Professional Documents
Culture Documents
100 15.10v
22 14.35v
Half-wave rectifier
Assemble the following circuit:
Place a resistance of 100 .
Connect the multimeter terminals 2 and 3 of the circuit and measure CD option
current (I0) and the output voltage V0 rectifier circuit
and calculate
Then place the channel 1 of oscilloscope in terminals 1 and 3 and channel 2 in
points 2 and 3.
Draw both channels
10 V/div channel 1
10V/div channel 2
10 mseg/div
Get the voltage peak of the channel 1 signal transformer
Get the peak voltage less channel 2 diode voltage
With integration filter half-wave rectifier
Assemble the following circuit:
Place a 100 resistor and capacitor according to the table.
Connect the meter in terminals 1 and 2 of the circuit, measure in the current CD
option
and voltage
470F 17.30v .163A 1.063v
2200 F 18.24v .78A 0.0606v
Then place the channel 1 of oscilloscope in terminals 1 and 2 on the AC option
Get the ripple voltage
and voltage
and calculate
Draw cannel 1 with the 470F capacitor Draw cannel 1 with the 2200F capacitor
2 V/div canal 1
10 mseg/div
0.5 V/div canal 1
10 mseg/div
Then replace the channel 1 of oscilloscope in terminals 1 and 3 and channel 2 in
points 2 and 3, draw both channels
Get the voltage peak of the channel 1 signal transformer
Get the peak voltage less channel 2 diode voltage
Full-wave rectifier with two diodes with filter integration
Assemble the following circuit
Place a 100 resistor and capacitor according to the table.
Connect the meter in terminals 1 and 2 of the circuit, measure in the current
CD option
and voltage
470F 9.59v 89.7mA 0.0203v
2200 F 9.86v 92mA 0.2656v
Then place the channel 1 of oscilloscope in terminals 1 and 2 on the AC option
Get the ripple voltage
and voltage
and calculate
Then place the channel 1 of oscilloscope in terminals 1 and 3 and channel 2 in
points 2 and 3.
Get the voltage peak of the channel 1 signal transformer
Get the peak voltage less channel 2 diode voltage
10 V/div channel 1
5 V/div channel 1
5 mseg/div
Full-wave rectifier type bridge integration filter
Assemble the following circuit:
Place a 100 resistor and capacitor according to the table.
Connect the meter in terminals 1 and 2 of the circuit, measure in the current
CD option
and voltage
470F 18.03v 17.02mA 2.216v
2200 F 18.48v 172.1mA 0.1006v
Then place the channel 1 of oscilloscope in terminals 1 and 2 on the AC option
Get the ripple voltage