Professional Documents
Culture Documents
JVC
ENGLISH
\
ESPANOL
FRAN<;AIS
INSTRUCTION MANUAL
RECEPTOR CON CD
MANUAL DE INSTRUCCIONES
R~CEPTEUR CD
MANUEL D'INSTRUCTIONS
JVCKENWOOD Corporation
Made for
~ iPod
DiPhone.
Works With
.PANDORA
IHeart
RADIO
For customerlJse:
Enter below the Model No. and Serial No. which are
located on the top or bottom of the cabinet. Retain this
information for .future reference.
Model No.
Serial No.
GET0941-00 1A [J]
BEFORE USE
CONTENTS
2
BASICS
A Caution
GETTING STARTED
CD I USB I iPod
RADIO
AUX
Volume setting:
Adjust the volume so that you can hear sounds outside the car to prevent accidents.
Lower the volume before playing digital sources to avoid damaging the speakers by the sudden increase of
the output level.
General:
Avoid using the USB device or iPodliPhone if it might hinder safe driving.
Make sure all important data has been backed up. We shall bear no responsibility for any loss of recorded
data.
Never put or leave any metallic objects (such as coins or metal tools) inside the unit, to prevent a short
circuit.
If a disc error occurs due to condensation on the laser lens, eject the disc and wait for the moisture to
evaporate.
Remote control (RM-RK52):
Do not leave the remote control in hot places such as on the dashboard.
The Lithium battery is in danger of explosion if replaced incorrectly. Replace it only with the same or
equivalent type.
The battery pack or batteries shall not be exposed to excessive heat such as sunshine, fire or the like.
Keep the battery out of r~ach of children and in its original packaging when not in used. Dispose of used
batteries promptly. If swallowed, contact a physician immediately.
10
AUDIO SETTINGS
11
DISPLAY SETTINGS
12
MORE INFORMATION
14
TROUBLESHOOTING
15
SPECIFICATIONS
17
INSTALLATION I
CONNECTION
18
KD-R450.
. [XX] indicates the selected items.
A Warning
BEFORE USE
Do not operate any function that takes your attention away from safe driving.
Maintenance
Cleaning the unit: Wipe off dirt on the faceplate with a dry silicone or soft cloth.
Cleaning the connector: Detach the faceplate and clean the connector
gently with a cotton swab, being careful not to damage the connector.
Handling discs:
Do not touch the recording surface of the disc.
Do not stick tape etc. on the disc, dr use a disc with tape stuck on it.
Do not use any accessories for the disc.
Clean from the center of the disc and move outward.
Clean the disc with a dry silicone or soft cloth. Do not use any solvents.
When removing discs from this unit, pull them out horizontally.
Remove burrs from the center hole and disc edge before inserting a disc.
BASICS
Faceplate
KD-AR7SS
KD-R7SO r;;ll;;y
KD-R6SO
Volume knob
(turn/press)
I[B!fB"
KD-AR7SS
Attach
Display window
-~
'"
f)
Remote sensor
(Do not expose to bright sunlight.)
X:c:.>
~~~:~~~5 ~~----~~--~-~
IB:~, :JI
..... ._"'
'
Detach
' ,
v~ ~
oo.:..r -",.,...
How to reset
Detach
button
,...,.
KD-R6SO
.....
-- ---~---- --
........
IPodMOOE
\!:;::-~~::
....
,::.:.j:,;: h::fb
::<:
1
c:.J
Press <!>/SOURCE.
Press and hold to turn off the power .
----~
c:.J
111
l%!J~i;t,:IJII"!!I;i~
tW~
'ltifit:#!!:rl~'\fJiit~1iir~l;""'~\lm
....
KD-ARSSS
::<:
....
~------- - -~----~--------
..
--------~----~~ -
...-
( not available )
---------- ..
-~ -" - -------~ -
.................................................................................. . ....................
--......... _______
~---~-----
-----~----
Select a source
~
4\)
.
8
..... .._... _,____ _
(not available)
ENGLISH
GETTING STARTED
Default: XX
CLOCKADJ
AUTO: The clock time is automatically set using the Clock Time (CT) data in
1
2
3
4
1
2
3
press~
PTY.
CLOCK DISP
ON: The clock time is shown on the display even when the unit is turned
off. ; OFF: Cancels.
BEEP
SRCSELEa
AM*
PANDORA*
IHEART*
AUX*
when the KS-BTA 100 Bluetooth adapter is connected to the auxiliary input
jack (+ 8). The source name will change to BT AUDIO.
F/W UPDATE
SYSTEM
F/Wxxxx
activated).
For details on how to update the firmware, see:
<http:llwww.jvc.netlcslcarl>.
CD I USB l iPod
The source changes.automatically and
playback starts.
CD
~ Eject disc
label side
KD-AR755 I KD-R750
KD-R650
iPod MOOE
, : .;.,.;.:ot>
USB
USB input terminal
= -l_ ._~.
~~!mo
. l
,
Lsa.xl
_.
. . . .
..
.
. .._
.
_
r
(commercially available)
l;tt~t
iPod/iPhone
(for KD-AR755 I KD-R750 I KD-R650)
.
Select a folder *2
Reverse/
Fast-forward
Repeat play *3
Random play *3
~~~.~
, J!J .. ,..XL
RM~RK52).
Press~~~
~- .... !~
~Hf!oo~-----
{or press~/.... on
Select a track!
file
*1 Do not leave the cable inside the car when not using.
*2
*3
Only for MP3/WMA/WAV files. This does not work for iPod.
For iPod: Applicable under [HEAD MODE] only.
ENGLISH
CD I USB I iPod
For iPod: Applicable only when [HEAD MODE] is selected. (+ 5)
1 Press MENU
2 Turn the volume knob to make a selection, then press the knob.
MP3/WMA/WAV file: Select the desired folder, then a file~
iPod or JPC I JMC file: Select the desired file from the list (PLA YLISTS,
ARTISTS, ALBUMS, SONGS, PODCASTS*, GENRES, COMPOSERS*,
AUDIOBOOKS*).
* Only for iPod.
If you have many files ....
You can search through them quickly (on step 2 above) by turning the
volume knob quickly.
Not applicable for iPod.
RADIO
PTY code: NEWS, INFORM (information), SPORTS, TAL~ ROCK, CLS ROCK (classic rock),
ADLT HIT (adult hits), SOFT RCK (softrock), TOP 40, COUNTRY, OLDIES, SOFT, NOSTALGA
(nostalgia), JAZZ, CLASSICL (classical), R&B(rhythm and blues), SOFT R&B (soft rhythm
and blues), LANGUAGE, REL MUSC (religious music), REL TALK (religious talk), PERSNLTY
(personality), PUBLIC, COLLEGE, HABL ESP (Spanish talk), MUSC ESP (Spanish musk),
HIP HOP, WEATHER
ENGLISH
AUX
RADIO
----------------------------------------------~
Default: XX
RADIO
TIMER
SSM
IF BAND
. .
(commercially available)
2
3
Q
, ~output.
:1._
' I
interference noises from adjacent FM stations, but sound quality will not be
degraded and the stereo effect will remain.
-- - -~ -------------~- - ~- --~----- ------~--~----------
MONO
AREA
------------------------,
gsJt
\..,..~-,;~:, ....,-. ,
I
I
I
I
Pandora
Preparation:
Install the latest version of the Pandora application onto your device
(iPhone/ iPod touch), then create an account and log in to Pandora.
Select [ON] for [PANDORA] in..[SRC SELEa]. (+ 4)
. 1 Press MENU.
2 Turn the volume knob to select [NEW STATION], then press the knob.
3 Turn the volume knob to select [FROM TRACK] or [FROM ARTIST], then
press the knob.
A new station is created based on the current song or artist.
Iii:.
~'~I
(__
. -= (~~;;s;:fthe iPod/iPhone)* /1
[101[
8
@
Pause or resume..
playback
Thumbs up or
thumbs down
Skip a track
1 Press MENU.
2 Turn the volume knob to make a selection, then press the knob.
[BY DATE]: According to the registered date.
[A-Z]: Alphabetical order.
3 Turn the volume knob to the desired station, then press the knob.
ENGLISH
0[),__--........
(Accessory of the iPod/iPhone)*
/( ~0
__ ,.,
-------------- . -----------------------
... --
* Do not leave the cable inside the car when not using.
3
--~ -----
--------~ --~-~
~--~-
~---
1 Press MENU.
2 Turn the volume knob to select a category, then press the knob.
3 Turn the volume knob to the desired station, then press the knob.
When a city list appears, you can skip cities in alphabetical order.
4 Press MENU to exit.
10
AUDIO SETTINGS
Default: XX
Select a preset
equalizer
Default:OO
1
2
* Displayed only when [UO MODE] is set to [SUB.W] and [SUB.W] is set to
[ON]. (12)
EQPRESET
equalizer.
EASYEQ
Default:OO
PROEQ
BASS BOOST*2
+011 +02: Selects your preferred bass boost level.; OFF: Cancels.
LOUD
SUB.W LEVEL *3
SUB.W*4
ENGLISH
11
AUDIO SETTINGS
HPF*6
OFF: All signals are sent to the front/rear speakers. ; LOW 1OOHz I
MID 120Hz I HIGH 150Hz: Audio signals with frequencies lower
than 100 Hz/ 120 Hz/ 150 Hz are cut off from the fr.ont/rear speakers.
FADER*2* 7
R06- F06 (00): Adjusts the front and rear speaker outp~~ bal~nc~
KO-ARSSS
BALANCE*2*7 L06- R06 (00): Adjusts the left and right speaker output balance.
-
VOL ADJUST
KO-R6SO I KO-R450
AMP GAIN
D.T.EXP
(Digital Track
Expander)
-----
TEL MUTING*S
ON: Mutes the sounds while using the cellular phone (not connected
through KS-BTA 100).; OFF: Cancels.
--~~---~---~----- ----~
L/0 MODE*S
1
2
*1 Displayed only when (L/0 MODE] is set to [SUB.W] and [SUB.W] is set
to [ON].
*2 This adjustmen t will not affect the. subwoofer output.
*3 Displayed only when [SUB. W] is set to [ON].
*4 Displayed only when [L/0 MODE] is set to [SUB.W).
*S Not applicable for KD-AR755.
*6 KD-AR755 only.
.
*7 If you are using a two-speaker system, set the fader level to [00].
*8 Does not work if [BT ADAPTER] is selected for [AUX] in [SRC SELECT].
DIMMER
BRiG.HTNiss
Selects the display and button illumination adjusted in the [BRIGHTNESS] setting.
AUTO: Changes between the day and night adjustments when you turn off or on
the car headlights. *1 ; ON: Selects the night adjustments.; OFF: Selects the day
adjustments.
---- ---------------- - --------S~t~- th-~ - b~tt~~-: -display and USB input terminal brightness for day and night
separately.
1 DAY I NIGHT: Select day or night.
2 Select a zone for setting. (+Illustration above)
3 Set the brightness level (00 to 31 ). (Default: DAY: 31 ; NIGHT: 15.)
--
*1
12
DISPLAY SETTINGS
Default: XX
Default XX
PRESET
You can select acolor for [ALL ZONE], [ZONE 1], [DISP ZONE], or
[ZONE 2] separately. For [ALL ZONE], you can also select a color pattern.
Default color:
ALL ZONE: [COLOR 06], ZONE 1: [COLOR 06],
DISP ZONE: [COLOR 01], ZONE 2: [COLOR 27]
1 Select a zone for setting. (+ 12)
2 Select acolor for the selected zone.
COLOR 01 to COLOR 29
USER: The color you have created for [DAY COLOR] or
[NIGHT COLOR] is shown.
COLOR FLOW 01 to COLOR FLOW 03: Color changes at different
speeds.
SPEURUM/ GROOVE/ TECHNO/ EMOTION/ RELAX/
NIGHT SWEEP: The selected color pattern is shown.* (Selectable
PRESET
DAY COLOR
NIGHT COLOR
MENU COLOR
ON: Changes the button illumination to white color when settings are
performed on menu and list search.; OFF:'Cancels.
* If one of these color pattern is selected, the [ZONE 1], [DISP ZONE],
[ZONE 2] illumination color will change to the default color.
-n-- "-''''"''" ' ' ' ' ' ' ' - - - - - - -
DAY COLOR
NIGHT COLOR
- -'-
- -
'''
- -
Store your own day and night colors for different zone.
1 Select a zone for setting. (+ 12)
2 RED I GREEN I BLUE: Select a primary color.
3 00 to 31: Select the level.
Repeat steps 2 and 3 for all the primary colors.
Your setting is stored to [USER] in [COLOR].
If [00] is selected for all primary colors for [DISP ZONE], nothing
appears on the display.
COLOR GUIDE
ON: Changes the button, display and USB input terminal illumination
when settings are performed on menu and list search. Display zone will
automatically change depending on volume level.; OFF: Cancels.
-. -- ....
-.-. --
. _______
._
'
------
--------- ...-
ENGLISH
13
MORE INFORMATION
About discs and audio files
This unit can only play the following COs:
DIGITAL AUDIO
DIGITAL AUDIO
l:iljke!M1~
DIG TAL
ReWritable
14
MORE INFORMATION
"
TROUBLESHOOTING
FM or AM
Playing time Day /Clock Album title/ Artist Track title (back to the
beginning)
Station name Album title/Artist Track title Playing time Day/Clock
(back to the beginning)
IHEART
;- ........ .
Soundcannotbeheard.
"MISWIRING CHK WIRING
THEN RESET UNIT" I
JJWARNING CHK WIRING THEN
RESET UNIT" appears and no
operations can be done.
AUX +-+Day/Clock
BT AUDIO
BT AUDIO+-+ Day/Clock
- -
.. ----
ENGLISH
15
TROUBLESHOOTING
Station cannot be
selected.
"CREATE ERR"
"SAVE ERROR"
"OISCONNITD"
"NO SKIPS"
"NO STAllONS"
"NOT CONNCTD"
1/UPDATE APP"
Make sure you have installed the latest version of the tHeart link .
."PLS LOGIN"
liSTATION NOT
AVAILABLE"
"STATION NOT
SELEITED"
No station is selected.
Communication is unstable.
"STREAM ERR"
"THUMBS ERR"
'11MEDOUT"
---
~~READING" keeps flashing. Do not use too many hierarchical levels and folders.
Reload the disc or reattach the USB device.
ADD ERROR"
I 1/SEARCH ERR"
II
['_CH_K~D_E_VI_C_E_"__-,====C=h=ec=k-!~;-p~--~~-~r-a_-ap_pli~~t~~~~~_i.~rd-e_v-ic~~-__._-_-_-. .=----
"NO SKIPS"
~
Ii 11 NO STATIONS"
!
~~
I "CONNEa ERR"
!"RATING ERR"
.
'! "LICENSE ERR"
.
!.
t::
GJ
I I/UPGRADE APP"
0:::
~ I liSTATION LIM"
O !
"C i
:c
- - - --
16
SPECIFICATIONS
Frequency Range
USB Standard
Compatible Devices .
50 kHz/200 kHz
File System
FAT12/16/32
DC5V===1 A.
MP3 Decode
WMA Decode
WAV Decode
Linear-PCM
20 Hz-20kHz
1200mV
Input Impedance
30k0
-----,---
------- ----
Usable Sensitivity
(SIN= 26 dB)
~V/75
0)
Quieting Sensitivity
(DIN SIN = 46 dB)
30Hz to 15kHz
64dB
40dB
AM Frequency Range
9kHz/10kHz
50Wx4'
Usable Sensitivity
(S/N =20 dB)
22Wx4
laser Diode
GaAIAs
Speaker Impedance
40-80
KD-AR75S:
4 800 mV/10 kO load
KD-R7SO I KD~R6SO I KD-ARSSS I KD-R4SO:
2500 mV/10 kO load
Preout Impedance
~6000
Spindle Speed
20Hz-20kHz
0.01%
105 dB
Operating Voltage
(10.5 V-. 16 Vallowable)
14.4V
90dB
10A
Channel Separation
85 dB
MP3 Decode
Installation Site {W x Hx D)
WMADecode
182 mm x 53 mm x 158 mm
{7-3/16" X 2-1/8" X 6-1/4")
Weight
ENGLISH
17
0.....
1-
...........
-c
0
1-
....
....
c
1-
"'z
A Warning
The unit can only be used with a 12 VDC power supply, negative ground.
Disconnect the battery's negative terminal before wiring and mounting .
Do not connect Battery wire. (yellow) and Ignition wire (red) to the car
chassis or Ground wire (black) to prevent ashort circuit..
Insulate unconnected wires with vinyl tape to prevent ashort circuit.
Be sure to ground this unit to the car's chassis again after installation.
.1
Do the required wiring.
(+19)
A Caution
For s~fety's sake, leave wiring and mounting to professionals. Consult the
car audio dealer.
Install this unit in the console of your vehicle. Do not touch the metal
parts of this unit during and shortly after use of the unit. Metal parts such
as the heat sink and enclosure become hot.
Do not connect the 8 wires of speakers to the car chassis or Ground wire
(black), or connect them in parallel.
Connect speakers with amaximum power of more than 50 W. If the
maximum power of the speakers is low~r than 50 W, change the
[AMP GAIN] setting to avoid damaging the speakers. (+12)
Mount the unit at an angle'of less than 30.
If your vehicle wiring harness does not have the ignition terminal,
connect Ignition wire (red) to the terminal on the vehicle's fuse box
which provides 12 VDC power supply and is turned on and off by the
ignition key.
After the unit is installed, check whether the brake lamps, blinkers,
wipers, etc. on the car are working properly.
If the fuse blows, first make sure the wires are not touching car's chassis,
then replace the old fuse with one th~t has the same rating.
Basic procedure
1 Remove the key from the ignition switch, then
disconnect the 8 terminal of the car battery.
2 Connect the wires properly.
Dashboard of
your car
8 mm (3/8") 8 mm (3/8")
11
\'<4>......_
14>......__
.
-
Pocket
Bracket (not supplied)
' .
18
( xl )
(B) Trim plate
Remote wire
(not supplied)
( xl )
-----+----- ----------------,
I
I
I
I
I
I
I
!
I
I
I
I
I
r----~-~-------~~--------~:
I
I
I
I
I
I
I
I
I
I
Yellow: Ba
I
!
I
I
Black: Ground
Jffi'C:OSc:::ut::
I
I
I
White/black
:I Scosche lndustnes:
:I www ;scosche.com
f
Green/black
I
I
I
!
I
Red: Ignition 12 V
( xl )
, __ ;
~(x2)
Purp
~--------------------------------------------------------------------------------------------------------------------------------------~
ENGLISH
19
I CAUTION
Use of controls or adjustments or performance of procedures other than those
specified herein may result in hazardous radiation exposure.
In compliance with Federal Regulations, following are reproductions of labels on, or
inside the product relating to laser product safety.
FCC WARNING
This equipment may generate or use radio frequency energy. Changes or
modifications to this equipment may cause harmful interference unless the
modifications are expressly approved in the instruction manual. The user could lose
the authority to operate this equipment if an unauthorized change or modification
is made.
FCC NOTE
This equipment has been tested and found to comply with the limits for a
Class Bdigital device, pursuant to Part 15 of the FCC Rules. These limits are
designed to provide reasonable protection against harmful interference in a
residential installation. This equipment may cause harmful interference to radio
communications, if it is not installed and used in accordance with the instructions.
However, there is no guarantee that interference will not occur in a particular
installation. If this equipment does cause harmful interference to radio or television
reception, which can be determined by turning the equipment off and on, the user
is encouraged to try to correct the interference by one or more of the following
measures:
Reorient or relocate the receiving antenna.
Increase the separation between the equipment and receiver.
Connect the equipment into an outlet on a circuit different from that to which the
receiver is connected.
Consult the dealer or an experienced radio/TV technician for help.
II
II
Microsoft and Windows Media are either registered trademarks or trademarks of Microsoft
Corporation in the United States and/or other countries.
Made for iPod," and Made for iPhone" mean that an electronic accessory has been designed to
connect specifically to iPod, or iPhone, respectively, and has been certified by the developer to
meet Apple performance standards. Apple is not responsible for the operation of this device or its
compliance with safety and regulatory standards. Please note that the use of this accessory with
iPod or iPhone may affect wireless performance.
iPhone, iPod, iPod classic, iPod nano, and iPod touch are trademarks of Apple Inc., registered in
the U.S. and other countries.
Lightntng is atrademark of Apple Inc.
Pandora, the Pandora logo, and the Pandora trade dress are trademarks or registered trademarks
of Pandora Media, Inc., used with permission.
iHeartRadioe is a registered mark of Clear Channel Broadc~sting, Inc. in the United States and
other countries. Such marks ar'e used under license.
Android is trademark of Google Inc.
..
-----
0:: :z.
w <( 0
en en ::;)
::)
~
w w. en
0::: c
. ..J
0
en I -
--
W
=
w ......
m :f ~
w 0 ~
...J ~ C(
m .__ w
LL
<(
(.)
::::iE
0
0:::
(.)
......
(.)
::::
w
......
:3
~
w
U)
::)
...J
m ~
CD
S: a
i= I=
w w
w <( (.)
> w__.
0:::
ifi
iii
0::: 0:::
1-
'~<(~
~
(.)
__.
LL
1.\ CAUTION
0::
0:::
CANADA
JVC
WARRANTY
GARANTIE
JVC CANADA INC. ( ci-apres appele "JVC") enon ce Ia garantie expresse suivante po ur tout nouveau pro dutt JVC distribue
au Canada par JVC et vendu par un detaillant JVCauto rise. JVC vous garanttt que ce produit est degage, so us utilisation et
entretien norm al, de to ut defaut materiel et de fabrication so us re serve des modalites et conditions suivantes :
3. Standards:
II any defects should be found in a JVC product within the
app licableterms. necessary repairs shall be made at no cost to
the purchaser for parts or labour when JVC acknowledges that
such defects aredue to faulty material or workmanship.
2. Limitation:
This Warranty shall not apply to
(a) Repair or replacement of any cabinets, batteries. plates.
connection cords. antennas. dust covers. knobs. speaker
grills. speaker cones. projection screens. projection screen
savers . and all accessories.
(b) Any defects caused or repairs required as a result of
misuse, abusive operation, negligence improper use and/or
insufficient care
(c) Any defect caused or repairs requned as a result of not
following the instructions in the operation manual
(d) Any JVC product tampered with, adjusted or repaired by
any party other than JVC or authorized JVC Service Centre
personnel
(e) Any JVC products on which the serial number has been
delaced. modified or removed.
(f) Maintenance, cleaning or periodic checkup
(g) Conversion to foreign or domestic voltage or frequency.
(h) Any JVC product without the Canadian Electrica l Safet y
Regulations ID
(i) Any JVC products used for commercial or institutional,
rental. or display purposes
Parts
1 year (except video head - 90 days)
Labour . 90 days
(j) Any JVC product which has been resold and no longer owned
by the original purchaser.
(k) Product purchased from outside Canada". "bankruptcy" or
"liquidator"
(I) Any defects caused by fire. flood. lightning power surge. or
other events beyond the control of JVC.
(m) FORAUTO PRODUCTS
Warranty does not cover elimination of ca r static or electrical
interferences. cleaning of head, adjustments, or labour cost
for the rernoval or reinstallation of the unit for repair.
2. Restrictions:
Cettegarantie ne s'applique pas aux
(a) Reparation au remplacement de tout cabinet batteries.
panneau ava nt. cordons de raccord, antennes. housses
deprotection. boutons. couverts de hautparteur. cones de
hautparleur. ecrans de protection protecteurs d'ecran de
protection et tous les accessoires.
(b) Taus defauts occasionnes ou reparations requises suite aune
utilisation abusive. mauvaise, negligenteet/ou une utilization
incorrecte.
(c) To us defauts occasionnes ou reparations rcquises suite
a!'omission de suivre les recomma ndations du manuel
d'rnstruction.
(d) Tout produit JVCa!tere. ajuste ou repare par lout au lie
entreprtse que JVC ou un centre deservice d'entretien ou de
service autorise JVC
(e) Tout produit JVC doni le numero de serie a ete altere , moditie
ou enleve
(f) L'entret ien. les verifications periodiques et neftoyage.
(g) La conversion aune lrequence ou unetension etran gereou
domestrque
(h) To ut produit JVC n'ayant pas le signe d'idenlificatton qui
conforme aux norms electrrques Canadiennes (CSA)
(i) Pour tout produit uti lise ades fins commerciales.
insti tutionnelles. de location ou utilise ades tins d'etatage.
Pieces
1 An (Excepte les tetes video- 90 jours)
Main d'oeuvre 90 Jours
(j) Tout produit JVC ayant ete revendu et qui n'est plus Ia
prop riete de l'ar.heteur orrgrnal
(k) Prod uit achete a"l'exterieu r du Canada" provenant dune
"taillite" ou d'un "liquidateur"
(I) Tout dommage cause par le feu. une inondation. un eclair.
une surtension ou tout autre evenement hors du controlede
JVC.
Product
Projection TV In-Home Service
Colour TV In-Home (25'. and above)
0-ILA Rear Projection In-Home Service
LCD TV In-Home Service (25" and above)
Parts
(Years)
Labour
(Years)
90 days 90 days
La garantls' applique seulement aux PRODUITS distrlbues au Canada par JVC Canada Inc.
Sertal No ..
Purchase date
Name of dealer:
No. de serie
Date d'achat
Nomdu revendeur
U.S.A.
JVC
LIMITED WARRANTY
ON LY FO R PRODUCT PURCHASED IN U.S.A
JVC Ame ri cas Corp. (JVC) warrants this product and all parts thereof, except as set forth below ONLY TOTHE OR IGINAL
RETA IL PURCH ASER to be FREE FROM DEFECTIVE MATER IALS AND WORKMANSHIP from the date of original purchase fo r
the period shown below. ("The Warranty Period")
,--------------------------------------.
YRS I LABOR 2 YRS : Car audio ARSENAL series
PARTS 2
PARTS 1 YR I LABOR 1 YR : All other car audio product s
THIS LIM ITED WARRANTY IS VALID ONLY IN THE FIFTY (50) UNITED STATES, THE DISTRICT OF COLUMBIA AND IN THE
COMMONWEALTH OF PUERTO RICO.
WHAT WE WILL DO:
If this product is found to be defective within the warranty period. JVCwill repair or replace defective parts with new or rebuilt equrvalents at no
charge to the original owner. Such repair and replacement services shall be rendered by JVC during normal business hours at JVC authorized
service centers. Parts used for replacement are warranted only for the remainder of the Warranty Period. All products may be brought to aJVC
auth orrzed service center on a carry- in basis. Color televisions with a screen size of 37"class or greater qualify for in-home service. In such
cases. atechnician will come to your home and either repair theTV there or remove and return it if it cannot be repaired in your home.
WHAT YOU MUST DO FOR WARRANTY SERVICE:
Please do not return your product to the retailer. Instead. return yo ur product to the JVC authorized se rvice center nearest you If shipping the
product to the service center, please be sure to package it carefully, preferably in the original packaging. and include a brief descr rption of
the problem(s) and a copy of the proof of purchase to verify purchase date. Please call 1-800-252-5722 to locate the nearest JVCauthorized
service center. Service locations can also be obtained from our website http/lwww.jvc.com. If your product qualifies for in-home service, the
service representative will require clear access to the product.
If you have any questions concerning your JVC Product. please contact our Customer Care Center at 800-252-5722
WHAT IS NOT COVERED :
This limited warranty provided by JVC does not cover
1 Products wh ich have been subject to abuse. accident. alteration, modification. tampering. negligence. misuse. faulty installation. lack of
reasonable care. or if repaired or servi ced by anyone other than a service facility authorized by JVC to render such service. or if affixed to
any attachment not provided with the products, or if the model or serial number has been altered, tampered with, defaced or removed;
2. Initial installation, installation and removal from cabinets or mounting systems
3. Operational adjustments covered in the Owner's Manual, normal maintenance. video and audio head cleaning;
4 Damage that occurs in shipment, due to act of God. and cosmetic damage;
5. Signal reception problems and failures due to fine power surge:
6. User Removal Memory Devices/Video Pick-up TubesiCCD Image Sensors are covered for 90 days from thedate of purchase;
7 Accessories;
8. Batteries (except that Rechargeable Batteries are covered for 90 days from the date of purchase).
9. Products used for commercial purposes. including, but not limited to rentaL
10. Loss of data resultant from malfunction of hard drive or other data storage device;
http ://www.jvc.com
Caution
To prevent electrical shock, do not open the cabinet.
There are no user serviceable parts inside.
Please refer to qualified service personnel for repairs.
PRODUCT REGISTRATION
We suggest that you register your product since it will enable us to contact you
directly if it is ever necessary to correct a safety related condition in your product.
You can register at www.register.jvc.com
Please note that failure to register does not diminish any of your rights during the
warranty period.
BT-50004-1 (0313)
REFURBISHED PRODUCTS CARRY ASEPARATE WARRANTY, THIS WARRANTY DOES NOT APPLY. FOR DETAIL OF REFURBISHED PRODUCT
WARRANTY, PLEASEREFER TO THEREFURBISHEDPRODUCTWARRAN TY INFORMATI ON PACKAGED WITH EACH REFURBISHED PRODUCT.
Serial No.:
Purchase date
Name of dealer
Printed in Indonesia