Professional Documents
Culture Documents
MKD
Messages:
The LC display automatically shows up every incoming message, regardless of
message type. The alarm messages are always shown first (higher priority). The
messages are displayed in the following format:
:
, .
.
:
Detector
Types of failure:
SC short circuit
OC broken wire
P!
pollution
Types of failure:
SC
OC
P!
:
Al
Flt
/
FTA ( )
Nom
TA
PA -
Info
Z
D
( )
Counters:
There are three three-digit counters in the bottom. These counters are directly assigned
to the buttons below the display and indicate the current number of messages that have
been received up to that point.
000
000
000
000
Alarm
Failure
Test"
Disconnection
By pressing one of these buttons, the operator can call the respective messages onto
the display.
:
.
.
000
000
000
000
Alarm
Failure
Test
Disconnection
LED indications:
LED :
glows when linked up to mains voltage
glows when the panel is in stand-by operation,
flashes when in service / programming
glows as soon as an alarm has been set off,
flashes to indicate a pre-alarm
flashes as soon as a failure occurs
glows continuously when a device is switched off
glows if a zone is in revision mode,
flashes when info messages have been received
Operation
Alarm
Fault
Disconnection
Test
Power Supply
Mains
Battery Charging
Short Circuit
System
Ext. Warning On/Off
Revision On / Off
Mains
(*) .
.
Type of failure
The first message received will get at the end an (*) as a marker. All following messages
can be searched via cursor keys up and right respectively.
Type of failure
Detector
Zone
Types of message:
Al
alarm
Flt
failure
FTA failure technical alarm (zone)
Nom normal
TA
test alarm
PA pre-alarm
Info informative message
Z
zone
D
detector number within the zone
ENG
Type of message
Zone
Type of message
Mains
230V
-,
/
,
-
/
,
Operation
Alarm
Fault
Disconnection
Test
Power Supply
Revision On / Off
Mains
Battery Charging
Short Circuit
System
Ext. Warning On/Off
( 230V),
,
.
Internal buzzer:
In case of fault or alarm the internal buzzer is switched to a continuous tone. By pushing
the buzzer off button the buzzer and the external sounders are switched off. This must
authorised by entering the correct password (1111).
:
/
. buzzer off /
. (1111).
Collective Reset:
By pressing the bottom Reset key the operator can effect a collective reset, i.e. all
messages of the panel are deleted. Modules of the system which were activated are
also reset by means of this function. Currently existing failure messages emitted by
detectors/zones are also reset by pressing this key, and they will, reappear immediately
if the fault still exists. Access must be authorised by entering the correct password
(1111).
:
Reset
.
/ .
/,
. (1111)
.
/ / :
/
.
Switching off:
Detector off ?
Zone off ?
Output off ?
(A)bort
Disable
detector zone .
Zone :
fromDetec. :
to Detec. :
,
. ,
For zones:
Zone:
from: _
to :
(A)bort
For detectors:
Zone :
fromDetec. :
to Detec. :
Detector off ?
Zone off ?
Output off ?
Zone:
from: _
to :
.
.
The switched-off zone / detectors will be shown in the LC display in text format and the
yellow Disconnection LED will glow continuously. It is also possible to switch on and off
a various amount of zones.
Disconnection . /
.
In order to switch them ON press Enable as in first step and all further steps are
carried out in the same way.
/ Enable
.
02.2012