Professional Documents
Culture Documents
PANIPAT REFINERY
Ref: PR/IP/201
Date: 22-03-2013
Site requirements
1. Thorough cleaning of tubes to remove all hard deposits/ scales, oil and rust is
must.
2. Electrical connection is required.
3. Scaffolding inside boiler is needed.
Advantages
1. Entire length of tubes can be scanned in short span of time.
2. Compared to ultrasonic thickness gauging which is spot measurement technique,
EMAT can cover section of tube (area under the probe) along its entire length.
3. No couplant between probe and tube is required.
Limitations
1. Air gap between tube and probe due to improper cleaning can cause loss of
signal/ erratic signal. Hard deposits on the tube can also damage the EMAT
probe.
2. Requirement of thorough cleaning (close to SA 2.5): Generally, water wall
tubes are covered with thick hard deposits as seen in photograph above,
whereas EMAT inspection requires thorough cleaning close to SA 2.5 level as
shown in photographs above. Areas that cannot be cleaned by grit blasting (such
as bank tubes facing furnace rear wall tubes) owing to space constraint cannot
be inspected.
3. Only thickness scanning of fire side of the tubes (i.e., side from which tubes are
accessible) can be done. The probe will not give any indication regarding unfired
side of the tubes.
Remarks
1. Overall the technique was found suitable for thickness scanning of boiler tubes.
2. Approx 1500 m length of tubes was inspected in 4 days after surface cleaning.
3. Low thickness was detected with EMAT technique in one tube and thinned
portion (0.75m length) of the tube was replaced. It would have been difficult to
detect localized thickness loss with conventional UT gauging.