Professional Documents
Culture Documents
F
r
e
e
P
l
a
n
s
t
o
Build a Dining Chair #1
When I construct chairs like this, I like to purchase 2x4s and 1x6s then rip them down on
the table saw. It is much more economical, for me anyway, and I dont have to hunt for 2x2s
that are straight!
Materials:
Lumber:
1 24 at 6
1 16 at 6
Scrap of 3/4 plywood for the seat
Cut List:
2. Cut the pieces for the back apron and the back slats. For the upper slat, draw the arc as
shown and cut out using a jigsaw or a bandsaw. For the lower slats, draw the curves as
shown on one piece and cut out. Clamp this board to the second board and trace the curves,
then cut out. Keeping the boards clamped together, sand both at the same time. (I am
incredibly OCD about this and tend to get frustrated if the pieces dont match!) Drill pocket
holes in each end of each piece. Secure using glue and 1-1/4 pocket hole screws. The front
faces of the slats will be flush with the front faces of the legs.
Drill pocket holes in each end of the back apron. Secure the piece as shown, the outer face
will be flush with the back face of the lower legs.
3. Cut the pieces for the front frame. Drill pocket holes in each end of the apron. Secure
using glue and 1-1/4 pocket hole screws. The front faces of the apron will be flush with the
front faces of the legs.
4. Cut the pieces for the stretchers and drill pocket holes in each end. Secure as shown
using glue and 1-1/4 pocket hole screws in the front leg, and 2 pocket hole screws in the
back legs.
5. Cut the piece for the seat. Cut the notches for the legs as shown and apply edge banding
if desired. Secure the seat to the frame using glue and 1-1/4 brad nails.
Finish as desired.
Got a project youve completed using my plans? Share photos with me at cher {at}
designsbystudioc {dot} com or designsbystudioc {at} gmail {dot} com. I would love to
feature your work on DbSC!
Until next time,
Happy Creating!
#DIY #Build #Woodworking