Professional Documents
Culture Documents
Page 1 of 2
Initial Action
Refer to BSD 8.7 (3 of 4) for the following procedure.
Check for any obstructions in the paper path.
Check the Registration Side Shift Motor assembly and gears for broken gear shaft or gears ( PL 2.3).
Procedure
Enter DC330 008-020 Regi Side Shift Motor. Select Start.
The Registration Side Shift Motor operates.
Yes
No
Unanswered
Go to Flag11 on BSD 8.7 (3 of 4). check the harness and connectors for an open circuit.
The harness and connectors are good.
Yes
No
Unanswered
No
Unanswered
No
Unanswered
Replace F5 ( PL 13.3).
+24 VDC is measured between J583D-7, 8 and GND on the SMA Driver D PWB.
Yes
No
Unanswered
Go to LVPS 2 +24 VDC Wirenet and LVPS 2 +24 RTN Wirenet check the harness and connectors between
LVPS 2 and SMA Driver D PWB. Replace the SMA Driver D PWB ( PL 13.2).
+5 VDC is measured between J453-B10, B11, B13 and B13 on the IO PWB.
Yes
No
Unanswered
Troubleshoot the circuit between the IO PWB and SMA Driver D PWB.
Replace the Registration Side Shift Motor ( PL 2.3).
Troubleshoot the circuit between the IO PWB and Registration Side Shift Motor.
Disconnect J110. Enter DC330 008-182 Regi Side Shift Home Snr.
+5 VDC is measured between J566-2 on the BGM Driver PWB and GND.
Yes
No
Unanswered
+5 VDC is measured between J563-5 on the BGM Driver PWB and GND.
Yes
No
Unanswered
+5 VDC is measured between J461-B14 on the IO PWB and GND.
Yes
No
Unanswered
No
Unanswered
Replace the Registration Side Shift Home Sensor ( PL 2.3). If that does not correct the problem, replace the BGM Driver PWB ( PL
13.3).
Disconnect J 109. Enter DC330 008-181 Regi Side Shift Snr.
+5 VDC is measured between J566-5 on the BGM Driver PWB and GND.
Yes
No
Unanswered
+5 VDC is measured between J563-4 on the BGM Driver PWB and GND.
Yes
No
Unanswered
pws://file/xerox/edoc/dc5000/chtml/svc.malta.0000140828.htm
1/8/2010
Page 2 of 2
No
Unanswered
No
Unanswered
Replace the Registration Side Shift Sensor ( PL 2.2). If that does not correct the problem, replace the BGM Driver PWB ( PL 13.3).
Perform the following:
Clean the Registration Side Shift Sensor ( PL 2.2) and Registration Side Shift Home Sensor ( PL 2.3).
Go to Flag13, Flag14, Flag19 and Flag20 on BSD 8.7 (3 of 4). check the harness and connectors for an open circuit. If they are good,
replace the Registration Side Shift Sensor ( PL 2.2) and/or Registration Side Shift Home Sensor ( PL 2.3).
Replace the IO PWB ( PL 13.3).
pws://file/xerox/edoc/dc5000/chtml/svc.malta.0000140828.htm
1/8/2010