Professional Documents
Culture Documents
Asst Professor
Department of Electrical and Electronics Engineering, K L University
Vaddeswaram, Guntur, AP, India
I. INTRODUCTION
The
single-phase
to
single-phase
cycloconverter with mid-tap transformer type
converter is shown in Fig.1.
As shown in fig.1. in this type of
arrangement midpoint tap transformer is use to
obtain variable voltage and variable frequency.
Waveforms shown are obtained by varying the
number of cycle covered by positive and the
negative converters and firing angle.
Page 776
International Journal of Engineering Trends and Technology (IJETT) - Volume4Issue4- April 2013
III. WORKING
International Journal of Engineering Trends and Technology (IJETT) - Volume4Issue4- April 2013
i s
L r s L m r
L s L r L 2 m
i r
L s r L m s
L s L r L 2 m
ir
L s r L m s
L s L r L 2 m
s
s
r
r
L
L
L
L
i
i
i
i
L
L
L
L
i
i
i
i
i s
L r s L m r
L s L r L 2 m
d
r Te TL
dt
Where;
s , s , r , r
TL =Load torque,
J =Rotor moment of inertia,
V: SIMULATION RESULT
International Journal of Engineering Trends and Technology (IJETT) - Volume4Issue4- April 2013
Fig.4 (a) Source Voltage (b) Output Voltage (c)
Output current Waveform of Single Phase to Single
Phase Cycloconverter When Input Frequency is Two
Times Output Frequency.
VI: CONCLUSION
1.
2.
Page 779
International Journal of Engineering Trends and Technology (IJETT) - Volume4Issue4- April 2013
3.
4.
Page 780