Professional Documents
Culture Documents
H Type
yp connector-ODU
H-LP-8DFB(S)
L Type connector-IDU
N-LP-8DFB
N-LP-TNC
IF Cable connector
H Type connector-ODU
H-LP-8DFB(S)
L Type connector-IDU
N-LP-8DFB
N LP TNC
N-LP-TNC
IF Cable connector
H Type connector-ODU
H-LP-8DFB(S)
L Type connector-IDU
N-LP-8DFB
N LP TNC
N-LP-TNC
N-LP-8DFB
IDU Instruction
L-Type connector-1
1 Take off the Tightenig nut fitting and take each part from the mainbody
1.
mainbody.
January 13, 2007
L-Type connector-2
L-Type
yp connector-3
Clamp
Hood
3.Insert the clamp to the stripped cable jacket end. Open the end of the outer conductor a
little.
4. Insert the hood between the plastic tape with aluminum foil and the outer conductor.
5. No gap is allowed in between the clamp, the outer conductor and the hood.
January 13, 2007
L-Type connector-4
6. After inserting the hood, cut off the plastic tape with aluminum foil and the
dielectric at A
A-surface
surface.
7. Cut off the part of the outer conductor exceeding the clamp rim with a scissor.
8. Check that distance between the tip of the center conductor and A-Surface is
6 7mm Chamfer at the tip of the inner conductor.
6-7mm.
conductor
January 13, 2007
10
L-Type connector-5
9. Insert the insulation washer to the center conductor, and engage it the F/f
Contact.
10 N
10.
No gap iis allowed
ll
d iin bbetween
t
th
the F/F C
Contact,
t t th
the iinsulation
l ti washer,
h
and the dielectric.
11. Combine the convex part of the clamp to the concave part of the gasket.
January 13, 2007
11
L-Type connector-6
1-2mm
12. Tighten the tightening nut sufficiently until the gasket is cut by the
13. Torque fot the tightening nut shall be 8-30N-m.
g
g nut is 1-2mm.
14. Distance between the tightening
January 13, 2007
12
IF Cable connector
L Type connector-IDU
N-LP-8DFB
N-LP-TNC
14
15
16
17
18
19
20
21