Professional Documents
Culture Documents
Concrete technology
MM: 50
M. Time: 1hr.
1) The property of fresh concrete, in which the water in the mix tends to rise to the
surface while placing and compacting, is called ___________________.
2) Select the incorrect statement
a) Lean mixes bleed more as compared to rich ones.
b) Bleeding can be minimized by adding pozzuolana finer aggregate.
c) Bleeding can be increased by addition 'of calcium chloride.
d) None of the above
3) The property of the ingredients to separate from each other while placing the concrete
is called_____________________________.
4) Workability of concrete is directly proportional to
a) Aggregate cement ratio
b) Time of transit
c) Grading of the aggregate
d) All of above
5) Approximate value of shrinkage strain in concrete, is_________________.
6) Air entrainment in the concrete Increases ___________________.
7) Strength of concrete Increases with
12)
13)
14)
15)
18)
19)
20)
29) The main reason for providing number of reinforcing bars at a support in a simply
supported beam is to resist in that
a) Compressive stress
b) Shear stress
c) Bond stress
d) Tensile stress
30) Which of the following has high tensile strength?
a) Plain hot rolled wires
b) Cold drawn wires
c) Heat treated rolled wires
d) All have same tensile strength
31) High carbon content in the steel causes
a) Decrease in tensile strength but Increase in ductility
b) Increase in tensile strength but Decrease in ductility
c) Decrease in both tensile strength and ductility
d) Increase in both tensile strength and ductility.
32) Stress strain curve of high tensile steel.
a) Has a definite yield point
b) Does not show definite yield point but yield point is defined by 0.1% proof stress
c) Does not show definite yield point but yield point is defined by 0.2% proof stress
d) Does not show definite yield point but yield point is defined by 2% proof stress
33) Select the correct statement.
a) Elastic modulus of high tensile steel is nearly the same as that of mild steel.
b) Elastic modulus of high tensile steel is more than that of mild steel.
c) Carbon percentage in high carbon steel is less than that in mild steel.
d) High tensile steel is cheaper than mild steel.
34) For quality control of Portland cement, the test essentially done is
a) setting time
b) soundness
c) tensile strength
d) consistency
e) all the above
35) If 1500 g of water is required to have a cement paste 1875 g of normal consistency,
the percentage of water is ________________.
36) Under normal conditions using an ordinary cement, the period of removal of the form
work, is :
a) 7 days for beam soffits
b) 14 days for bottom slabs of spans 4.6 m and more
c) 21 days for bottom beams over 6 m spans
d) 2 days for vertical sides of columns
e) all the above
37) Wp and Wf are the weights of a cylinder containing partially compacted and fully
38) On given water content, workability decreases if the concrete aggregates contain an
excess of
a) thin particles
b) flat particles
c) elongated particles
d) flaky particles
e) all the above
39) M10 grade of concrete approximates
a) 1 : 3 : 6 mix
b) 1 : 1 : 2 mix
c) 1 : 2 : 4 mix
d) 1 : 1.5 : 3 mix
e) none of these
40) For ensuring quality of concrete, use
a) single sized aggregates
b) two sized aggregate
c) graded aggregates
d) coarse aggregates
41) According to I.S. : 456, the number of grades of concrete mixes, is ___________.
e) 12 mm
45) The process of proper and accurate measurement of concrete ingredients for
uniformity of proportion, is known
a) Grading
b) Curing
c) Mixing
d) Batching
e) none of these
47) The preliminary test is repeated if the difference of compressive strength of three test
specimens, exceeds
a) 5 kg/cm2
b) 8 kg/cm2
c) 10 kg/cm2
d) 12 kg/cm2
e) 15 kg/cm2
48) Pick up the correct proportions of chemical ingredients of cement.
a) Lime : Silica : Alumina : Iron oxide : 63 : 22 : 6 : 3
b) Silica : Lime : Alumina : Iron oxide : 63 : 22 : 6 : 3
c) Alumina : Silica : Lime : Iron oxide : 63 : 22 : 6 : 3
d) Iron oxide : Alumina : Silica : Lime : 63 : 22 : 6 : 3
a)
b)
c)
d)
e)
Cement
Aggregates
Admixture
Water
All the above.