You are on page 1of 13

S No.

Step/Description

10
11

Paging Timers Check


Paging Strategy to be changed from repeated Global to
Local with IMSI
BTDM to be changed from 120 to 60
T3212 to be changed from 20 to 10
MP Load
Signaling Link Utilisation
LAC Duplicacy - Definition of LAC 33013 to be removed
from HPRSM01
EOS Check
SAE Check
LAC Boundry - LAC-33012 is serving two disconnected
areas in HP.
UTRAN Rejections

12
13

Analysis of Paging Attempt Counters at RNC level


Paging without paging area ID (Paging Type 2)

14
15
16
17

3G PCH Capacity / Paging Congestion


CCSP Load
Number of preconfigured subsequent transmissions of
the same Paging Record
Software Correction Check in MSC-S

18
19
20

RRC connection Establishment Success Rate


Admission control feature
SCCP Establishment Success Rate

21
22

URA_PCH Mode (Active/Not)


inactivityTimerPch & inactivityTimer,
hsdschInactivityTimer

23

Paging Intensity - No. of pages per second

24
25

RAB Assignment Success Rate


NBAP Failures

26

RANAP

27

t305 (periodic URA update) timer

28
29

utranDrxCycleLength (For UTRAN initiated paging)


Paging Area Dimensioning

2
3
4
5
6
7
8
9

30
31
32
33
34
35
36
37
38
39
40
41
42
43

Inappropriate CN paging retransmission


Inappropriate time interval setting
Inappropriate Utran paging retransmission and time
interval setting
DRX Circle Value unreasonable setting
NP Value reasonable
CN use whole-network paging
CN pages with the wrong UE identifier
PCH/PICH channel power is set too low
Coverage Hole
UE Performance
Implied Shutdown Timer(Related to Paging Success
Rate)
UE Location Area Updating Timer
Physical Paging Channel Power Setting(PICH and SCCPCH)
UE Accessibility Parameter: Maximum Access Attempts,
Preamble Power, etc

Commands/Counters

pmNoPagingAttemptUtranRejected
RNC_Paging.doc

pcong = {pmNoPagingAttemptUtranRejected/(npag*ncell)}
npag = pmCnInitPagingToIdleUeLa + pmCnInitPagingToIdleUe +
+ pmCnInitPagingToIdleUeRa + pmCnInitPagingToUraUe +
+ pmUtranInitPagingToUraUe

get . NoOfPagingRecordTransm
:pmTotNoTermRrcConnectReq, pmTotNoTermRrcConnectReqSucc,
pmTotNoTermRrcConnectReqCs, pmTotNoTermRrcConnectReqCsSucc

get RncFeature=RabCombination021, get uerc label ura


Also check the following counters : pmCnInitPagingToUraUe, pmSamplesRabUra,
pmSumRabUra, pmUtranInitPagingToUraUe, pmNoUraUpdSuccess, pmNoUraUpdAttempt,
pmNoSystemRabReleasePacketUra, pmNoNormalRabR
get . inactivityTimerPch, get . Inactivitytimer, get ChannelSwitching
Npag = (pmCnInitPagingToIdleUeLa + pmCnInitPagingToIdleUe+
pmCnInitPagingToIdleUeRa)*noOfPagingRecordTransm
pmNoFailedRabEstAttemptLackDlChnlCode, pmNoFailedRabEstAttemptLackDlPwr,
pmNoFailedRabEstAttemptLackDlAse, pmNoFailedRabEstAttemptLackUlAse,
pmNoFailedRabEstAttemptExceedConnLimit, pmSumCompMode / pmSamplesCompMode
(Number of CM Users per Cell), pmNoOfNon
pmNoOfDiscardedNbapcMessages
Counters for monitoring abnormal RANAP release : pmNoSystemNasSignReleaseCs,
pmNoSystemNasSignReleasePs, pmNoSystemRabReleaseSpeech,
pmNoSystemRabReleaseAmrNb, pmNoSystemRabReleaseCs64,
pmNoSystemRabReleaseCsStream, pmNoSystemRabReleasePacket, pmNoSystem
get . T305
get . utranDrxCycleLength

cnDrxCycleLengthCs (for CS) and cnDrxCycleLengthPs (for PS).

pich power and pch power

Comments

Valid only when URA_PCH mode is


active and working

Valid only when URA_PCH mode is


active and working
Valid only when URA_PCH mode is
active and working

Closed
Pending
Ongoing

You might also like