Professional Documents
Culture Documents
net
R07
2.a)
b)
3.a)
b)
4.a)
b)
[8+8]
D
L
R
O
Design a double riveted, double butt strap joint for the longitudinal seam of a
boiler shell of 1.5m diameter, which is subjected to an internal pressure of
1 N/mm2. The permissible stresses are: 80MPa in tension, 120MPa in
compression, and 60MPa in shear. Take the efficiency of the joint as 75%.
A 70mm diameter solid shaft is to be welded to a plate by means of a fillet weld,
around the circumference of the shaft. Determine the size of the weld, if the shaft
is subjected to a torque of 4kN-m. The allowable shear stress in the weld is
45MPa.
[8+8]
W
U
T
N
5.a)
b)
6.
A steel shaft 1.25 m long between bearings carries 1250 N pulley at its mid point.
The pulley is keyed to the shaft and receives 20 kW at 200 rpm. The belt drive is
horizontal and the ratio of the belt tensions is 3:1. The diameter of the pulley is
600 mm. Compute the shaft diameter.
[16]
www.jntuworld.com || www.jwjobs.net
7.
Two 5 cm shafts running at 350 rpm and transmitting a torque of 1200 Nm are
connected by a flange coupling. The flanges are fitted with six bolts. Permissible
stresses are 35 MPa in shear and 45 MPa in crushing. Design the coupling with a
neat sketch.
[16]
8.a)
b)
****************
D
L
R
O
W
U
T
N
www.jntuworld.com || www.jwjobs.net