Professional Documents
Culture Documents
constructive solutions
Standard compliance
ASTM C-157-93
DIN 1048 Part 5
BS 1881 part 121
Test method
Drying shrinkage
ASTM C157-93
7 days:
28 days:
Permeability:
(DIN 1048 Part 5)
Flexural strength:
(BS 6319 Part 3)
Tensile strength:
(BS 6319 Part 7)
Compressive strength:
(BS 1881 Part 1161)
ii.
Properties
Advantages
:
:
:
Water absorption:
(BS 1881 Part 121)
Typical results
Description
Renderoc SPXtra is supplied as a ready to use blend of
dry powders, which requires only the addition of clean
water to produce a highly consistent, hand and spray
grade, repair mortar suitable for most structural and load
bearing repairs.
:
:
:
:
10 mm
up to 150 mm thick
up to 200 mm thick
See Note
Page 1
Renderoc SP Xtra
(ii)
Precautions
(iii)
(iv)
During use, avoid inhalation of the dust and contact with the
skin or eyes. Wear suitable protective clothing eye
protection, gloves and respiratory equipment (particularly in
confined spaces).
Fire
Estimating
Supply
Renderoc SPXtra:
20 kg bags
Yield
Renderoc SPXtra:
(at water addition of 3.6 ltr/bag)
Approximately
10.8
litres per 20 kg bag
Limitations
Important note:
Fosroc products are guaranteed against defective materials and manufacture and are sold subject to its standard Conditions
for the Supply of Goods and Services, copies of which may be obtained on request. Whilst Fosroc endeavours to ensure that
any advice, recommendation, specification of information it may give is accurate and correct, it cannot, because it has no direct
or continuous control over where or how its products are applied, accept any liability either directly or indirectly arising from the
use of its products, whether or not in accordance with any advice, specification, recommendation of information given by it.
www.fosroc.com
email: fosam@fosroc.com
Regional Offices
Jeddah Sales Office
Jeddah Showroom
Riyadh
Dammam
Khamis Mushayt
Registered Office: Industrial Area, Phase 4, Road No. 414, Street No. 407
Page 2
FO SA/SPXtra/05/B