3.6. Special Tools. 4. Inspection, Testing, and Preparation for Shipment. 4.1. General. 4.2. Inspection. 4.3. Testing. 4.4. Preparation for Shipment. 5. Vendor's Data. 5.1. General. 5.2. Proposals. 5.3. Contract Data. Appendix A. General-Purpose Gear Data Sheets. Appendix B. Lateral Critical Speed Map and Mode Shapes for a Typical Rotor. Appendix C. T'?ical Lube-Oil Systems. Appendix D. Material Specifications for General-purpose Gear Units. Appendix E. Vendor Drawing and Data Requitements. Appendix F. Referenced Specifications. Appendix G. Spiral Bevel Gear-Tooth Contact Arrangement Requirements for Inspection. Appendix H. Residual Unbalance Worksheets. 2.4.9 ANSI/API Standard 682 and ISO Standard 21O49:,2OO4 (ldentical). Pumps-Shaft Sealing Systems for Centrifugal and Rotary Pumps Scope This international standard specifies requirements and gives recom. mendations for sealing systems for centrifugal and rotary pumps used in the petroleum, natural gas, and chemical industries. It is applicablc mainly for hazardous, flammable, and toxic services, where a greatel degree of reliability is required for the improvement of equrpmenr availability and the reduction of both emissions to the atmosphcrc arxl lifc-cycle scaling costs. It covers seals for pump shaft diametcrs lrorn 20 nrnr (0.7,5) to I l0 nrnr (4.i3). This international standard also is applicable to seal spare parts nd can be referred to for the upgrading of existing equipment. A classification system for the seal configurations covered by this internntional standard into categodes, types, anangements, and orientallons is provided 2.4.10 API Standard 685 Sealless Centrifugal Pumps for Petroleum, Heavy Duty Chemical, and Gas Industry Services Scope ll)is standard covers the minimum requirements for sealless centdfrrgal pumps for use in petroleum, heavy duty chemical, and gas lndustry services. Refer to Appendix U for application information. Single-stage pumps of two classifications, magnetic drive pumps irrrcl canned motor pumps, are covered by this standard. Sections 2 tlrlough 8 and 10 cover requirements applicable to both classificatlons. Section 9 is divided into two subsections and covers require||ronts unique to each classification. For process services not exceeding any of the following limits, ptrchasers may wish to consider pumps that do not comply with API Slandard 685: Maximum discharge pressure,1900 kPa (275 psig). Maximum suction pressure, 500 kPa (25 psig). Maximum pumping temperature, 150"C (300"F). Maximum rotation speed, 3600 rpm. Maximum rated total head, 120 m (400 ft).
Maximum impeller diameter, 300 mm (13).
l,rble of Contents l. Scope. 2. ReferencedPublications. :,|. Definition of Terms. .1. General. 4.1. Unit Responsibility. 4.2. Nomenclature. 5. llequirements. 5.1. Units of Measure. .5.2. Statutorv llco r.rifcments.