Professional Documents
Culture Documents
Advantages
!
!
!
!
!
!
!
Dosage
The optimum dosage of Conplast RP264 to meet specific
requirements should always be determined by trials
using the materials and conditions that will be
experienced in use. The normal dosage range is 0.3 to
0.8 liters per 100 kg of cementitious material, including
PFA, GGBFS or micro-silica.
Use at other dosages
Dosages outside the normal rang quoted above can be
used to meet particular mix requirements Contact Fosroc
for advice in these cases
Properties
Appearance:
Specific gravity:
Chloride content:
Air entrainment:
Alkali content:
Standard compliance
Brown liquid
Typically 1.180 at 20oC
Nil to BS 5075
Typically less than 2% additional
air is entrained at normal
dosages
Typically less than 5.0 g. Na2O
equivalent/liter of admixture. A
fact sheet on this subject
available.
Description
Retardation
Storage
Conplast RP264 has a minimum shelf life of 12 months
0
provided the temperature is kept within the range of 2 C to
0
50 C. Should the temperature of the product fall outside this
range contact Fosroc for advice.
Compatibility
Freezing point:
Precautions
o
Approximately -4 C
Dispensing
The correct quantity of Conplast RP264 should be measured
by means of a recommended dispenser. The admixture
should then be added to the concrete with the mixing water to
obtain the best results. Contact Fosroc for advice regarding
suitable equipment and its installation.
Effects of overdosing
Fire
An overdose of double the amount of Conplast RP264 will
result in a significant increase in retardation as compared to
that normally obtained at the intended dosage. Provided that
adequate curing is maintained, the ultimate strength of the
concrete will not be impaired by increased retardation and will
generally be increased. The effects of overdosing will be
further increased if sulphate resisting cement or cement
replacement materials are used.
Over-dosage may also cause increased air entrainment,
which will tend to reduce strength. The degree of this effect
will depend on the particular mix design and overdose level.
Estimating - packaging
Jeddah Showroom
Dammam
Yanbu
Medinah
Head Office & Factory
Important note: Fosroc products are guaranteed against defective materials and manufacture and are sold subject to its standard terms and conditions of
sale, copies of which may be obtained on request. Whist Fosroc endeavors to insure that any advice, recommendation, specification or information it may give
is accurate and correct, it cannot, because it has no direct or continuous control over where how its products are applied, accept any liability either directly or
indirectly arising from the use of its products, whether or not in accordance with any advice, specification, recommendation or information given by it.
SAU/CONPLAST264/07/99/A