You are on page 1of 4

Create account Log in

Book Discussion

Read Edit View history

Search

Trumpet/Playing
< Trumpet
This page may need to be reviewed for quality.
Main Page
Help
Browse wiki

Contents [hide]

Cookbook

1 Parts of the instrument

Wikijunior

2 Posture and hand position

Featured books

3 Proper breathing

Recent changes

4 Embouchure formation

Donations

5 Proper tonguing

Random book

6 First sounds on the mouthpiece

Using Wikibooks
Community
Reading room
Community portal
Bulletin Board
Help out!
Policies and
guidelines
Contact us
Tools
What links here
open in browser PRO version

Parts of the instrument

[edit]

Parts of the instrument include, starting at the mouthpiece end of the instrument, the mouthpiece,
leadpipe, main tuning slide, main body of the instrument, and bell. The main body of the instrument
conatins three (sometimes four) valves, each valve connected to a separate and distinct slide.
When no valves are pressed, the air moves through the instrument without entering any of the
valve slides. When a valve is pressed, the air moves through the instrument and through the slides
of the valves which are depressed, thus lengthening the instrument and lowering its fundamental
Are you a developer? Try out the HTML to PDF API

pdfcrowd.com

What links here

pitch.

Related changes
Upload file
Special pages
Permanent link
Page information
Cite this page
Languages
Add links
Sister projects
Wikipedia
Wikiversity
Wiktionary
Wikiquote
Wikisource

Posture and hand position

[edit]

Proper posture can be obtained by either standing or sitting tall with the elbows at a 45 degree
angle with the ground. The angle of the trumpet to the plane of the player's face generally should
be slightly less than 90 degrees. An upward horn angle (i.e. "bells up") can be obtained by altering
posture at the waist or neck, but this should be used only for special effect as it can interfere with
proper breathing. The angle of the trumpet with the plane of the player's face should never be
significantly altered.

Proper breathing

[edit]

A perfect inhalation breath can be accomplished the following way: Exhale fully and count out loud

Wikinews

to twenty without breathing in any additional air. The natural inhalation which occurs upon reaching

Wikivoyage

the number twenty is a natrually good breath, provided the throat stays open and relaxed and the

Commons

shoulders also stay relaxed and do not rise closer to the ears. Proper exhalation, the basis of

Wikidata

proper breath support, occurs when the muscles in the diaphragm and abdominal area push the

Print/export
Create a collection

air out of the lungs. The throat must stay relaxed in order for proper tone production to occur. The
abdominal area should be firm during proper exhalation.

Download as PDF
Printable version

Embouchure formation

[edit]

In proper embouchure formation, the corners of the lips are firm and slightly drawn down. The
center of the lips will be slightly firm, but not nearly as firm as the corners. The teeth are separated
to approximately a pencil's width. The lips are rolled in slightly so that the buzz can occur near
where the moist inside of the lip meets the dry outside of the lip. Both lips must be even; they
open in browser PRO version

Are you a developer? Try out the HTML to PDF API

pdfcrowd.com

should touch but not overlap one another. The chin must remain firm, and air pockets should
never be allowed to form between the teeth and the outer walls of the mouth with which the teeth
make natural contact. The mouthpiece should rest approximately 50% on the upper lip and 50%
on the lower lip. Common causes of a tight tone quality are 1) teeth which are too close together,
and 2) too much tightness in the center part of the lips (where wet meets dry).

Proper tonguing

[edit]

To tongue properly, the upper side of the tongue's tip is placed where the upper front teeth meet
the gumline. A seal must be made between all of the upper teeth and the edge of the tongue so
that no air can escape in the instant before actual tonguing occurs. The tongue should never be
allowed to protrude between the top and bottom front teeth, and the tip of the tongue should never
be so far back that it only touches the gums/membranes of the mouth and not the front teeth.

First sounds on the mouthpiece

[edit]

The mouthpiece should be held with the thumb and first finger of the non-dominant hand. It should
be held on the "dirt line" which may be slightly scratched or worn away from repeated insertions
into the leadpipe. The first sound on the mouthpiece should be air-based. This can be
accomplished by forming the embouchure, placing the mouthpiece on the lips, and blowing air (no
buzz) through the mouthpiece. While continuing to try to blow air, cover up the tip of the
mouthpiece with the dominant hand first finger and let the pressure build up for a second or two.
When the finger is released, the pressure will be released and the air will once again pass through
the mouthpiece, but if everything is properly lined up, the sudden release of pressure will
automatically start a proper air-based buzz.
Category: Trumpet
open in browser PRO version

Are you a developer? Try out the HTML to PDF API

pdfcrowd.com

This page w as last modified on 4 October 2012, at 20:35.


Text is available under the Creative Commons Attribution-ShareAlike License.; additional terms may apply. By using this site, you
agree to the Terms of Use and Privacy Policy.
Privacy policy

open in browser PRO version

About Wikibooks

Disclaimers

Are you a developer? Try out the HTML to PDF API

Developers

Mobile view

pdfcrowd.com

You might also like