Professional Documents
Culture Documents
2) There has been a chemical spillage into the warehourse. The department that
would deal with this is
a) RIDDOR
b) COSHH
c) EAWR
d) Control of dangerous chemicals and waste
4) A 1kW load is connected to a 230V supply at a power factor of 0.6 the supply
current will be
a) 4.34A
b) 7.24A
c) 230A
d) 1000A
5) In a star connected supply system the relationship between Line and Phase
voltages are
a) VL = VP x ?3
b) VL = VP ? ?3
c) VP = VL x ?3
d) VP = VL ? ?3
VL = VP x the square root of 3 or VP = VL divided by the square root of 3
6) On a 33Kv/ 400v star delta transformer the transformer earth will be connected
to
a) The transformer core
b) The star point c) To the delta connection
d) There will be no earth connection
7) A transformer has a input power of 10kVA and a power factor 0f 0.8 if the
losses are 490 Watts the overall efficiency is
a) 96%
b) 93%
c) 95.1%
d) 90%
I'm assuming that the power factor is a red herring, if the manufacturer has
stated 10kvA as the input power then surely they would be aware of its reactive
component and assuming it is for a 50Hz supply they would now its pf and the
stated 10kvA would be after the power factor is taken into consideration
12) An electronic component has the following connections Anode, Cathode, Gate.
The component is a
a) A transistor
b) A triac
c) A diac
d) A thyristor
a) Closed switch
b) Open switch
c) Amplifier
d) Inverter
14) The following resistors are connected in series to a 230V supply 10?, 20 ?, 40
?. Calculate the power dissipated by the 40? resistor
a) These are not the values in the exam but the question is!
431.8w
a) These are not the values in the exam but the question is!
12.2 ohms
a) These are not the values in the exam but the question is!
10.44 ohms
17) The two appropriate starters for a 10kW squirrel cage induction motor are
a) Rotor resistance and a star/delta
b) DOL and a rotor resistance
c) Rotor resistance and a Auto transformer
d) Auto transformer and a star/delta
18) On a squirrel cage motor the conducting bars in the rotor will be
a) Open circuit
b) Shorted out by the end rings
c) Fed an ac supply
d) Connected to the stator windings