Professional Documents
Culture Documents
Characteristics
Stabilization
Surfactants
Specification
These technical data are determined for each lot before its release by our Quality Control Laboratory.
Unit
Solids content
(DIN 53 189 / ISO 1625)
Viscosity
(ISO 2555; 23 C) Brookfield viscometer RVT;
spindle no. 2; 20 min-1
pH value
(ISO 976)
Value
55
mPas
500
300
8.5
0.5
Additional Data
These data are used solely to describe the product. They are not subject to constant monitoring or part of the
specification.
Unit
Value
Dispersion
Particle size
approx. 0.25
approx. 0
Film *
Appearance
Glass transition temperature Tg
(DIN 53 765) (DSC, heating rate 10 K/min)
approx. 15
* dried under standard atmospheric conditions at 23 C and 50 % relative humidity (DIN EN 23 270)
Applications
Mowilith LDM 7900 is especially designed as a binder for flexible and crack-bridging wall coating systems.
Mowilith LDM 7900 allows the formulation of impermeable coatings.
Mowilith LDM 7900 is also suitable for the formulation of roof coatings with elastomeric properties.
The polymer film of Mowilith LDM 7900 exhibit low water uptake and high resistance to saponification.
Mowilith LDM 7900 shows a high elongation at break at temperatures down to -10C. Mowilith LDM 7900
has both an internal and UV curing crosslinking system. Therefore tack and dirty pick-up are very low after
exposure to sunlight.
Processing
The usual titanium dioxide rutile type and coloured pigments as well as fillers may be used for the
formulation of paints. To ensure adequate storage stability long term storage trials are recommended at
any rate, especially when fillers and coloured pigments with a large specific surface area are chosen. In
addition to the widespread used polyphosphates the salts of low molecular weight polyacrylic acids (e. g.
Mowiplus XW 330, Emucryl D) working as a dispersing agent should also be used to achieve further
stability. Depending on the pigments and extenders the required quantity is in the range of 0.1 and 0.4 %
active substance relative to the pigment/extender mixture.
Many thickeners are usable to adjust the desired viscosity of the paint and to improve its processability.
Very good results are achieved by employing Tylose grades of the H and MH series with retarded
swelling and medium to high molecular weight. Associative PU or acrylic thickeners (Mowilith LDM 7002,
Mowilith LDM 7020 can be used as well alone or in combination.
A lot of commercially available defoamers can be included in order to prevent excessive foaming in the
paints. Trials must be carried out to determine the most suitable grades and the correct concentration.
The Colanyl pigment preparations are usable for tinting paints. Organic pigments should be tested for
their suitability for exterior paints, especially in the case of pastel tones.
Clariant VenezuelaS.A.
This information is based on our present state of knowledge and is intended to provide general notes on our
products and their uses. It should not therefore be construed as guaranteeing specific properties of the products
described or their suitability for a particular application. Any existing industrial property rights must be observed. The
quality of our products is guaranteed under our General Conditions of Sale.