You are on page 1of 8

An inductance of 0.

08 H is larger than
A. 0.0000008 H
B.
0.000000008 H
C. 0.000008 H
D. 0.00008 mH
View Answer Workspace Report Discuss in Forum

2.
A 240 H inductor is equivalent to a
A.
0.240 mH inductor
B. 0.000240 mH inductor
C. 240 mH inductor
D. 240 H inductor
View Answer Workspace Report Discuss in Forum

3.
A 2 mH, a 3.3 mH, and a 0.2 mH inductor are connected in series. The total
inductance is
A. 55 mH
B. less than 0.2 mH
C. less than 5.5 mH
D.
5.5 mH
View Answer Workspace Report Discuss in Forum

4.
A 5 mH, a 4.3 mH, and a 0.6 mH inductor are connected in parallel. The total
inductance is
A. 9.9 mH
B. greater than 5 mH
C. 9.9 mH or greater than 5 mH
D.
less than 0.6 mH
View Answer Workspace Report Discuss in Forum

5.
The voltage across a coil when di/dt = 20 mA/ s and L = 8 H is
A. 16 mV
B.
160 mV
C. 1.6 mV
D. 2.5 mV

6.A sine wave voltage is applied across an inductor. When the frequency of the
voltage is decreased, the current
A.
is increased
B. is decreased
C. does not change
D. momentarily goes to zero
View Answer Workspace Report Discuss in Forum

7.
Two 10 H inductors are in parallel and the parallel combination is in series with
a third 10 H inductor. What is the approximate total reactance when a voltage
with a frequency of 7 kHz is applied across the circuit terminals?
A. 219 k
B. 66 k
C.
660 k
D. 1.3 M
View Answer Workspace Report Discuss in Forum

8.
An ohmmeter is connected across an inductor and the pointer indicates zero
ohms. The inductor is
A. good
B. open
C.
shorted
D. partly shorted
View Answer Workspace Report Discuss in Forum

9.
Two inductors, L
1
and L
2
, are in parallel. L
1
has a value of 25 H and L
2
a value
of 50 H. The parallel combination is in series with L
3
, a 20 H coil. The
entire combination is across an ac source of 60 V
rms
at 300 kHz. The total rms
current is
A. 87 mA
B.
870 mA
C. 87 A
D. 337 mA
View Answer Workspace Report Discuss in Forum

10.
An inductor, a 1 k resistor, and a switch are connected in series across a 6 V
battery. At the instant the switch is closed, the inductor voltage is
A. 0 V
B.
6 V
C. 12 V
D. 4 V


11.
The winding resistance of a coil can be increased by
A. increasing the number of turns
B. using a thinner wire
C. changing the core material
D.
increasing the number of turns or
using thinner wire
View Answer Workspace Report Discuss in Forum

12.
An inductance of 0.43 mH is smaller than
A. 43 H
B. 430 H
C.
0.05 H
D. 0.00043 H
View Answer Workspace Report Discuss in Forum

13.
An inductor and a resistor are in series with a sine wave voltage source. The
frequency is set so that the inductive reactance is equal to the resistance. If the
frequency is increased, then
A. V
R
V
L

B. V
L
< V
R

C. V
L
= V
R

D.
V
L
> V
R

View Answer Workspace Report Discuss in Forum

14.
The current through a 120 mH coil is changing at a rate of 150 mA/s. The
voltage induced across the coil is
A. 1.8 mV
B.
18 mV
C. 180 mV
D. 1.25 mV
View Answer Workspace Report Discuss in Forum

15.
When the current through an inductor decreases, the amount of energy stored
in the electromagnetic field
A. increases
B.
decreases
C. remains the same
D. doubles


16.
Three 15 mH inductors are in series. The total inductance is
A. 15 mH
B. 30 mH
C.
45 mH
D. 5 mH
View Answer Workspace Report Discuss in Forum

17.
An 18 V power supply is connected across a coil with a winding resistance of
180 . Current flow in the coil is
A. 1 mA
B. 10 mA
C.
100 mA
D. 1 A
View Answer Workspace Report Discuss in Forum

18.
A switch, a 220 resistor, and a 60 mH inductor are in series across a 20 V
battery. What is the current through the inductor two time constants after the
switch is closed?
A. 91 mA
B.
78 mA
C. 57 mA
D. 400 mA
View Answer Workspace Report Discuss in Forum

19.
A 320 H coil is in series with a 3.3 k resistor. How long does it take for
current to build up to its full value?
A.
5.28 s
B. 5.28 ms
C. 5.28 s
D. 528 s
View Answer Workspace Report Discuss in Forum

20.
Five inductors are connected in series. The lowest value is 8 H. If the value of
each inductor is twice that of the preceding one, and if the inductors are
connected in order of ascending values, the total inductance is
A. 8 H
B. 32 H
C. 64 H
D.
248 H

21.
The inductance of an iron-core coil decreases if
A.
the number of turns is decreased
B. the iron core is removed
C. the length of the coil decreases
D. none of the above
View Answer Workspace Report Discuss in Forum

22.
The following coils are in parallel: 75 H, 40 H, 25 H, and 15 H. The
total inductance is approximately
A.
6.9 H
B. 14 H
C. 2.2 H
D. 155 H
View Answer Workspace Report Discuss in Forum

23.
When the current through an inductor is cut in half, the amount of energy
stored in the electromagnetic field
A.
is quartered
B. quadruples
C. doubles
D. does not change

You might also like