Professional Documents
Culture Documents
Introduction
The gas injection is used to supply the natural energy of the reservoirs and keep pressure maintenance.
Present technique consists in injecting gas through wells located structurally up dip of the block reservoir
in order to enhance the total oil recovered from the wells located down dip the block reservoir.
The gas injection projects offshore Peru began in early 1966, originally in order to use the excess of gas
from the gas lift compressors. However, only a small amount of gas was introduced into the reservoir
compared with the production rate.
Since 1974, the gas injection projects in the Pea Negra field were implemented in order to increase the
recovery factor and keep the pressure maintenance. Later, in 1975, response to the gas injection projects
was observed.
The production mechanism is gas drive solution, characterized by a fast increase of the Gas- Oil ratio,
fast decline of the production rate and pressure. The water produced comes from high water saturation
sands, where the oil production response is directly proportional to the net pay and the porosity, being
affected by the clay volume, water saturation and size of the structural block.
Geology
Structural Framework
Several tectonic episodes of normal faulting affected the Talara Basin from the Paleozoic to the Eocene,
where the structural styles have a direct bearing on hydrocarbon systems (Fig. 5).
Based on structural cross sections, the dip meter logs and stratigraphic correlations, and the detailed
structural maps on tops of producer formations were prepared in order to define the framework and
characterization of reservoirs (Fig. 6).
Sedimentary Aspects Basal Salina
This formation is composed of alternations of thick and thin beds of milky- white quartz, and gray to dark
gray quartzite sandstone, medium to coarse grained, grading to conglomerate, poorly sorted, interbedded
with dark steel-gray claystone.
There is not recorded outcropping of this formation. However based on ditch cuttings, electrical logs,
conventional and sidewall cores, the sedimentary environment are marine, forming turbidite sequences
flowing from West to East (Fig. 7).
Mogollon
Present formation is outcropping in Quebrada Mogollon, and consists of medium grained to pebbly
massive milky-white, hyaline and light green quartz sandstones, interbedded with brown- gray shales.
Sedimentary environment corresponds to fluvio-deltaic system flowing from N towards S, with marked
changes from fluvial deposits in the Mancora area, through re-sedimented conglomerate on a submarine
slope in the El Alto- Pea Negra area to a major fan system with progressively finer deposits towards the
South (Fig. 8).
Pea Negra-Rio Bravo
Formed by white-gray, fine to medium grained sandstone, calcareous, with shell fragment, interbedded
with gray claystone and siltstone.
Sedimentary environment corresponds to beach bar sands flowing from NE towards SW, and based on
lithological characteristics and palynological determinations is being considered as the same unit called
Pea Negra in the Pea Negra field and Rio Bravo in the Lobitos field (Fig. 9).
Cabo Blanco
Formed by massive medium to coarse and conglomeratic-grained sandstone, milky, hyaline and white
quartzitic grains interbedded with light gray claystone.
The depositional model indicates a fluvio-deltaic system flowing to the northwest, and it was deposited in
the El Alto-Pea Negra area (Fig. 10).
Parias
Consists of massive medium of coarse-grained sandstone, white, milky-white quartz and dark grains,
interbedded with beds of pebbles and reddish-brown, medium gray claystone. Towards the Lobitos area,
the Parias becomes thinner and fine-grained sandstone.
Sedimentary environment is fluvio-deltaic system flowing from East towards West. However, in the
Lobitos area, it corresponds to a Crevasse splay deposits flowing towards North (Fig. 11).
Conclusions
In spite of the reservoirs complexity in the Talara basin, the gas injection is a good alternative based
in a detailed characterization of reservoir considering multidisciplinary teams.
The 26.5% of the daily production in the offshore fields of Talara basin is a clear response of the gas
injection projects.
The selective gas injection in thicker reservoirs optimizes the oil recovery in different characterized
layers and avoids the continuous loss of pressure.
Bibliography
Carozzi, A. (1975); Depositional Model for the Mogollon, Parias and Cabo Blanco clastic systems of
the Talara Basin, NW Peru.
Belco Petroleum Corporation of Peru.
Carozzi, A. & Palomino, R. (1993); The Talara fore arc basin, NW Peru. Depositional models of oilproducing Cenozoic clastic systems.
Journal of Petroleum Geology, volume 16(1) January 1993.
Chavez, M. (2004); Evaluation of the Lobitos offshore field, Talara basin.
Petro-Tech Peruana S.A, Internal report.
Chavez, M. & Janampa, H. (1994 2001).
Petro-Tech Peruana S.A, Internal reports.
Chavez, M. & Monforte, Y. (2002).
Petro-Tech Peruana S.A, Internal reports.
Chavez, M. & Montes, C. (2002).
Petro-Tech Peruana S.A, Internal reports.
Euribe, A. (1976); Glossary of Stratigraphic Units of NW Peru. Biostratigraphic Report 76-01
Belco Petroleum Corporation of Peru.
Serra, O. (1985); Sedimentary environments from wire line logs.
Schlumberger.
12
13