Last Updated: April 7, 2009 for SmartPlant 3D 2009 Routing Pipe Runs in a Rotated Coordinate System
Objective:
Routing Pipe Runs in a Rotated Coordinate System
Overview:
In this exercise you will be pipe runs using the Route Pipe command to route
Before you start placing the equipments define your workspace to show Unit U06.
1. Navigate to the Piping task 2. Make sure the Active Permission Group is set to Piping. 3. Activate the PinPoint ribbon and set the active coordinate system to U06 CS on the PinPoint ribbon.
Discharge Nozzle Discharge Nozzle
SP3D Piping Training Labs
Copyright 2009 Intergraph Corporation
Last Updated: April 7, 2009 for SmartPlant 3D 2009 4. Follow the Plan, Isometric and Side View Diagrams below and ensure that the following parameters are utilized in order to complete this exercise.
Pipeline: 600-P Name Rule: DefaultNameRule Specifications: 1C0031 Nominal Diameter: 4
5. To begin this exercise Create a 4 Pipe Run and use the discharge Nozzle on Equipment C- 101B as your Start point.
Plan View
2 6 Gate Valve Concentric Size Change at Flange From 3 to 4 CL 10 C-101B C-101A
Pipeline: 600-P Name Rule: DefaultNameRule Specifications: 1C0031 Nominal Diameter: 4
Discharge Nozzle
SP3D Piping Training Labs
Copyright 2009 Intergraph Corporation
Last Updated: April 7, 2009 for SmartPlant 3D 2009
Isometric View Side View Vessel D-104
6. After Placing the 15 ft Straight feature Continue routing Pipe and Connect directly to Nozzle A on Vertical Vessel D-104 to complete this exercise. 6 15 Nozzle A