Professional Documents
Culture Documents
I.
K.BHAVYA
Assistant Professor
Department of Electrical & Electronics Engineering,
Gudlavalleru Engineering college, JNTU K
Gudlavalleru, A.P, India.
e-mail: bhavya.eee.08@gmail.com
DC converter with shared ZCS lagging leg.[10] It is used
to full bridge converters so cost is high.
Finally to propose single input multiple output
converter with coupled inductor [1]. It uses only single
switch and to obtain the different output voltage levels.
Soft switching and voltage clamping techniques are used to
reduce switching and conduction losses.
In this paper fuel cell is used as the input so to
eliminate the environment pollution [2]-[7]. Fuel cell is a
device; it converts chemical energy into electricity through
a chemical reaction with oxidizing agent or oxygen. Fuel
cell has many applications. They are used in automobiles,
airplanes, boats, submarines and hybrid vehicles.
II.
INTRODUCTION
PROPOSED CONVERTER
www.iaetsd.in
< <
Mode 1: (
III.
MODES OF OPERATION
< <
Apply KVL
Mode 4: (
< <
+
(1 ) = 0
= [ /(1 )]
=
= [ /(1 )]
)
www.iaetsd.in
< <
+1
1
1
< <
(1
=0
www.iaetsd.in
IV.
SIMULATION RESULTS
The simulation circuit of single input multiple outputs DCDC converter is shown in below and to observe the low
power DC to DC converter and high power DC to DC
converter waveforms of voltage and current across the high
voltage side, auxiliary circuit and main switch are shown in
below.
Case-1 Low power DC to DC Converter
Fig.8 Simulated output wave form of the VD4,iD4 in Low power DC
to DC converter
www.iaetsd.in
V.
BLDC MOTOR
www.iaetsd.in
VI.
SIMULATION RESULTS
The simulation circuit of single input multiple outputs DCDC converter with BLDC motor is shown in fig 10 and to
observe the response of speed and torque are shown in
below.
www.iaetsd.in
VII.
CONCLUSION
www.iaetsd.in