Professional Documents
Culture Documents
Enablement Tutorials
With the US version NEXUS6 XT1103 Chinese users, most of them come for China
Telecom
, but is there such a telecommunications in many indoor shopping centers and car
parks, do 4G LTE band1 2100MHz coverage, but also greater bandwidth than band3
15MHz with 20MHz bandwidth with China Telecom license.
What is a pity, XT1103 band1 RF front-end is shipped out without factory
calibration, so only official usage is 15MHz@band3 only for China Telecom.
In fact, as NEXUS5 band3 enablement, NEXUS6 RF front-end hardware also left a
tiny space to enable it.
The following tutorial is the first edition, With more extensive testing,It will
needs correction on your demands.
I am sorry I do not have English version computer to reworks the Chinese screen
captures,
I believe you have some way to understand around.
5. select "Disk"
6. Click "Browse"
7. Select the folder where you drive, point to open after selecting "momdm",
then OK.
10, in the Device Manager port as shown below to show that the installation was
successful (Note: The port number com93 vary)
: Write qcn
, the mobile client: the phone off, then press the power button + volume
button, enter fastboot mode, use the volume keys to select BP Tools, and then
turn the power button to confirm, so you can open the usb diag device port.
1. the installation QPST.exe (closed before installing anti-virus software).
Do not use lower version 2.7 build 422, otherwise it will not recognize
the device.
http://pan.baidu.com/s/1hq475Ec
or
http://yunpan.cn/cATpyJfUTvhP9
extraction code: de92)
2. open QPST configuration, the first point of Ports tab, select the device
displayed, the first point below "remove", Prompt window popuped, and then point
"Yes".
4. BP Click below shows the port of your device drivers, and then "OK" button.
5, open the folder points QPST Software Download, click on "Restore" check
box, click Browse to select the desired brush into qcn file:
XT1100_LTE_B1_To_XT1103_24226_6735_6736_RxAdded_TxOverrided.QCN
XT1100_LTE_B1_To_
XT1103_24226_6735_6736_RxAdded_TxOverrided.QCN
(Here, the only difference vs nexus5 enabled band3 ,XT1103 purchased from Google
Play, MOTO did not change default SPC, 000000),
Check Allow phone / file ESN mismatch, the final blow: Point Start, Errors box
appears Could not Reset the Phone error normal, qcn has finished writing, after
using the Power button off, then boot directly out LTE signal, the restart, do not
use QuickBoot like Reboot, to ensure safety.
Method 1: Insert telecom cards, confirming a place where band1 see with LTE
Only Cell ID can be found at the end of HEX is 00,010,203 of LTE base stations (in
the dial-up interface, enter * # * # 4636 # * # *, open "mobile phone information
", the" Set preferred network type "to LET ONLY, and then find the" Location: LAC
= 7101 CID = 1924c01 "in this column, the CELL ID is inside this CID.
Here
we
must
thank:
Q39705630 enthusiastic and efficient testing and Draft this tutorial V0.1 version;
Q562552826
provide
XT1103
of
qcn
file,
doing
preliminary
provide XT1100 qcn file, do the final release qcn file parameter reference;
analysis;