You are on page 1of 7

Service tables

The following chapter contains the well-known service tables with


the service specifications of the Volkswagen brand. Since, in the
past, individual service specifications were set up in various
markets, mostly through severe operating conditions, these are
listed in service tables with specific deviations.
Service tables Chapter
Service tables with market-specific deviations Chapter
Note
For combined kilometre and time display applies: whichever
occurs first.
Depending on conditions under which the vehicle is used
Chapter and vehicle equipment, extra service work must be
performed in addition to the interval service, inspection service
or interval service inspection.
It is also possible, to perform additional work outside the
service intervals with regard to the entries in the service
schedule (or sticker: your next service).
Service tables
Service intervals Anchor.
VW engine oil standards Anchor
Filter change intervals Anchor
Toothed belt change intervals Anchor
Spark plug change intervals Anchor
Other time or distance dependent additional work Anchor
Service intervals
Caution

Only applies to diesel engines:
In some countries the sulphur content in diesel fuel
exceeds 2000 ppm.
The high sulphur content leads to excessive wear of
cylinders and it considerably reduces the cleanliness
of pistons.
Therefore, in countries with elevated sulphur content in
diesel fuel, change engine oil and fuel filter every 7,500
km.
Your importer will inform you about countries with
elevated sulphur content in diesel fuel.

Note
For extremely uneconomical driving style or use under extreme conditions Chapter, the shortest interval
for an oil change service or interval service is 15,000 km or 1 year.
However, other intervals apply for other countries. Your importer will inform you about this.
PASSAT 3C
Page 1 of 7 Service tables
04.03.2011 vw-wi://igg/V.en-GB.K00590214.wi::40352910.xml?xsl=3


Service intervals 2007
From - to Engine/Engine code/
PR No./Remarks
Service/intervals Indicated on
service interval display SID
(includes oil change)
Since
introduction
Diesel, in countries
with elevated sulphur
content in fuel
Oil change service
every 7,500 km or 1 year
YES
Since
introduction
2007
QG0/QG2/QG3 or
QG1 vehicles coded
to non-flexible interval
Oil change service:
every 15,000 km or 1 year
YES
Interval service:
every 30,000 km or 2 years
YES
QG1 vehicles
Interval service:
flexible from 15,000 to max.
30,000 km or max. 2 years
YES
All vehicles
Interval service inspection:
every 60,000 km or 4 years
YES

PASSAT 3C, Passat CC 2009 and CC 2010
Service intervals 2008
From - to Engine/Engine code/
PR No./Remarks
Service/intervals Indicated on
service interval display SID
(includes oil change)
Since
introduction
Diesel, in countries
with elevated sulphur
content in fuel
Oil change service
every 7,500 km or 1 year
YES
2008
QG0/QG2/QG3 or
QG1 vehicles coded
to non-flexible interval
Oil change service
every 15,000 km or 1 year
YES
Interval service:
every 30,000 km or 2 years
YES
QG1 vehicles
Interval service:
from 15,000 km or 1 year up to
max. 30,000 km or 2 years
YES
All vehicles
Inspection service:
after 3 years or max 60,000 km,
then every 2 years
NO
Note
For combined kilometre and time display applies: whichever
occurs first.
VW engine oil standards
Caution

Only engine oils approved by VW may be used, up-to-date
information ServiceNet, Technical information,
Inspections and Servicing, Approved oils, or ask your
importer.

PASSAT 3C, Passat CC 2009 and CC 2010
Page 2 of 7 Service tables
04.03.2011 vw-wi://igg/V.en-GB.K00590214.wi::40352910.xml?xsl=3

VW ENGINE OIL STANDARDS
With LongLife service (QG1) Without LongLife service (QG0, QG2)
PETROL ENGINES
4-cylinder engines incl.
FSI
504 00
1
alternative
503 00
2
4-cylinder engines incl.
FSI 2007
501 01/502 00
4-cylinder engines incl.
FSI 2008
502 00
VR6 FSI
504 00
1
alternative
503 01
VR6 FSI 2007 502 00/505 01
VR6 FSI 2008 502 00
4-cylinder TSI 504 00
1
4-cylinder TSI 502 00
DIESEL ENGINES
4-cylinder engines with
diesel particulate filter
507 00
1
4-cylinder engines with
diesel particulate filter
507 00
1
4-cylinder engines without
diesel particulate filter
507 00
1
alternative
506 01
3

4-cylinder engines
without diesel particulate
filter
505 01
1) Combination product: 504 00/507 00
2) Combination product: 503 00/506 00
3) Combination product: 503 00/506 00/506 01
Note
Vehicles with retrofitted diesel particulate filter are allocated in the
table to diesel engines without diesel particulate filter. Vehicles
with diesel particulate filter (factory-fitted) can be identified by PR
No. 7GG or 7MB on the vehicle data sticker.
Filter change intervals

PASSAT 3C, Passat CC 2009 and CC 2010
FILTER CHANGE INTERVALS
Descriptions of work
ENGINE OIL FILTER:
1)2)
Chapter
Vehicles with LongLife
service (QG1)
According to service interval display
All remaining vehicles Every 15,000 km or 1 year
AIR FILTER: Chapter
All engine types Every 90,000 km or 6 years
FUEL FILTER: Chapter
All diesel engines
Diesel conforming to EN
590
Diesel not conforming to
EN 590
Diesel with sulphur
content 2000 ppm
Every 90,000 km Every 30,000 km Every 7,500 km
Draining water is deleted.
DUST AND POLLEN FILTER: Chapter
All engine types Every 60,000 km or 2 years
Page 3 of 7 Service tables
04.03.2011 vw-wi://igg/V.en-GB.K00590214.wi::40352910.xml?xsl=3


OIL FILTER OF DUAL CLUTCH GEARBOX (DSG): Chapter
All with gearbox type
02E
Every 60,000 km
1)
A new engine oil filter must be installed at every engine oil change.
2)
Only applies to diesel engines: In some countries the sulphur content in diesel fuel exceeds 2000 ppm. The
high sulphur content leads to excessive wear of cylinders and it considerably reduces the cleanliness of
pistons. Therefore, in countries with elevated sulphur content in diesel fuel, change engine oil and fuel filter
every 7,500 km. Your importer will inform you about countries with elevated sulphur content in diesel fuel.
Toothed belt change intervals

If the engine is fitted with toothed belt or timing chain can be found in the engine list.
Note
The camshaft drive with timing chain is maintenance-free!
PASSAT 3C, Passat CC 2009 and CC 2010
TOOTHED BELT CHANGE / TENSIONING ROLLER CHANGE INTERVALS
Diesel engines
Engine type Engine code Model year Toothed belt
change interval
Tensioning roller
change interval
TDI-PD BKC, BKP ,BMA,
BMP, BLS, BVE
BMR, BUZ, BWV, BXE
2006 Every 120,000 km
Chapter
Every 240,000 km
Chapter
TDI-PD BKC, BKP ,BMA,
BMP, BLS, BVE
BMR, BUZ, BWV, BXE
2007 Every 150,000 km
Chapter
Every 300,000 km
Chapter
2.0 l TDI CR CBAA, CBAB, CBAC,
CBBB, CBDC
Since introduction
2009
Every 180,000 km
Chapter
360,000 km
All TDI CR CBAA, CBAB,CBAC,
CBBB, CBDC, CAYC
2010 Every 210,000 km
Chapter
210,000 km
Petrol engines
2.0 l AXX, BLR, BLX,
BLY, BPY, BWA
BVX, BVY, BVZ
Since introduction Every 180,000 km
Chapter
---
1.6 l BSE, BSF Since introduction No prescribed
change interval,
toothed belt drive
with test interval,
see other time or
distance dependent
additional work
Anchor

Spark plug change intervals

Spark plug designation and specified torque: Power unit Rep. Gr.28 Repairing ignition system
Test data.
Note
For technical reasons it is possible that several cross references are not directed to the correct chapter. In this
case select the procedure manually in the information.
Page 4 of 7 Service tables
04.03.2011 vw-wi://igg/V.en-GB.K00590214.wi::40352910.xml?xsl=3

PASSAT 3C, Passat CC 2009 and CC 2010
Spark plug change intervals
Engine type Engine code Change intervals Description
of work
2.0l FSI 110 kW,
1.6l SRE and FSI
1.4l TSI engines
BLR, BLX, BLY, BVX, BVY,
BVZ
BLF, BLP, BSE, BSF
CAXA, CDGA
EVERY 60,000 km
Mileage more than 60,000 km in 4
years
Chapter
EVERY 4 years
Mileage less than 60,000 km in 4 years
2.0l TFSI
V6 FSI
1.8l and 2.0l TSI
AXX, BPY, BWA
AXZ, BLV
BZB, CAWB, CBFA, CCTA,
CCZA, CCTB, CDAA, CDAB,
CGYA
EVERY 90,000 km
Mileage more than 90,000 km in 6
years
EVERY 6 years
Mileage less than 90,000 km in 6 years
Other time or distance dependent additional work

Time or distance dependent additional work Interval Description of
work

Reducing agent (AdBlue

): Replenish
Only if customer requires and as a separate charge
At every service Chapter
Haldex coupling: Change oil
Only applies to vehicles up to model year 2009
Applies to vehicles with 4MOTION
Every 60,000 km Chapter
ATF: Change
Applies to 1.8 l TSI with gearbox group 09G in 6-speed automatic
gearbox
Applies to 2.0 l TSI with gearbox group 09G in 6-speed automatic
gearbox
Applies to 2.0 l FSI from model year 2009 with gearbox group 09G
in 6-speed automatic gearbox in countries with hot climate, China
and USA
Every 60,000 km Chapter
Camshaft drive toothed belt: Check
Applies to 4-cylinder petrol engines without prescribed change
interval
First at 90,000
km,
then every
30,000 km
Chapter
Diesel particulate filter: Check
Only applies to vehicles up to model year 2009
Vehicles with factory-fitted diesel particulate filter
First at 150,000
km,
then every
30,000 km
Chapter
Diesel particulate filter: Check
Only applies to vehicles from model year 2010
Vehicles with factory-fitted diesel particulate filter
First at 180,000
km,
then every
30,000 km
Chapter
Exhaust emissions test (EET): Perform test
For vehicles with commercial passenger transport, e.g. taxis
Only applies to Germany
every 12 months Chapter
Brake and clutch system: Change brake fluid
Only applies to vehicles 2007
Every 2 years Chapter
Page 5 of 7 Service tables
04.03.2011 vw-wi://igg/V.en-GB.K00590214.wi::40352910.xml?xsl=3

Haldex coupling: Change oil
Only applies to vehicles from model year 2010
Applies to vehicles with 4MOTION
Every 3 years Chapter
Brake and clutch system: Change brake fluid
Only applies to vehicles 2008
First after 3
years,
then every 2
years
Chapter
WARNING: Must only be carried out by authorized personnel!
Gas system test (GAP): Perform test
Only applies to Passat EcoFuel
First after 3
years,
then every 2
years
Chapter
Checking condition of natural gas filler neck and sealing cap, clean
if necessary and check seal
Only applies to Passat EcoFuel
First after 3
years,
then every 2
years
Chapter
Exhaust emissions test (EET): Perform test
Only applies to Germany
First after 3
years,
then every 2
years
Chapter

Reducing agent (AdBlue

): Change
Applies to vehicles driving less than 15,000 km in 4 years
Every 4 years Chapter
Tyre pressure sensors: Change
Only applies to vehicles up to model year 2003
If fitted
Every 6 years Chapter
WARNING: Must only be carried out by authorized personnel!
Natural gas tank: Renew
Only applies to Passat EcoFuel Every 20 years Chapter
Service tables with market-specific deviations
Note
This chapter only provides information on market-specific
deviations. This means that all maintenance points that are not
shown here are to be found in the normal service tables.

Russian market from model year 2010
Interval Description
of work
Interval service (QG0/QG2)
(appears on service interval display)
Every 15,000 km
or 1 year
1)

Maintenance
tables
Inspection service
(does not appears on service interval display)
Every 30,000 km
or 2 years
1)

Maintenance
tables
Dust and pollen filter (cabin filter): Renew
Every 15,000 km
or 1 year
1)
Chapter
Spark plugs: Renew
Every 30,000 km
or 2 years
1)
Chapter
Fuel filter: Renew Every 30,000 km Chapter
Page 6 of 7 Service tables
04.03.2011 vw-wi://igg/V.en-GB.K00590214.wi::40352910.xml?xsl=3


Air filter element: Check and renew, if necessary, and clean
housing
Every 30,000 km
or 2 years
1)
Chapter
Camshaft drive toothed belt: Renew
Only valid for 2.0 l TFSI
Every 90,000 km Chapter
1)
Whichever occurs first

North American market
Interval Description
of work
Sliding sunroof drains: Check flow and clean if necessary Every 60,000 km Chapter

Page 7 of 7 Service tables
04.03.2011 vw-wi://igg/V.en-GB.K00590214.wi::40352910.xml?xsl=3

You might also like