Professional Documents
Culture Documents
Earl Mangulabnan
AB1
February 25, 2015
Experimental
The experiment was carried out mostly using the procedures found in the lab manual4.
During the synthesis of the two compounds, all volumes outlined in the lab manual were
doubled.
temperature was maintained for (x) minutes. The final solution was cooled to (x) degrees using
an ice bath. The product was filtered out using a vacuum filtration apparatus into a sintered glass
crucible weighing (x). This product was washed with two 10 mL portions of 6 M HCl and dried
with 10 mL of acetone. The suction was continued for (x) minutes. The glass crucible was stored
in a desiccator until the following week.
Synthesis of Compound W
(x) grams of [Co(NH3)5Cl]Cl2 were initially weighed out and combined with 90 mL of
5% aqueous ammonia in a 250 mL Erlenmeyer flask (Equation A.4). The mixture was slowly
heated in a water bath with frequent swirling, taking (x) minutes to heat to (x) degrees Celsius.
The solution was left at this temperature for (x) minutes after the solid completely dissolved.
This solution was immediately filtered through a Buchner funnel, and the filtrate collected. The
filtrate was cooled to (x) degrees in an ice bath, then concentrated HCl was added dropwise until
fog no longer formed over the solution, and red precipitate stopped forming (Equation A.5). (x)
mL of HCl was used. The solution was cooled to (x) degrees Celsius. The precipitate was filtered
into a (x) gram sintered glass crucible and washed with 3 portions of 10 mL of 95% ethanol. The
product was placed into a refrigerator and the final mass of both the crucible and the precipitate
was taken.
Determination of Molar Mass of Cobalt(III) Compound
This test used 0.151 grams of the unknown cobalt compound and 0.151 grams of
[Co(NH3)5Cl]Cl2. These were placed in separate, labeled 150 mL Erlenmeyer flasks. Flask 1
contained the unknown cobalt compound while flask 2 contained [Co(NH3)5Cl]Cl2.Two boiling
beads and 10 mL of 3M H2SO4 were added to each flask (Equation). 0.2008 and 0.1995 grams of
oxalic acid were added to flasks 1 and 2, respectively. Each solution was boiled in the fume hood
until foaming occurred. Once the foaming ended, the flasks were cooled on the bench top until
the SO3 fumes cleared. 0.1996 and 0.2023 grams of oxalic acid were then added to flasks 1 and
2. The walls of the flasks were rinsed with DI water. These solutions were boiled once again until
the foaming ended. After the solutions were cooled on the bench top, 50 mL of DI water was
used to rinse the walls of each flask. The flasks were reheated to a boil and swirled to dissolve
any remaining crystals. Each solution was diluted to 100 mL and allowed to cool to room
temperature.
Next, the solution in flask 1 was transferred to a 250 mL volumetric flask and diluted to
the mark with DI water. The solution was mixed and 10 mL was transferred to a 100 mL
volumetric flask. 10 mL of 50% ammonium thiocyanate (NH4SCN) and 50% ethanol was also
added to the 100 mL flask, which was then diluted with water to volume (Equation). After
mixing by inversion, the absorbance of the solution at a 621 nm wavelength was measured using
a Spec 20. A mixture of 2.0 mL of 50% NH4SCN, 8.0 mL of water, and 10.0 mL of 95% ethanol
was used as the blank. This procedure was also used to measure the absorbance of flask 2, using
the same quantities and glassware.
Determination of the Non-Ammonia Ligands
For this test, 0.204 g of [Co(NH3)5Cl]Cl2 and .202 g of compound W was used. These
samples were placed in separate 100 mL volumetric flasks which were filled to volume with DI
water. After mixing, the known and unknown samples were placed into separate curvettes. A
fiber-optic UV-Vis spectrophotometer was used to measure the visible absorbance (360-700 nm
wavelength) of each solution. The spectrophotometer was blanked using DI water.
Determination of the Charge of the Complex Ion by Ion Exchange
This experiment uses an ion exchange column packed with 10-15 cm of Dowex 50W-X8
cation exchange resin. This was rinsed with three portions of 25 mL DI water. The column was
inspected to ensure its quality.
0.3022 g of compound W was placed into a 250 mL with 100 mL of DI water. This
solution was run through the ion exchange column at approximately 10 mL per minute and
collected in a 250 mL Erlenmeyer flask. After the solution was run through, the column was
rinsed with 3 25 mL portions of DI water, which was collected in the same flask. This was
titrated using our prepared NaOH solution, and the volume of NaOH used was recorded.
Determination of the Number of Ammonia Ligands
The distillation apparatus was first assembled with 50.0 mL of the HCl solution. A
solution of .184 g of compound W was dissolved in 100 mL of DI water in the flask that was to
be heated. Two boiling chips and 10 mL of 19 M NaOH were added to this flask and the stopper
was replaced. We swirled the flask to mix the solution and slowly heated it up to a boil. The ice
on top of the receiving flask was continuously replaced as it melted during the heating process.
After 23 minutes and 16 seconds of boiling, the HCl solution was removed and the glass tube
washed into the solution. This was brought to room temperature, and titrated with the .1 M
NaOH solution using bromcresol green as the indicator. The volume of NaOH added was
recorded.
Appendix A
Synthesis of [Co(NH3)5Cl]Cl2
A.1
Co ( N H 3 6 ] C l 2+ 6 H 2 O(l )
H 2 O 6 ( aq) +6 N H 3 ( aq) +2 N H 4 C l ( s )
Co
A.2
++2 O H (aq)
Co C l 2( aq )
Co ( N H 3 5 ] C l 2( aq) + H 2 O 2 ( s) 2
2
A.3
+
Co ( N H 3 5 Cl ] C l 2 (s )+H (aq)
2++HC l (aq )
N H 3 5 Cl (aq )
Co
Appendix A
Compound M synthesis
+
++ N H 3 (aq )+2 H (aq )
[ Co ( N H 3 )5 Cl ]( aq)
+
Co ( N H 3 5 N O2 ] C l 2 (s )+2 H (aq )
2++ Heat +2 HC l (aq)
A5
N H 3 5 ONO (aq )
Co
+
++2 H (aq )
N H 3 5 Cl (aq )
Co
A6 2++C 2 H 2 O 2 C O +
4 ( s)
2 (g )
N H 3 5 Cl (aq )
Co
N H 3 5 Cl (aq)
Co
+
+ +2 H (aq)
N H 3 5 N O2 ( aq)
Co
A9 2++C 2 H 2 O C O +
4 ( s)
2 ( aq )
N H 3 5 N O2 ( aq)
Co
+ +6 H 2 O(l )
2+ 4 N H 4 (aq )
SCN 4 (aq )
Co
A11 2++ 4 N H SC N
4
( aq )
H 2 O 6 (aq )
Co
A7
+
2+ N H 4 (aq)
SCN 4 ( aq)
Co
A8 2++ N H 4 SC N
( aq )
H 2 O 6 (aq )
Co
N H 3 5 N O2 (aq)
Co
2++2 C l (aq )
N H 3 5 Cl ( aq)
A12
Co
Co ( N H 3 5 Cl ] C l 2 (s )
2++2 C l (aq )
N H 3 5 N O2 ( aq)
A13
Co
Co ( N H 3 5 N O2 ] C l 2 (s )
S O3
2++2 HC l ( aq)
N H 3 5 Cl (a q )
Co
2++2 C l ( aq)
N H 3 5 Cl ( aq)
Co
( S O 3 H )2 +
A15
S O3
2++2 HC l (aq)
N H 3 5 N O2 (aq)
Co
2++2 C l ( aq)
N H 3 5 N O2 ( aq)
Co
( S O 3 H )2 +
A16
+
2+ + H 2 O( l) + N a(aq)
N H 3 4 N H 2 N O 2 (aq )
Co
2++ NaO H ( aq)
N H 3 5 N O2 ( aq)
Co
+
+10 N H 3 ( g )+ H (aq)
C o 2 O3 (aq )+ 2 N O2 (aq )
2++ 3O H (aq )
A17
N H 3 4 N H 2 N O2 ( aq)
Co
2
A18
++C l (aq)
N H 3(g) + HC l (aq ) N H 4(aq)
+
+ N a(aq)
NaO H (aq )+ HC l (aq ) 2 H 2 O(l) +C l (aq)
References
1
(4)