Professional Documents
Culture Documents
00432903
1.
2.
HAZARDS IDENTIFICATION
The preparation is not classified as dangerous according to Directive 1999/45/EC and its amendments.
See section 11 for more detailed information on health effects and symptoms.
3.
COMPOSITION/INFORMATION ON INGREDIENTS
Yes.
: Preparation
copolymer from acrylic acid, divinylbenzene and aliphatic diene with
carboxylic acid groups in H-form
Within the present knowledge of the supplier, this product does not contain any hazardous
ingredients in quantities requiring reporting in this section, in accordance with EU or national
regulations.
4.
First-aid measures
Inhalation
Ingestion
Date of issue
: Move exposed person to fresh air. Keep person warm and at rest.
If not breathing, if breathing is irregular or if respiratory arrest
occurs, provide artificial respiration or oxygen by trained personnel.
Obtain medical attention if symptoms occur. If unconscious, place
in recovery position and get medical attention immediately.
Maintain an open airway. Loosen tight clothing such as a collar, tie,
belt or waistband.
: Wash out mouth with water. Move exposed person to fresh air.
Keep person warm and at rest. If material has been swallowed and
the exposed person is conscious, give small quantities of water to
drink. Stop if the exposed person feels sick as vomiting may be
dangerous. Do not induce vomiting unless directed to do so by
medical personnel. If vomiting occurs, the head should be kept low
so that vomit does not enter the lungs. Obtain medical attention if
symptoms occur. Never give anything by mouth to an unconscious
person. If unconscious, place in recovery position and get medical
: 2008-10-30
Page: 1/6
LEWATIT CNP 80
Skin contact
Eye contact
00432903 / 1
attention immediately. Maintain an open airway. Loosen tight
clothing such as a collar, tie, belt or waistband.
: Flush contaminated skin with plenty of water. Remove
contaminated clothing and shoes. Obtain medical attention if
symptoms occur. Wash clothing before reuse. Clean shoes
thoroughly before reuse.
: Immediately flush eyes with plenty of water, occasionally lifting the
upper and lower eyelids. Check for and remove any contact lenses.
Continue to rinse for at least 10 minutes. Get medical attention if
irritation occurs.
See section 11 for more detailed information on health effects and symptoms.
5.
FIRE-FIGHTING MEASURES
Extinguishing media
Suitable
Not suitable
Special exposure hazards
Hazardous combustion
products
Special protective
equipment for fire-fighters
6.
: In case of fire, use water spray (fog), foam, dry chemical or CO2.
: None known.
: No specific fire or explosion hazard.
Promptly isolate the scene by removing all persons from the vicinity
of the incident if there is a fire. No action shall be taken involving
any personal risk or without suitable training.
: Decomposition products may include the following materials:
carbon oxides
: Fire-fighters should wear appropriate protective equipment and selfcontained breathing apparatus (SCBA) with a full face-piece
operated in positive pressure mode.
Personal precautions
Environmental precautions : Avoid dispersal of spilt material and runoff and contact with soil,
waterways, drains and sewers. Inform the relevant authorities if the
product has caused environmental pollution (sewers, waterways, soil
or air).
Large spill
: Move containers from spill area. Prevent entry into sewers, water
courses, basements or confined areas. Vacuum or sweep up
material and place in a designated, labelled waste container.
Dispose of via a licensed waste disposal contractor. Note: see
section 1 for emergency contact information and section 13 for
waste disposal.
Small spill
Date of issue
: 2008-10-30
Page: 2/6
LEWATIT CNP 80
7.
00432903 / 1
Handling
Storage
Packaging materials
Recommended
Remarks
8.
: Not available.
Recommended monitoring
procedures
Date of issue
: 2008-10-30
Page: 3/6
LEWATIT CNP 80
00432903 / 1
Hand protection
Eye protection
Skin protection
Hygiene measures
9.
General information
Appearance
Physical state
: Solid. [beads]
Colour
: Beige. to Grey. opaque
Odour
: Characteristic.
Important health, safety and environmental information
pH
: 5 to 7 [Conc. (% w/w): 10%]
Density
: 1.18 kg/L (20 C)
Bulk density
: 750 to 850 kg/m3
Solubility
: Insoluble in the following materials: cold water
Ignition temperature:
: >250C
Date of issue
: 2008-10-30
Page: 4/6
LEWATIT CNP 80
00432903 / 1
Result
Species
Dose
LEWATIT CNP 80
LD50
* Rat
>5000
Oral
mg/kg
*Test results on an analogous product
Irritation/Corrosion
Skin
: Non-irritating, Rabbit.*
Eyes
: Non-irritating, Rabbit.*
Exposure
Test
Not available.
Hazardous waste
UN
Proper shipping name
number
Class
PG
Label
Additional
information
ADR/RID
Not regulated.
GGVSE
Not regulated.
ADNR
Not regulated.
Date of issue
: 2008-10-30
Page: 5/6
LEWATIT CNP 80
00432903 / 1
Regulation
UN
Proper shipping name
number
Class
PG
Label
Additional
information
IMDG
Not regulated.
IATA
Not regulated.
:
:
:
:
2008-10-30
2008-10-30
No previous validation
1
Date of issue
Date of previous issue
Version
Notice to reader
The data given here is based on current knowledge and experience. The purpose of this
Safety Data Sheet is to describe the products in terms of their safety requirements. The above
details do not imply any guarantee concerning composition, properties or performance.
Date of issue
: 2008-10-30
Page: 6/6