of Burst phase discriminator circuit.
(b) Write short notes on colour saturation control. [10+6]
8. Explain how integrating and differentiating circuits are employed to separate vertical and horizontal
sync pulses. Draw a typical circuit and explain its operation. Indicate how a noise gate can be added
to it. [16]
?????
Code No: R5410406 2
IV B.Tech I Semester(R05) Regular/Supplementary Examinations, December 2009
TELEVISION ENGINEERING
(Electronics & Communication Engineering)
Time: 3 hours Max Marks: 80
Answer any FIVE Questions
All Questions carry equal marks
?????
1. Sketch a composite video signal for a 625 line system picture having alternate 3 black & white vertical
lines and figure out different points. [16]
2. Give briefly how does the measurement of any different parameters of antenna system. [16]
4. Draw the figure of monochrome picture tube and explain its working. [16]
5. (a) Draw a block diagram of an AFT circuit and explain the functions performed by each block.
(b) Explain how sound trap circuit is used to separate the sound signal from video signal. [8+8]
6. (a) Draw a block diagram of a TV tuner and explain the functions performed by each block.
(b) Write short notes on high pass filter and trap circuits in VHF tuner. [10+6]
7. (a) With a neat sketch explain the operation of synchronous demodulator circuit.
(b) Write short notes on 1800 PAL switch. [10+6]
8. Draw a block diagram of an UP-LINK set-up and explain how the signals are compressed, packetised
and multiplexed before modulation and transmission. [16]
?????
Code No: R5410406 3
IV B.Tech I Semester(R05) Regular/Supplementary Examinations, December 2009
TELEVISION ENGINEERING
(Electronics & Communication Engineering)
Time: 3 hours Max Marks: 80
Answer any FIVE Questions
All Questions carry equal marks
?????
4. Draw the diagram for PIL picture tube and discuss various aspects of it. [16]
5. With a neat block diagram explain the functioning of a typical TV monochrome receiver. [16]
6. (a) With a neat sketch explain the operation of remote control infrared transmitter.
(b) What are the merits of keyed AGC system? [10+6]
8. Draw a circuit diagram of Single-Ended AFC. Illustrate the operation of the circuit with necessary
waveforms. [16]
?????
Code No: R5410406 4
IV B.Tech I Semester(R05) Regular/Supplementary Examinations, December 2009
TELEVISION ENGINEERING
(Electronics & Communication Engineering)
Time: 3 hours Max Marks: 80
Answer any FIVE Questions
All Questions carry equal marks
?????
1. Write in detail about television transmitter by drawing the block diagram. [16]
3. How do you select a camera tube for a particular application and explain it operation? [16]
4. Draw the figure of monochrome picture tube and explain its working. [16]
5. (a) Explain the block diagram of a video amplifier in a Black and White receiver.
(b) What are the factors that influence the choice of IF in TV receivers. [10+6]
6. (a) With a neat circuit diagram explain how noise cancellation is done by a separate noise gate
amplifier.
(b) Draw a block diagram of Phase Locked Loop FM detector and explain the functions performed
by each block. [8+8]
7. Discuss briefly about RO phase shift and 1800 PAL-switch circuitry. [16]
8. Draw a block diagram of an UP-LINK set-up and explain how the signals are compressed, packetised
and multiplexed before modulation and transmission. [16]
?????