Professional Documents
Culture Documents
t
A
B
C
D
A pump being used to deballast for peak tank which is full, it it seen that suct
ion pressure is Positive and this pressure is very low compared to rated dischar
ge head, it indicates that
a. Pump is not operating satisfactorily n pump capacity is too low
b. Pump is not operating satisfactorily n Pumping capacity is higher than rated,
Throttling of discharge valve is reqd.
c. Pumping capacity is not affected by suc n discharge pressure
d. Pump is operating normally
Answer-May be D Not Sure
While calibrating bourdan tube gauge..adjustment should be made by
. increasing the sector to pivot point length
. resetting the pointer on shaft
. decreasing the sector to pivot point length
. increasing the set screw length
Answer-Not Sure
Which factor must be considered when determining the order of loading of dissimi
lar products through the same piping system aboard a tanker?
Contamination of the cargo
Flash points
Reid vapor pressures
Specific gravities
Leaking valves in a low pressure, reciprocating, air compressor can result from
__________ .
excessive compressor discharge pressure
operating the compressor at excessive speed
uneven piston stroke in the compressor
abrasion by dust and dirt
The turbocharger (constant pressure) is making "whoofing" noises. What might be
the cause?
A Heavy seas from behind.
B A faulty turbocharger bearing.
C One or more leaking exhaust-valve(s).
D Strong current against
Answer-Not sure Check in Forums
When there is excessive ingress of water in the engine room onboard causing dang
erous levels of bilge water,
A.Start oily water separator and pump overboard
B.Start General service pump and pump bilges overboard
C.Use bilge injection valve and pump bilges overboard
D.None of the above
r.
Dehumidification is process of removing water/moisture from air supplied from AC
system.
For collecting gas in receiver you need to close the outlet valve of receiver wi
th compressor running
A.
Purging
B.
Collecting
C.
condensing
Answer-NOT SURE
which of the following is considered to be the safest protection from static ele
ctric discharge,when connecting or disconnecting cargo hoses and metal arms?
A.
Insulating flange or a length of non-conducting hose
B.
Switching off ICCP
C.
Ship shore bonding cable
D.
None of the above
Answer-NOT SURE
Dry chemical fire
lasses of fires?
A.
Class A
B.
Class B
C.
Class B
Answer-NOT SURE
only D.
Class A
and
only
113)Despatch is normally:
A.
Payable by the charterers to owners if cargo operations
ter expiry of lay time
B.
Payable by owners to charterers if cargo operations are
expiry of lay time
C.
Payable by the owners to charterers if cargo operations
ter expiry of lay time
D.
Payable by charterers to owners if cargo operations are
expiry of lay time
Answer-NOT SURE
are completed af
completed before
are completed af
completes before
145)In refrigeration system vegetable room and meat rooms are maintained at diff
erent? (A or b)
A.
Different expansion valves
B.
By putting solenoid valves
C.
By boiling the refrigerant at different pressures(correct)
D.
By using samller evaporator
Answer-C
180)What is the Fresh Water Allowance? A. x/5TPC cm; B. x/40TPC cm C. x/10TPC cm
; D. x/20TPC cm B
187)Which of the following codes is mandatory for chemical tankers constructed o
n or after 1July2010
A. IGC code
B. BCH code
C. IBC code
D. IMDG code
Answer-NOT SURE
236).M/C space opening are to have _____door with ______ position.
NOT SURE
ELECTRICAL
QA.
B.
C.
D.
The winding resistance of a coil can be increased by _______ the number of turns
or using a ______ wire.
A. increasing, thicker
B. decreasing, thicker
C. increasing, thinner
D. decreasing, thinner
1.
Which of the following statements is true concerning a poly-phase synchr
onous propulsion motor?
A.
The motor is started as an induction motor.
B.
Resistance is gradually added to the rotor circuit.
C.
The starting current is held below the rated current.
D.
The field winding is energized for starting purposes only.
Answer2.
When reading electrical motor controller diagrams, it helps to know that
____________.
A.
current paths in the control circuit are drawn as heavy lines and in the
power circuit as lighter lines
B.
current paths in the power circuit are drawn as heavy lines and in contr
ol circuit as lighter lines
C.
circuits subject to 500 volts or greater are drawn as heavy lines and be
low 500 volts as lighter lines
D.
circuits subject to 500 volts or greater are drawn as light lines and be
low 500 volts as heavy
Answer3.
Alternating current circuits develop resistance, inductance and capacita
nce. The inductance of a coil is expressed in _____________.
A.
ohms
B. mhos
C. henrys
D. farads
Answer4.
Large cable sizes are formed as individual conductors that may be compri
sed of several smaller strands to __________.
A.
obtain the flexibility required for easy handling
B.
reduce the overall weight of the wire run
C.
reduce the number of supports needed for a horizontal overhead run
D.
all of the above
Answer5.
Which of the following is having Di-Electric Constant 80?
A.
Air
B. water
C. Mica
D. Caster oil
Answer6.
Where a thermal-acting breaker is required to be used in an area of unus
ually high, low, or constantly fluctuating temperatures, an ambient compensating
element must be used. This element consists of a ______________.
A.
cylindrical spring on the contact arm
B.
conical spring on the contact arm
C.
second bimetal element
D.
second electromagnet
Answer7.
Which of the following precautions should you take when securing propuls
ion generators and motors for an extended period of time?
A.
Disconnect the brush pigtails from their contacts and circulate air thro
ugh the units.
B.
Disconnect the brush pigtails from their contacts and discharge carbon d
ioxide into the units to keep them dry.
C.
Lift the brushes from commutator collector rings and use the built-in he
ater to prevent moisture accumulation.
D.
Lift the brushes from commutator collector rings and circulate cool dry
air through the units.
Answer8.
The direction of magnetic flux changes when the direction of current is
reversed.
True
False
Answer9.
A.
B.
C.
D.
Answer-
In a Transistor
PNP and NPN are two basic types
Emitter,Collector and Base are the basic Elements.
Collector separates Base and Emitter
Emitter separates Base and Collector
A. obtain
B. reduce
C. reduce
D. all of
Answer-
the
the
the
the
c faraday
d henry
10 open loop function system having one zero positiva real valueof __________ ph
ase function
11 semmi conductor failed to over curent reason___low breakdown voltage___ and__
_______
12 sum 700w 36dayslike tht question 700xdays 36 x one day 24/ 1000
13 three resistor 40,50,60 connected in series input 30v calculate voltage drop
across 60 resistor
GENERAL ENGINEERING 2005 OBJECTIVE PAPER
Q- Before the longitudinal carriage feed of a lathe is engaged, you must be cert
ain the
A. spindle clutch is disengaged
B. carriage clamp screw is loosened
C. carriage stop clamp is tightened
D. thread dial indicator is zeroed
Q- corrosion occurs in cooling fresh water system
A. stress corrosion
B. hot corrosion
C. bi metalic corrosion
D. selective phase corrosion
Answer-Dont Know
Qa)
b)
c)
d)
enlarging one tube end so the other end of another tube of same size will fit in
side is termed as
A belling B stretching C flaring D swaging