Professional Documents
Culture Documents
AMENDMENT RECORD
Amd No
Date
Text Affected
REVISION NOTE
This standard is raised to Issue 1 to update its content.
HISTORICAL RECORD
This standard supersedes the following:
Naval Engineering Standard (NES) 106 Part 2 Issue 1 dated July 1993.
Ministry of Defence
NES 106
Part 2
Issue 1 (Reformatted)
REQUIREMENTS FOR
MEDICAL AND DENTAL ORGANIZATION
IN HM SURFACE SHIPS AND SUBMARINES
PART 2
SPECIFIC REQUIREMENTS
MEDICAL AND DENTAL FACILITIES
IN HM SURFACE SHIPS
July 1993
Record of Amendments
AMDT
1
2
3
4
5
6
7
8
9
10
INSERTED BY
DATE
ECROWN COPYRIGHT
Published by:
Director of Naval Architecture
Procurement Executive, Ministry of Defence
Sea Systems, Foxhill, Bath BA1 5AB
i
ii
NES 106
Part 2
Issue 1 (Reformatted)
SCOPE
1.
This Part of the NES defines the Specific Requirements of Medical and Dental Facilities in HM
Surface Ships.
2.
The Specific Requirements for Medical Organization in ActionHM Surface Ships are
covered by part 3 of this NES.
iii
NES 106
Part 2
Issue 1 (Reformatted)
iv
NES 106
Part 2
Issue 1 (Reformatted)
FOREWORD
Sponsorship
1.
This Naval Engineering Standard (NES) is sponsored by the Procurement Executive, Ministry
of Defence, Director Naval Architecture (DNA), Section NA 145.
2.
Part 2
Part 3
Part 4
The Specific Requirements are to be read in conjunction with the Common Requirements
Part 1.
3.
4.
Any user of this NES either within MOD or in industry may propose an amendment to it.
Proposals for amendments that are
a.
not directly applicable to a particular contract are to be made to the Sponsor of the NES
b.
directly applicable to a particular contract are to be dealt with using existing procedures
or as specified in the contract.
5.
6.
Unless otherwise stated, reference in this NES to approval, approved, authorized or similar
terms, means by the Ministry of Defence in writing.
7.
Any significant amendments that may be made to this NES at a later date will be indicated
by a vertical side line. Deletions will be indicated by 000 appearing at the end of the line
intervals.
8.
This NES has been reissued to reflect changes in technical requirements and supersedes
DGS 89 and 90.
Conditions of Release
General
9.
This Naval Engineering Standard (NES) has been prepared for the use of the Crown and of
its contractors in the execution of contracts for the Crown. The Crown hereby excludes all
liability (other than liability for death or personal injury) whatsoever and howsoever arising
(including but without limitation, negligence on the part of the Crown, its servants or agents)
for any loss or damage however caused where the NES is used for any other purpose.
10.
This document is Crown Copyright and the information herein may be subject to Crown or
third party rights. It is not to be released, reproduced or published without written permission
of the MOD.
NES 106
Part 2
Issue 1 (Reformatted)
11.
The Crown reserves the right to amend or modify the contents of this NES without consulting
or informing any holder.
This NES is the property of the Crown and unless otherwise authorized in writing by the MOD
must be returned on completion of the contract, or submission of the tender, in connection
with which it is issued.
13.
When this NES is used in connection with a MOD tender or contract, the user is to ensure that
he is in possession of the appropriate version of each document, including related documents,
relevant to each particular tender or contract. Enquiries in this connection may be made of
the local MOD(PE) Quality Assurance Representative or the Authority named in the tender
or contract.
14.
When NES are incorporated into MOD contracts, users are responsible for their correct
application and for complying with contracts and any other statutory requirements.
Compliance with an NES does not of itself confer immunity from legal obligations.
Related Documents
15.
In the tender and procurement processes the related documents listed in each section and
Annex A can be obtained as follows:
a.
British Standards
b.
Defence Standards
c.
d.
Other documents
All applications to Ministry Establishments for related documents are to quote the relevant
MOD Invitation to Tender or Contract Number and date, together with the sponsoring
Directorate and the Tender or Contract Sponsor.
17.
Prime Contractors are responsible for supplying their subcontractors with relevant
documentation, including specifications, standards and drawings.
vi
NES 106
Part 2
Issue 1 (Reformatted)
This NES may call for the use of processes, substances and/or procedures that may be injurious
to health if adequate precautions are not taken. It refers only to technical suitability and in
no way absolves either the supplier or the user from statutory obligations relating to health
and safety at any stage of manufacture or use. Where attention is drawn to hazards, those
quoted may not necessarily be exhaustive.
vii
NES 106
Part 2
Issue 1 (Reformatted)
viii
NES 106
Part 2
Issue 1 (Reformatted)
CONTENTS
Page No
TITLE PAGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SCOPE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
iii
FOREWORD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sponsorship . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Conditions of Release . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
MOD Tender or Contract Process . . . . . . . . . . . . . . . . . . . . . . . . . .
Related Documents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Health and Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
v
v
v
v
vi
vi
vii
vii
CONTENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ix
SECTION
1.
1.1
1.2
1.3
1.4
1.4.1
1.4.2
1.4.3
1.5
LOBBY/WAITING AREA . . . . . . . . . . . . . . . . . . . . .
Area . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hinged Benching . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Access . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Alarm and Call Systems . . . . . . . . . . . . . . . . . . . . . . .
Crash-on-Deck Alarm . . . . . . . . . . . . . . . . . . . . . . . .
Patient Call System . . . . . . . . . . . . . . . . . . . . . . . . . .
Attendant Call System . . . . . . . . . . . . . . . . . . . . . . . .
Switch Sockets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1.1
1.1
1.1
1.1
1.1
1.1
1.2
1.2
1.2
SECTION
2.
2.1
2.2
2.3
2.4
2.1
2.1
2.1
2.1
2.8
RECEPTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Layout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Whereabouts DiagramMedical Organization
for Action . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Chairs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
OASIS Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . .
Switch Sockets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FIGURE 2.1 TYPICAL LAYOUT OF RECEPTION
FOR CLASS A SHIPS . . . . . . . . . . . . . . . . . . . . . . . .
TABLE 2.1 RECEPTION EQUIPMENT . . . . . . . .
Communications . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
3.
3.1
3.2
3.3
3.4
3.5
3.6
3.7
3.8
CONSULTING ROOM . . . . . . . . . . . . . . . . . . . . . . .
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Layout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Patient Call System . . . . . . . . . . . . . . . . . . . . . . . . . .
Examining Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Chair . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Switch Sockets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Communications . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2.5
2.6
2.7
SECTION
ix
2.1
2.1
2.1
2.1
2.2
2.3
2.3
3.1
3.1
3.1
3.1
3.1
3.1
3.1
3.1
3.1
NES 106
Part 2
Issue 1 (Reformatted)
4.
4.1
4.2
4.3
4.4
4.5
4.6
4.7
4.8
4.9
4.10
4.11
4.12
4.13
4.14
4.15
4.16
4.17
4.18
4.19
4.20
SECTION
SECTION
5.
5.1
5.2
5.3
5.4
5.5
5.6
5.7
5.8
5.9
6.
6.1
6.2
6.3
6.4
6.5
SURGERY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Layout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operating Table . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Medicine and Dressing Stowage . . . . . . . . . . . . . . . .
Controlled Drugs/Poisons Cupboards . . . . . . . . . . .
FIGURE 4.1 TYPICAL LAYOUT OF SURGERY
TABLE 4.1 SURGERY EQUIPMENT . . . . . . . . . .
Surgeons Washbasin . . . . . . . . . . . . . . . . . . . . . . . . .
Soiled Dressings Bin . . . . . . . . . . . . . . . . . . . . . . . . . .
Surgeons Desk . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Whereabouts Diagram . . . . . . . . . . . . . . . . . . . . . . . .
Chairs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Refrigerator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Curtain . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Dental Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Switch Sockets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operating Table Lights . . . . . . . . . . . . . . . . . . . . . . .
Communications . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fire Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4.1
4.1
4.1
4.1
4.1
4.1
4.1
4.1
4.2
4.3
4.4
4.4
4.4
4.4
4.4
4.4
4.4
4.5
4.5
4.5
4.5
4.5
4.5
TREATMENT ROOM/DISPENSARY . . . . . . . . . . .
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Layout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Resuscitation TrolleyClass A Ships . . . . . . . . . . . .
Controlled Drugs/Poisons Cupboard . . . . . . . . . . . .
Worktops . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Refrigerator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Switchsockets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FIGURE 5.1 TYPICAL LAYOUT OF
TREATMENT ROOM/DISPENSARY . . . . . . . . . . .
TABLE 5.1 TREATMENT ROOM/DISPENSARY
EQUIPMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
5.1
5.1
5.1
5.1
5.1
5.1
5.1
5.1
5.1
5.2
OPERATING THEATRE . . . . . . . . . . . . . . . . . . . . .
Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Layout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operating Table . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
6.1
6.1
6.1
6.1
6.1
6.1
5.3
5.4
NES 106
Part 2
Issue 1 (Reformatted)
6.6
6.7
6.8
6.9
6.10
6.11
6.12
6.13
6.14
6.15
6.16
6.17
SECTION
SECTION
7.
7.1
7.2
7.3
7.4
7.5
6.1
6.1
6.2
6.3
6.4
6.5
6.5
6.5
6.5
6.5
6.5
6.5
6.5
6.6
6.6
7.6
7.7
7.8
7.9
7.10
7.11
7.12
7.13
7.14
7.15
7.16
7.17
7.18
7.19
7.20
7.21
DENTAL SURGERY . . . . . . . . . . . . . . . . . . . . . . . . .
Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Layout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Dental Chair . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Dental Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FIGURE 7.1 TYPICAL LAYOUT OF DENTAL
SURGERY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TABLE 7.1 DENTAL SURGERY EQUIPMENT . .
X-Ray Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
X-Ray Protection Apron Stowage . . . . . . . . . . . . . . .
X-Ray in Progress Warning Light . . . . . . . . . . . . .
Clinical Area Worktops and Units . . . . . . . . . . . . . .
Clinical Area Washbasin . . . . . . . . . . . . . . . . . . . . . .
Sterilizing/Clean Area Worktop and Units . . . . . . .
Sterilizing/Clean Area Sink . . . . . . . . . . . . . . . . . . . .
Fitted Unit Interiors . . . . . . . . . . . . . . . . . . . . . . . . . .
Sterilizing Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ultrasonic Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Clerical AreaSurgeons Desk . . . . . . . . . . . . . . . . .
Surgeons Chair . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Patient Call System . . . . . . . . . . . . . . . . . . . . . . . . . .
Operating Stools . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Switch Sockets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Communications . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
7.2
7.3
7.3
7.4
7.4
7.4
7.4
7.4
7.4
7.4
7.4
7.4
7.4
7.5
7.5
7.5
7.5
7.5
8.
8.1
8.2
8.3
DENTAL LABORATORY . . . . . . . . . . . . . . . . . . . . .
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Layout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
8.1
8.1
8.1
8.1
xi
7.1
7.1
7.1
7.1
7.1
7.1
NES 106
Part 2
Issue 1 (Reformatted)
8.4
8.5
8.6
8.7
8.8
8.9
8.10
8.11
8.12
8.13
8.14
8.15
8.16
SECTION
9.
9.1
9.2
9.3
9.4
9.5
9.6
9.7
9.8
9.9
9.10
9.11
9.12
SECTION
10.
10.1
10.2
10.3
10.3.1
10.3.2
Fitted Units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Workbench . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sink and Worktop . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lathe Bench . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FIGURE 8.1 TYPICAL LAYOUT OF DENTAL
LABORATORY . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TABLE 8.1 DENTAL SURGERY EQUIPMENT . .
FIGURE 8.2 WASTE CHUTE IN SINK
UNIT DENTAL LABORATORY . . . . . . . . . . . . . . .
Dental Vibrator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Dental Plaster Trimmer . . . . . . . . . . . . . . . . . . . . . . .
X-Ray Film Processor . . . . . . . . . . . . . . . . . . . . . . . .
Lathe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Warning Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Dark Room Light . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Switch Sockets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Communications . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PATHOLOGICAL LABORATORY/DARK
ROOM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Layout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Pathological Bench Unit . . . . . . . . . . . . . . . . . . . . . . .
Sink and Cupboard Unit . . . . . . . . . . . . . . . . . . . . . .
Developing Tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Film Drying Rack . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Refrigerator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Deep Freezer Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Warning Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Dark Room Light . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Switch Sockets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FIGURE 9.1 TYPICAL LAYOUT OF
PATHOLOGICAL
LABORATORY/DARK ROOM . . . . . . . . . . . . . . . .
TABLE 9.1 PATHOLOGICAL
LABORATORY/DARK ROOM EQUIPMENT . . .
WARDS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ward Accommodation . . . . . . . . . . . . . . . . . . . . . . . .
Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Layout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Main Ward . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Isolation Ward . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FIGURE 10.1 TYPICAL LAYOUT OF CLASS A
MAIN WARD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FIGURE 10.2 TYPICAL LAYOUT OF CLASS B
MAIN WARD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FIGURE 10.3 TYPICAL LAYOUT OF CLASS C
MAIN WARD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
xii
8.1
8.1
8.1
8.1
8.2
8.3
8.4
8.5
8.5
8.5
8.5
8.5
8.5
8.5
8.5
8.5
9.1
9.1
9.1
9.1
9.1
9.1
9.1
9.1
9.1
9.1
9.1
9.1
9.2
9.3
9.4
10.1
10.1
10.1
10.1
10.1
10.1
10.2
10.3
10.4
NES 106
Part 2
Issue 1 (Reformatted)
10.4
10.5
10.6
10.7
10.8
10.9
10.10
10.11
10.12
10.13
10.14
10.15
10.16
10.17
10.18
10.19
10.20
SECTION
11.
11.1
11.2
11.3
11.4
11.5
11.6
11.7
11.8
11.9
11.10
SECTION
12.
12.1
12.2
12.3
12.4
12.5
12.6
12.7
10.5
10.6
10.6
10.6
10.6
10.6
10.6
10.6
10.6
10.7
10.7
10.7
10.7
10.7
10.7
10.7
10.7
10.8
10.9
WARD PANTRY . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Layout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sink Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Worktops . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cupboards and Drawer Units . . . . . . . . . . . . . . . . . .
Shelves . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FIGURE 11.1 TYPICAL LAYOUT OF WARD
PANTRY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TABLE 11.1 EQUIPMENT REQUIREMENT
FOR WARD PANTRY . . . . . . . . . . . . . . . . . . . . . . . .
Tea Urn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Electrical Requirements . . . . . . . . . . . . . . . . . . . . . . .
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
STERILIZING ROOM . . . . . . . . . . . . . . . . . . . . . . .
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Layout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Deck Drains . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FIGURE 12.1 TYPICAL LAYOUT OF
STERILIZING ROOM . . . . . . . . . . . . . . . . . . . . . . .
TABLE 12.1 STERILIZING ROOM
EQUIPMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fitted Units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emergency Water Tank . . . . . . . . . . . . . . . . . . . . . . .
Instrument Sterilizer . . . . . . . . . . . . . . . . . . . . . . . . .
12.1
12.1
12.1
12.1
12.1
xiii
11.2
11.3
11.3
11.3
12.1
12.2
12.2
12.2
12.2
NES 106
Part 2
Issue 1 (Reformatted)
12.8
12.9
12.2
12.2
13.
13.1
13.2
13.1
13.1
13.1
13.4
13.5
13.6
13.7
13.4
13.5
13.5
13.5
13.5
ANNEX
RELATED DOCUMENTS . . . . . . . . . . . . . . . . . . . .
A.1
ANNEX
B.1
SECTION
13.3
xiv
13.1
13.1
13.2
13.3
13.3
NES 106
Part 2
Issue 1 (Reformatted)
1.
1.1
1.2
1.3
LOBBY/WAITING AREA
a.
b.
Area
a.
b.
When Medical and Dental Waiting Areas are combined an additional benching
is to be provided for four dental patients.
c.
When the hinged benching is occupied the occupants are not to impede the flow
of personnel through the area.
Hinged Benching
a.
b.
c.
Bolts are to be provided to secure the benching in its stowed position against the
bulkhead.
d.
Access
a.
In addition to the normal double door Main Entrance, the Lobby/Waiting Area
is to have direct access onto the Aircraft lift, where one is fitted, by way of a
quick acting watertight (QAWT) door.
b.
The area immediately inside the QAWT door is to be provided with darken ship
precautions enclosing an area of 2500 mm x 2000 mm illuminated by low level
red lighting.
1.4
1.4.1
Crash-on-Deck Alarm
a.
b.
1.1
NES 106
Part 2
Issue 1 (Reformatted)
c.
1.4.2
1.4.3
1.5
b.
An indicator light and low tone buzzer are to be provided and sited above the
Consulting Room/Dental Surgery Door.
c.
b.
An indicator light and low tone buzzer are to be provided and mounted outside
the Ward and Toilet/Wash facility above the doors.
c.
The Attendant Call low tone buzzer is to have a tone distinct from all other
alarms.
Switch Sockets
a.
Two 5A 115V 60Hz single phase and two 5A 240V 60Hz single phase switch
sockets are to be fitted.
b.
The 115V and 240V switch sockets and plugs are to be incompatible.
1.2
NES 106
Part 2
Issue 1 (Reformatted)
2.
2.1
2.2
2.3
2.4
2.5
RECEPTION
a.
b.
The Reception Compartment is to cater for both medical and dental patients.
Location
a.
b.
Layout
a.
A typical layout for a Class A Ship Medical Reception is shown in FIGURE 2.1.
b.
The Medical Reception layout for a Class B Ship is similar to that for a Class A
but reduced in area consistent with a smaller number of occupants and
equipment.
Equipment
a.
The equipment for fitting out the Compartment is given in TABLE 2.1.
b.
b.
c.
Chairs
a.
2.6
OASIS Equipment
a.
2.7
Swivel office chairs at each desk position are to be secured to the deck using a
slide type keep-batten centred at the desk knee hole.
An OASIS Keyboard visual display unit (VDU) and printer are to be provided
and suitably sited adjacent to the hatch.
Switch Sockets
a.
2.1
NES 106
Part 2
Issue 1 (Reformatted)
Item numbers, equipment, ship class and quantities are shown in TABLE 2.1
2.2
NES 106
Part 2
Issue 1 (Reformatted)
ITEM
No
EQUIPMENT
CLASS
QTY
Bookcase
Whereabouts Diagram
Notice Board
Hatch
10
ChairOffice Swivel
11
Key Box
12
Clock
13
14
OASIS Equipment
A/R
A/R
15
16
17
Desk Light
Telephone
Emergency Telephone
Intercom
2.8
b.
c.
Communications
a.
b.
c.
d.
2.3
NES 106
Part 2
Issue 1 (Reformatted)
2.4
NES 106
Part 2
Issue 1 (Reformatted)
3.
CONSULTING ROOM
3.1
Introduction
a.
3.2
Layout
a.
3.3
3.6
3.8
Examining Light
a.
b.
Chair
a.
3.7
3.5
Equipment
a.
3.4
Two Consulting Rooms are to be provided in Class A ships and one in Class B
ships.
The swivel office chair is to be secured to the deck using a slide type keep batten
centred at the desk knee hole.
Switch Sockets
a.
b.
One 5A 240V and two 115V 60Hz single phase switch sockets are to be provided.
Communications
a.
3.1
NES 106
Part 2
Issue 1 (Reformatted)
3.2
NES 106
Part 2
Issue 1 (Reformatted)
ITEM
NO
1
Door
Desk Rack
Desk Light
Bookcase
Examination Couch
CabinetDiagnostic
EQUIPMENT DESCRIPTION
QTY
Splashback
Mirror
Light over Mirror
Soap Dispenser
Toilet Tray
9
10
Waste Bin
11
ChairOffice Swivel
12
ChairPatient
13
ShelvingFull Length
14
CupboardFull Length
15
16
A/R
Telephone
3.3
NES 106
Part 2
Issue 1 (Reformatted)
3.4
NES 106
Part 2
Issue 1 (Reformatted)
4.
SURGERY
4.1
Introduction
a.
4.2
Location
a.
4.3
4.4
4.6
4.7
The Surgery is to form part of the Medical Complex of Class C Ships having
direct access to the Ward and Toilet Facilities and access through the main
entrance to the passageway.
Layout
a.
b.
The Operating Table when in the operating (rigged) position is to have a clear
working space around it of 760mm.
c.
Equipment
a.
4.5
Operating Table
a.
b.
b.
4.1
NES 106
Part 2
Issue 1 (Reformatted)
4.2
NES 106
Part 2
Issue 1 (Reformatted)
ITEM
No
1
DESCRIPTION
QTY
Double Doors
Door NWT
Splash Guard
ChairPatients
10
Desk Pedestal
11
Key Cupboard
12
Bookcase
13
14
ChairSurgeons
15
Desk PedestalFiling
16
Refrigerator 5 cu ft
17
OASIS Equipment
A/R
18
19
Equipment Cupboard
20
21
22
23
24
Operating Table
25
Fire Extinguisher
26
27
Clock
28
29
Notice Board
30
31
32
33
Transfusion Hook
34
Telephone
1
TABLE 4.1 SURGERY EQUIPMENT
4.3
NES 106
Part 2
Issue 1 (Reformatted)
4.8
Surgeons Washbasin
a.
b.
4.9
4.10
4.13
(2)
Splashback.
(3)
(4)
(5)
(6)
Soap dispenser.
(7)
Toilet tray.
(8)
A paper towel dispenser and waste bin or a towel rail are to be provided as
specified on the layout drawing.
A pedal-type waste bin is to be provided for soiled dressings and secured to the
bulkhead.
b.
All work surfaces in the Surgery are to be 1.6mm thick stainless steel with a
25mm deep upstand on the front and sides and 65mm deep on the back.
c.
Surgeons Desk
A surgeons desk is to be provided having the desk top supported on Modular
Furniture items.
Whereabouts Diagram
A Whereabouts Diagram is to be fitted to the surgeons desk top under a clear
acrylic sheet.
Chairs
a.
The surgeons chair provided is to have arms and be capable of being secured
to the deck with a slide keep-batten.
b.
c.
Refrigerator
a.
4.14
Waste trap.
a.
a.
4.12
(1)
a.
4.11
Curtain
a.
A curtain and rail are to be provided across the entrance to the Surgery. The
curtain fabric is to comply with NES 129 and the Master Decor Scheme
NES 184.
4.4
NES 106
Part 2
Issue 1 (Reformatted)
4.15
4.16
Dental Equipment
a.
An air control unit for the compressed air operated dental equipment is to be
provided and bulkhead-mounted adjacent to the operating table when rigged.
b.
Switch Sockets
a.
b.
The following 115V 60Hz, single phase, switch sockets are to be provided:
c.
4.17
(3)
An operating table light is to be provided and sited centrally over the operating
table when in the rigged position. The unit is to be flush with the deckhead
lining.
Communications
a.
4.20
(2)
4.19
One 15A and one 5A, bulkhead-mounted, adjacent to the Operating Table
when rigged.
Lighting
a.
4.18
(1)
Fire Precautions
a.
4.5
NES 106
Part 2
Issue 1 (Reformatted)
4.6
NES 106
Part 2
Issue 1 (Reformatted)
5.
TREATMENT ROOM/DISPENSARY
5.1
Introduction
a.
5.2
5.3
5.4
Location
a.
b.
Layout
a.
b.
Equipment
a.
5.5
5.6
5.8
b.
5.7
Worktops
a.
A stainless steel worktop containing two sinks and having 25mm upstands on
the front and sides with a 65mm upstand on the back is to be provided and to
run continuously over the Treatment Room cupboard.
b.
c.
One sink is to be a scrub-up unit and to be fitted with elbow-operated taps with
the other sink having screw-down taps. Both are to be provided with individual
drainage facilities.
Refrigerator
a.
5.1
NES 106
Part 2
Issue 1 (Reformatted)
5.9
Switchsockets
a.
b.
Two 5A 240V 60Hz and two 5A 115V 60Hz single phase switch sockets are to
be provided and bulkhead mounted over the worktop.
c.
One 15A 115V 60Hz single phase switch socket is to be provided and mounted
adjacent to the refrigerator.
5.2
NES 106
Part 2
Issue 1 (Reformatted)
Item numbers, equipment description and quantities are shown in TABLE 5.1
5.3
NES 106
Part 2
Issue 1 (Reformatted)
ITEM
NO
1
EQUIPMENT DESCRIPTION
QTY
Instrument Trolley
WorktopStainless Steel
Clock
10
11
12
13
14
Splashback (Continuous)
15
Stool
16
Cupboard
17
18
19
20
A/R
5.4
NES 106
Part 2
Issue 1 (Reformatted)
6.
OPERATING THEATRE
a.
6.1
Location
a.
6.2
6.3
a.
b.
Equipment
6.6
Operating Table
a.
b.
6.7
Door
a.
6.5
The Operating Theatre is to be adjacent to the Main Ward and the Sterilizing
Room and is to have direct access through double doors to the Treatment
Room/Dispensary.
Layout
a.
6.4
Fitted Units
a.
All bulkhead and deck mounted fitted units are to be of the Modular Range of
Furniture design, NES 128 refers, and where possible in a continuous run to
make optimum use of available space.
b.
c.
d.
e.
6.1
NES 106
Part 2
Issue 1 (Reformatted)
Item numbers, equipment description and quantities are shown in TABLE 6.1
6.2
NES 106
Part 2
Issue 1 (Reformatted)
ITEM
NO
1
EQUIPMENT DESCRIPTION
QTY
Operating Table
CupboardControlled Drugs
SinkDouble
SinkScrub-Up
Soap Dispenser
10
Chair
11
Anaesthetic Apparatus
12
Dressings Trolleys
13
14
Clock
15
Heater Panel
16
Transfusion Hooks
17
Towel Rail
18
19
Double Doors
20
21
22
6.3
A/R
NES 106
Part 2
Issue 1 (Reformatted)
6.4
NES 106
Part 2
Issue 1 (Reformatted)
f.
6.8
Sink
a.
6.9
6.10
a.
A stainless steel scrub-up sink is to be provided with the top of the sink 800mm
above the deck and space allowance of 300mm on each side of the sink for
elbows.
b.
The sink, with a soap dispenser bulkhead-mounted above and a paper towel
dispenser adjacent, is to be sited close to the Treatment Room/Dispensary door.
Chairs
6.15
Dressings Trolley
a.
6.14
6.13
Swivel chairs provided are to be suitable for working at the 900mm worktop
height and are to have seats and back rests covered with a MOD, approved
impervious wipe-clean material.
Anaesthetic Apparatus
a.
6.12
A double stainless steel sink is to be provided and let into the worktop.
Scrub-up Sink
a.
6.11
The cupboard size may be varied to allow for a continuous run with other
bulkhead mounted fitted units.
b.
b.
6.5
NES 106
Part 2
Issue 1 (Reformatted)
6.16
6.17
Switch Sockets
a.
b.
Four 5A and one 15A 115V 60Hz single phase switch sockets are to be provided
and bulkhead-mounted with easy access to the operating table.
c.
Two 5A 240V 60Hz single phase switch sockets are to be provided and
bulkhead-mounted with easy access to the operating table.
An AEL is to be provided and fitted to indicate the exit route for the occupants.
6.6
NES 106
Part 2
Issue 1 (Reformatted)
7.
DENTAL SURGERY
a.
7.1
7.2
7.3
7.4
Location
a.
The Surgery is to be within the Medical Complex and accessible from the
Lobby/Waiting Area.
b.
Layout
a.
b.
c.
Equipment
a.
b.
The following items of equipment are supplied by MDG(N) and fitted by the
manufacturer:
(1)
Dental Chair.
(2)
(3)
Dental Chair
a.
7.5
The Dental Chair is to be sited such that when the chair is horizontal with the
head rest fully open there is to be a minimum of 750mm clear space all round
the chair.
Dental Unit
a.
The Dental Unit including the aspirator is to be operable from both sides of the
dental chair.
7.1
NES 106
Part 2
Issue 1 (Reformatted)
Item numbers, equipment description and quantities are shown in TABLE 7.1
7.2
NES 106
Part 2
Issue 1 (Reformatted)
ITEM
No
1
EQUIPMENT DESCRIPTION
QTY
Dental Chair
Aspirator
Dental Unit
Dental Light
X-Ray Unit
WashbasinClinical
8A
8B
Soap Dispenser
1A
A/R
A/R
10
SinkSterile/Clean Area
11
Instrument Sterilizer
12
13
14
Surgeons Chair
15
Operating Stool
16
17
18
Clock
19
Towel Rail
20
Telephone
21
Intercom
22
12
23
24
A/R
7.6
The main air and water controls for the Dental Unit are to be centrally located
on the bulkhead above the clinical area worktop.
X-Ray Unit
a.
b.
c.
7.3
NES 106
Part 2
Issue 1 (Reformatted)
7.7
7.8
7.9
7.10
7.12
a.
b.
Worktop heights are to range from 690mm to 870mm above the deck as advised
by MDG(N)
c.
All seams and edges are to be sealed against potential mercury spillage.
d.
a.
b.
Coving 75mm high is to be provided between the worktop and the bulkhead.
Ultrasonic Unit
a.
7.16
Sterilizing Unit
a.
7.15
A stainless steel sink with screw down taps and drainage facilities is to be
provided set into the worktop.
7.14
a.
7.13
a.
7.11
A stowage rail for the X-ray protection apron is to be provided. The rail is to be
77mm dia 1000mm long.
The Clerical area is to be provided with a Surgeons desk comprising a desk top
mounted on a lateral filing unit and a nest of drawers with a bulkhead-mounted
clip-board and bookcases above the desk top.
7.4
NES 106
Part 2
Issue 1 (Reformatted)
7.17
b.
The filing unit, nest of drawers and bookcases are to be to the Modular Range
of Furniture (NES 128) Standard.
c.
Surgeons Chair
a.
7.18
7.19
7.20
7.21
A swivel office chair is to be provided and secured to the deck utilizing a slide
type keep-batten centred at the desk knee hole.
A patient call button and cancellation switch are to be provided and sited at the
Surgeons desk.
Operating Stools
a.
b.
Straps, bulkhead mounted, are to be provided for stowing the operating stools.
Switch Sockets
a.
b.
Twelve 5A 240V 60Hz single phase and two 5A 115V 60Hz single phase switch
sockets are to be provided and sited on the bulkheads over worktops as advised
by MDG(N).
Communications
a.
A telephone linked to the ships main exchange and the reception telephone is
to be provided and bulkhead-mounted at the Surgeons desk.
b.
7.5
NES 106
Part 2
Issue 1 (Reformatted)
7.6
NES 106
Part 2
Issue 1 (Reformatted)
8.
DENTAL LABORATORY
8.1
Introduction
a.
8.2
8.3
8.4
Location
a.
The compartment is to be within the Medical Complex with access to the Lobby
Waiting area and adjacent to the Dental Surgery.
b.
Layout
a.
b.
c.
Fitted Units
a.
8.5
8.6
8.7
Fitted units under the workbench, sink and worktop and lathe bench are to be
to the Modular Range of Furniture (NES 128) Standard in a configuration as
advised by MDG(N) at the Design Stage.
Workbench
a.
b.
The worktop is to be made from fireproofed plywood, faced and edged with
white HPL.
c.
A stainless steel sink fitted with screw-down taps and drainage incorporating
a plaster trap is to be provided.
b.
The sink is to be set into a stainless steel worktop supported on fitted units.
c.
The worktop is to have 50mm upstands along the back and 25mm upstands
along the sides and front, and fitted with a waste shute and recepticle as in
FIGURE 8.2.
d.
Lathe Bench
a.
A stainless steel lathe bench with dimensions as for the worktop incorporating
the sink is to be provided.
b.
The bench top is to be 860/870mm above the deck and supported on fitted units.
8.1
NES 106
Part 2
Issue 1 (Reformatted)
8.2
NES 106
Part 2
Issue 1 (Reformatted)
ITEM
No
1
EQUIPMENT
QTY
Waste Chute
Dental Vibrator
Plaster Trimmer
Lathe
Warning Light
10
11
12
Bench Lighting
13
Switch Sockets
14
Switch Sockets
15
Telephone
16
Intercom
1
TABLE 8.1 DENTAL SURGERY EQUIPMENT
8.3
NES 106
Part 2
Issue 1 (Reformatted)
NOTE:
LID TO SLEEVE
UP AND DOWN THE
CHUTE TO ENABLE
REMOVAL OF BOX
FOR CLEANING
PURPOSES.
CHUTE AND BOX TO
BE OF 1.6mm
ALUMINIUM ALLOY
8.4
NES 106
Part 2
Issue 1 (Reformatted)
8.8
Dental Vibrator
a.
8.9
8.10
b.
8.11
8.14
8.15
A dark room light complete with screen and safe-light filter is to be provided and
bulkhead-mounted above the X-ray film processor.
b.
A switch that simultaneously controls the dark room light and the warning light
is to be provided.
Switch Sockets
a.
b.
Three double outlet 5A 240V 60Hz single phase switch sockets are to be
provided and sited centrally over the workbench, sink worktop and lathe bench.
c.
One double outlet 5A 115V 60Hz single phase switch socket is to be provided and
sited over the workbench.
Lighting
a.
8.16
Warning Light
a.
8.13
Lathe
a.
8.12
Lights centrally positioned over the workbench, sink/worktop and lathe bench
are to be provided.
Communications
a.
b.
8.5
NES 106
Part 2
Issue 1 (Reformatted)
8.6
NES 106
Part 2
Issue 1 (Reformatted)
9.
9.1
Location
a.
9.2
9.4
a.
The equipment for fitting out the compartment is listed in TABLE 9.1.
b.
A 0.142 cubic metre (5 cu ft) top loading deep freeze unit is to be provided. The
unit is to be capable of maintaining a temperature of 20 C to 30 C.
Warning Light
a.
9.11
A 0.142 cubic metre (5 cu ft) pharmacy refrigerator complete with a bulkheadmounted temperature chart recorder is to be provided.
9.10
Refrigerator
a.
9.9
A film developing tank with a bulkhead-mounted spring clip to hold the top in
the open position is to be provided.
9.8
A sink and cupboard unit is to be provided complete with screw-down taps. The
taps are to be 560mm above the bottom of the sink bowl.
Developing Tank
a.
9.7
9.6
Equipment
a.
9.5
The compartment is to be within the Medical Complex with direct access to the
Lobby/Waiting area.
Layout
a.
9.3
A dark room light complete with screen and safe-light filter is to be provided and
bulkhead-mounted above the developing tank.
b.
A switch that simultaneously controls the dark room light and the warning light
is to be provided.
9.1
NES 106
Part 2
Issue 1 (Reformatted)
9.12
Switch Sockets
a.
Three 15A 115V 60Hz and one 15A 240V 60Hz single phase switch sockets are
to be provided, one on the bulkhead above the pathological bench, one adjacent
to the refrigerator and one adjacent to the deep freeze unit.
9.2
NES 106
Part 2
Issue 1 (Reformatted)
Item numbers, equipment description and quantities are shown in TABLE 9.1
9.3
NES 106
Part 2
Issue 1 (Reformatted)
ITEM
No
1
EQUIPMENT DESCRIPTION
QTY
Pathological Unit
Refrigerator Complete5 cu ft
Bookcase
Hinged Table
10
Stool
11
Towel Rail
12
Warning Light
13
14
15
16
CupboardBulkhead Mounted
17
18
WorktopStainless Steel
19
20
Splashback
21
Clock
9.4
NES 106
Part 2
Issue 1 (Reformatted)
10.
WARDS
a.
10.1
Ward Accommodation
a.
10.2
Main Wards are to be provided in Class A, B and C Ships with an Isolation Ward
provided in Class A Ships only.
(2)
(3)
b.
c.
The Ward in Class C Ships may also be used as temporary accommodation for
two personnel on instructions from FOSF.
Location
a.
The Main and Isolation Wards in Class A Ships are to have direct access through
double doors to the Lobby/Waiting area with the Main Ward also having direct
access to the Operating Theatre.
b.
The Ward in Class B Ships is to have direct access through double doors to the
Lobby/Waiting area with good access to the Treatment Room/Dispensary.
c.
The Ward in Class C Ships is to have direct access to the Surgery and to the
passageway through a second door.
10.3
Layout
10.3.1
Main Ward
a.
10.3.2
Layouts of the Main Ward for Class A, B and C Ships are shown in FIGURE 10.1,
FIGURE 10.2 and FIGURE 10.3 respectively.
Isolation Ward
a.
10.1
NES 106
Part 2
Issue 1 (Reformatted)
Item numbers, equipment description and quantities are shown in TABLE 10.1
10.2
NES 106
Part 2
Issue 1 (Reformatted)
Item numbers, equipment description and quantities are shown in TABLE 10.1
10.3
NES 106
Part 2
Issue 1 (Reformatted)
Item numbers, equipment description and quantities are shown in TABLE 10.1
10.4
NES 106
Part 2
Issue 1 (Reformatted)
Item numbers, equipment description and quantities are shown in TABLE 10.1
10.5
NES 106
Part 2
Issue 1 (Reformatted)
10.4
Equipment
a.
10.5
10.6
A two-tier medical berth is to be provided with the lower bunk fixed over
suitable stowage units and the upper berth capable of being folded upwards and
retained.
b.
An amenity panel, attendant call system and reading lights are to be provided
for all berths.
Amenity Panel
a.
b.
10.7
The amenity panel to be provided at each berth is to be fitted with the following:
(1)
(2)
(3)
The lower bunk amenity panel is to be fitted with one 115V 60Hz single phase
switch socket in addition to the above items.
an indicator light;
(2)
(3)
a cancel button.
These are to be connected to a call light and alarm buzzer sited outside the ward.
10.8
Reading Lights
a.
10.9
Siting of Berths
a.
10.10
10.11
All berths are to be provided with a reading light complete with an on/off switch
and incorporating a two-pin shaver socket mounted at the head of each bunk.
Berths are to be sited in a fore and aft position but if, exceptionally, sited
athwartships, the head is to be placed towards the mid-line.
Spacing of Berths
a.
b.
Where berths are sited facing each other a minimum distance of 900mm is to
be provided between them.
Mattresses
a.
A spring interior mattress, complying with NES 165, is to be provided for each
berth.
10.6
NES 106
Part 2
Issue 1 (Reformatted)
10.12
Ladders
a.
10.13
Food Trays
a.
10.14
10.17
Stowage for patients kit is to be provided in lockable units under the lower
berth.
Towel Rail
a.
10.16
One food tray per berth is to be provided. Stowage for the trays is to be provided
either individually or centrally as space allows.
10.15
Each upper berth is to be provided with an access ladder. Stowage for the ladder
when not in use is to be provided adjacent to the berth.
A towel rail fitted outside the headboard of the two-tier bunk unit is to be
provided for each berth.
b.
The curtain rail is to be mounted at a minimum of 460mm out from the bunks.
c.
The curtain fabric is to comply with NES 129 and the Master Decor Scheme,
NES 184.
Surgeons Washbasin
a.
Elbow operated taps for hot and cold fresh water supplies.
(2)
(3)
(4)
Splashback.
(5)
(6)
Soap dispenser.
(7)
Toilet tray.
(8)
(9)
10.18
Wash-up Cabinet
a.
10.19
A wash-up cabinet is to be provided and fitted complete with items (1), (2), (4),
and (6)(10) inclusive as above.
Switch Sockets
a.
10.7
NES 106
Part 2
Issue 1 (Reformatted)
10.20
Communications
a.
b.
The loudspeaker provided for the Ships main broadcast system is to have a
volume control.
10.8
NES 106
Part 2
Issue 1 (Reformatted)
Quantities
Ward Equipment
Item
No
1
Main Ward
Equipment Description
Two-tier Medical Bunk with:
Isol
Ward
Amenity Panels
Attendant Call System
Reading Lights
Mattresses
Food Trays
Towel Rails
Patient Stowage Units (Under)
Ladder
2
Folding Table
Nesting Chair
Hinged Table
CupboardBedding
CupboardGames
Bookcase
CupboardGeneral, Small
10
Notice Board
11
CupboardGeneral, Tall
12
Magazine Rack
13
12
14
12
15
Clock
16
CupboardFood
17
18
19
Shelf
20
CupboardWardrobe
21
22
23
1
1
1
A/R
A/R
A/R
Telephone
10.9
NES 106
Part 2
Issue 1 (Reformatted)
10.10
NES 106
Part 2
Issue 1 (Reformatted)
11.
WARD PANTRY
11.1
Introduction
a.
11.2
Location
a.
11.3
11.8
A double stainless steel sink unit is to be provided complete with hot and cold
fresh water supplied through screw-down taps and drainage facilities.
Worktops
a.
11.7
The equipment for fitting out the compartment is given in TABLE 11.1.
Sink Unit
a.
11.6
Equipment
a.
11.5
The pantry is to be within the Medical Complex with direct access to the Main
Ward.
Layout
a.
11.4
Fitted cupboards and drawer units are to be provided and sited under the sink
unit and worktops.
Shelves
a.
b.
11.1
NES 106
Part 2
Issue 1 (Reformatted)
11.2
NES 106
Part 2
Issue 1 (Reformatted)
ITEM
No
1
EQUIPMENT DESCRIPTION
QTY
Sink Unit
Splash Back
Toaster
Microwave Oven
Tea Urn
10
11
Towel Rail
12
CupboardBulkhead-Mounted
11.9
Tea Urn
a.
11.10
A 1.5kw tea urn is to be provided and secured on the bulkhead over the worktop
adjacent to the sinks.
Electrical Requirements
a.
A 115V 60Hz single phase supply is to be provided for the grill/boiler and toaster.
The units are to be permanently wired.
b.
c.
A 5A 115V 60Hz single phase switch socket is to be provided for each food
container supplied.
d.
A 15A 115V 60Hz single phase switch socket is to be provided for the
refrigerator.
11.3
NES 106
Part 2
Issue 1 (Reformatted)
11.4
NES 106
Part 2
Issue 1 (Reformatted)
12.
STERILIZING ROOM
12.1
Introduction
12.2
a.
b.
c.
The Sterilizing Room is to have access from the Lobby/Waiting area through a
sliding door.
d.
e.
Layout
a.
12.3
Equipment
a.
12.4
The equipment for fitting out the compartment is given in TABLE 12.1.
Deck Drains
a.
Two deck drains are to be provided and sited one in each end of the lowest side
of the deck.
12.1
NES 106
Part 2
Issue 1 (Reformatted)
ITEM
No
1
EQUIPMENT DESCRIPTION
QTY
SinkStainless Steel
WorktopStainless SteelContinuous
A/R
A/R
Instrument Sterilizer
Towel Rail
10
Door
11
12.5
12.6
Fitted Units
a.
b.
c.
12.7
Instrument Sterilizer
a.
12.8
12.9
An emergency water tank, 136 litres (30 gallons) capacity is to be provided and
sited in the deckhead over the sink. A pipe and screw-down tap to the sink are
to be fitted. A tally plate with operating instructions is to be provided.
12.2
NES 106
Part 2
Issue 1 (Reformatted)
13.
13.1
13.2
Toilet and wash facilities in the form of bathrooms, shower-rooms and WCs are
to be provided for Main and Isolation Wards and WCs for the Out-Patients area.
b.
Location
a.
Each Main and Isolation Ward is to be provided with a dedicated facility. There
is to be direct access from the Ward, with the exception of Class C Ships where
access will be from the Surgery.
b.
Facilities
a.
The toilet and wash facilities to be provided in each Class of Ship and the
compartments major constituents are shown in TABLE 13.2.
Facilities
Class
Location
Bath
Bath
room
room
Shower Shower
Room
& BCU
Main Ward
A
Room
n
n
n
n
n
Out-Patients Area
C
& BCU
Out-Patients Area
Main Ward
WC
& BCU
Isolation Ward
WC
Ward
Major Constituents
Bath With Shower Over
Shower Unit
Washbasin
WC
n
n
WC With BCU
n
n
13.3
Layout
a.
Typical layouts of each facility are shown in FIGURE 13.1, FIGURE 13.2 and
FIGURE 13.3.
b.
In Class A and B Ships the Main Ward facilities may be combined into one
compartment provided the Bathroom has a separate entrance to the Ward.
13.1
NES 106
Part 2
Issue 1 (Reformatted)
Item numbers, equipment description and quantities are shown in TABLE 9.1
13.2
NES 106
Part 2
Issue 1 (Reformatted)
13.3
NES 106
Part 2
Issue 1 (Reformatted)
Item
Equipment
No
Description
Br
WCBulkhead
Mounted
Sr
WC
WC
Br
& BCU
Sr
& BCU
out
& BCU
Deodorizer
Towel Rail
Washbasin
1
1*
1*
Corner Washbasin
8
Shower Cubicle
10
Shower)
11
12
Curtain (Bath/Shower)
13
14
Waste Bin
15
Soap Dispenser
16
(BCU)
17
18
19
Warning Light
1B
1B
Br = Bathroom
Sr = Shower Room
BCU = Bedpan Cleaning Unit
Out = Outpatients
B = for Class B only
* = may be normal type of washbasin if space allows
TABLE 13.1 TOILET AND WASH FACILITIES EQUIPMENT
13.4
NES 106
Part 2
Issue 1 (Reformatted)
13.4
13.5
13.6
Equipment
a.
The equipment for fitting out the toilet and wash facilities is given in
TABLE 13.1.
b.
An Attendant Call System comprising an indicator light, pull and call switch
and a cancel button is to be provided and connected to the call light and alarm
buzzer sited outside the Ward or in the Surgery.
b.
The indicator light and cancel button are to be sited outside the compartment
adjacent to the door.
Washbasin
a.
13.7
(2)
(3)
(4)
Splashback.
(5)
Electrical Requirements
a.
b.
c.
The Dark Room Light, complete with a screen and safe light filter, is to be
bulkhead-mounted inside the compartment.
d.
13.5
NES 106
Part 2
Issue 1 (Reformatted)
13.6
NES 106
Part 2
Issue 1 (Reformatted)
ANNEX A.
RELATED DOCUMENTS
A.1
NES 129
NES 165
NES 184*
4.20a.
4.14a.,
10.16c.
10.11a.
13.b.
6.7a.,
7.9a.,
7.11a.,
7.16b.,
8.4a.,
12.5a.
4.14a.,
10.16c.
A.1
ANNEX A
NES 106
Part 2
Issue 1 (Reformatted)
ANNEX A
A.2
NES 106
Part 2
Issue 1 (Reformatted)
ANNEX B.
DEFINITIONS AND ABBREVIATIONS
B.1
Definitions
Utilizable Space
Class ACVS
Class BLPD/LPH
B LPD/LPH
Class CDD/FF/OSV/MCMV
C DD/FF/OSV/MCMV
Class DMinor War Vessels
b.
Abbreviations
AEL
CSA
DNDS
FAP
HPL
QAWT
RFA
MDG(N)
SO3(MED(P&P))
SMP
SR(Sea)
SRE
UDMS
VDU
Vessels
CVS
Carrier
DD
Destroyer
FF
Frigate
LPD
LPH
MCMV
OSV
B.1
ANNEX B
NES 106
Part 2
Issue 1 (Reformatted)
ANNEX B
B.2