You are on page 1of 4

Front Page Format for Project Report

The covering page (color light sky-blue)


(Title of the Project)
A
Project Report
Submitted
In
Partial fulfillment
For the award of the Degree of
Bachelor of Technology
In
Electronics and Communication Engineering

Supervisor:

Submitted By:

Name of Faculty

Name of Candidate

Designation

Enrolment No.: .........

Department of Electronics and Communication Engineering


School of Engineering and Technology
Jaipur National University, Jaipur
Month and Year

Certificate
I here by declare that the project work being presented in the Project report , entitled
< Title, (Bold)>. In partial
fulfillment for the award of Degree of Bachelor of Technology in Electronics and
Communication and submitted to the Department of Electronics and Communication
Engineering , Jaipur National University, Jaipur, Rajasthan is carried under the Guidance
of<Name

of

the

Guide(s),

(Bold)>.,

<Designation>, Department of Electronics and Communication Engineering,


Jaipur National University, Jaipur.

(Name and Signature of Candidate)


Electronics and Communication,
Enrolment No:..
Jaipur National University,
Jaipur.

Counter Signed By
Names(s) of Guide(s)
.
.

(Signature of External Examiner)


Name:

Contents
Certificate
Acknowledgement
List of Contents
List of Figures
List of Tables
Chapter 1: Introduction
1.1 Heading1
1.2 Heading2

i
ii
iii
iv
1

Chapter 2: .
2.1 Heading1
2.1 Heading2
----

Conclusion
Appendix (Data sheet, Program Code etc.)
References

---

Report Writing Guidelines


1) The main contents in the report should be typed in Times New Roman 12 font and
Headings and subheadings should be typed in Font 12, Times New Roman, bold).
2) Page no. should be numbered from Chapter-1 as 1, 2, 3 Spacing between
consecutive lines should be 1.5 Separate successive paragraphs by 9 points.
3) Margins of each page should be preferably 1.25 inch left side, 0.75 inch right hand side,
and 1 inch top and 1.5 inch bottom with page no. at bottom margin of one inch.
4) For each chapter at top right corner chapter no. should be written: for example; for
chapter 1, it should be Chapter - 1 (Font 12, Times New Roman).
5) Title of the chapter should be typed in Font 14 (All Capital) and should be centered.
6) Preferably, the report should be organized as under:
i) Contents (Pg no. should be numbered in Roman as i, ii, iii distinct to that of starting
from Certificate).
ii) Introduction (Chapter - 1, Essential, Detailing Scope of work with Objectives)
iii) Chapter - 2
iv) and SO ON .
v) Chapters describing the Work (Tables should be given the number based on their
(a) chapters; for example; for chapter 2 they should be Table 2.1, 2.2 and so on.
They should be written as per IEEE Syntax as under:
TABLE 1.1
NO. OF LINES, RELAYS, VARIABLES AND CONSTRAINTS
FOR SOME POWER SYSTEMS

(b)Like Tables, Figures should be numbered, and should be titled as under


Fig. 2.2. Diagram showing near-end and far-end faults
vii) Conclusions
viii) References (IEEE Syntax) should be mention as per Examples are given as under:
To refer a book - David E, Goldberg, Genetic Algorithms in Search,
Optimization, and Machine Learning, ISBN 81-7808-130-X, Pearson Education Asia
Pte Ltd., 2000. (621.381952, G47G)
To refer a website- https://en.wikipedia.org/wiki/GSM
ix) Appendix

You might also like