1. ,In a 3 phase full converter, the firing angle is less than 60 decrees.
The instantaneous output
voltage Answer, will have positive part only
2. ,In a stud mounted SCR, the stud is Answer,in electrical and thermal contact with heat sink
3. ,In a full bridge inverter, the waveshape of load current depends on Answer,relative values of load parameters R, L and C
4. ,The characteristics of which device has peak point and valley point Answer, P-U-T
5. ,In an ordinary thyristor Answer, turn off time is more than turn on time
6. ,Thyristors connected in series need Answer, both static and dynamic equalizing circuits
7. ,If 4 quadrant operation is required we need , Answer, dual converter
8. ,A single phase half wave converter is feeding a resistive load. Output dc power is Pdc and total power delivered to load is Pac then , Answer, Pdc is less than Pac if firing angle is less than 180 degrees
10. ,In integral cycle control of ac regulators, the period of integral cycle control, in example m plus n times T , Answer, should be less than mechanical or thermal time constant of the system
11. ,All other parameters remaining the same, a 3 phase bridge inverter with 180 degree mode of operation Answer, has higher peak thyristor current than in 1200 mode of operation
12. ,As compared to BJT, MOSFET has Answer, lower switching losses and higher conduction losses
13. ,If a step down chopper is fed by a dc voltage V with Ton and Toff are on and off periods then is Answer, average output voltage
14. ,In the basic series inverter circuit, the source supplies load Answer, only in positive half cycle
15. ,In load commutated chopper, the commutating element Answer, is capacitor
16. ,In a half bridge inverter each thyristor is gated at a frequency f. The output frequency is Answer, F
17. ,(A): A transistor has lower voltage drop during conduction as compared to thyristor (R): Transistors are manufactured in very high voltage and current ratings. Answer, A is correct but R is wrong
18. ,In a parallel inverter each thyristor is turned on twice during Answer, each cycle
19. ,Multiphase choppers are used in Answer, high power circuit
20. ,(A): Typical value of thermal resistance from source to sink of an SCA is about 0.30 (R): Heat sinks of thyristors are generally made of aluminum. Answer, Both A and R correct but R is not correct explanation of A
21. ,In a single phase converter using a centre tapped transformer and with a highly inductive load, the firing angles is a. Each thyristor conducts for a period Answer, P
22. ,A step up chopper can give an output voltage Answer, higher than input voltage
23. ,The specified maximum junction temperature of thyristors is about Answer, 120 degrees Celsius
24. ,A bridge type single phase cycloconverter changes the frequency f to f/3. Then one half wave of output contains Answer, 3 half waves of input
25. ,A half bridge inverter Answer, needs a 3 wire dc supply
26. ,A 3 phase series inverter has Answer, 6 thyristors
27. ,Which device has metal-silicon junction? Answer, Schottky diode,
28. ,A dc chopper is feeding an RLE load. The condition for maximum ripple is Answer, A equal to 1,
29. ,In a series inverter , Answer, the commutating elements L and C are in series with load,
30. ,When a power diode is conducting, the voltage drop across it is about , Answer, 1 Volt
31. ,In thermal ohm's law, temperature and power loss are analogous to , Answer, current and Volt respectively of ohm's law
32. ,A string of series connected thyristors needs equalising circuit to , Answer, ensure proper voltage division
33. ,A surge voltage has , Answer, very high magnitude and very small duration and can be positive or negative
34. ,The minimum gate current which can turn on SCR is called , Answer, trigger current
35. ,The total number of leads in SUS, SBS and SCS respectively are , Answer, 3, 3 and 4
36. ,Which device can conduct in both directions? , Answer, SBS
37. ,(A): A half wave controlled rectifier has poorer efficiency and higher ripple factor than a full wave controlled rectifier. (R): The use of a freewheeling diode in half wave controlled rectifier circuit improves the waveform of load current and circuit power factor, Answer, Both A and R correct but R is not correct explanation of A
38. ,A 3 phase dual converter consists of two 3 phase full converters connected in , Answer, antiparallel
Answer, Both McMurray Bedford half bridge inverter and Modified McMurray Bedford half bridge inverter
40. ,When an SCR is in forward blocking mode, the applied voltage , Answer, appears across only one junction
41. ,A class D chopper, Answer,can operate in either first or fourth quadrant ,
42. ,The symbol in figure is for , Answer, P-U-T
43. , The efficiency of a chopper circuit is about , Answer, 80% or more
44. ,If the frequency is less than the damped frequency in a series- inverter , Answer, the distortion of output voltage waveform is high ,
45. ,Mc Murray full bridge inverter uses , Answer, 8 thyristors and 4 diodes
46. ,(A): A diac has four layers but only two terminals. (R): A Diac can conduct in both directions. Answer, Both A and R correct but R is not correct explanation of A
47. , In a 3 phase full converter, the instantaneous output voltage can have negative part if , Answer, firing angle is more than 60 degrees
48. , In a single phase full wave ac regulator using two thyristors only, the gate circuits of the two thyristors , Answer, must be isolated
49. , A fully controlled bridge converter is feeding an RLE load. For some circuit conditions firing angle is 47 degrees. If connections of battery are reversed, the firing angle is likely to be more than Answer, 47 degrees.
50. , In a sirigle phase half wave converter feeding resistive load and full wave converter (M - 2 connection) feeding a resistive load the circuit conditions are similar. The firing angle is a. Then the waveshapes of voltages across thyristors Answer, are similar
51. , In a 3 phase full converter feeding a highly inductive load, the average load current is 150 Ampere. The peak current through thyristor is , Answer, 150 Amps
52. , In a 3 phase full wave regulator feeding a star connected resistance load, firing angle is 75 degrees. Then the number of thyristors conducting at one time is , Answer, 2
53. , The main utility of SCR is due to , Answer, gate triggering
54. , A single phase half bridge inverter required to feed R-L loads needs , Answer, 2 thyristors and two diodes ,
55. , Typical values of for an SCR are in the range of , Answer, 25 to 500
56. , When a dc chopper feeds an RLE load, the load current, during steady state operation , Answer, varies between maximum and minimum values