Professional Documents
Culture Documents
Description
Application
Automotive(Interior)
Properties
Test Condition
Test Method
Unit
Typical Value
250/2.16kg
ASTM D792
ASTM D955
ASTM D1238
%
g/10min
1.14
0.5~0.8
4.8
kg/cm2
540
%
%
kg/cm2
kg/cm2
>100
870
22,000
kgcm/cm
kgcm/cm
-
70
55
114
114
Physical
Specific Gravity
Molding Shrinkage (Flow), 3.2mm
Melt Flow Rate
Mechanical
Tensile Strength, 3.2mm
@ Yield
Tensile Elongation, 3.2mm
@ Yield
@ Break
Flexural Strength, 3.2mm
Flexural Modulus, 3.2mm
IZOD Impact Strength, 3.2mm
(Notched)
Rockwell Hardness
ASTM D638
50mm/min
ASTM D638
50mm/min
50mm/min
10mm/min
10mm/min
23
-30
R-Scale
ASTM D790
ASTM D790
ASTM D256
ASTM D785
Thermal
Heat Deflection Temperature, 6.4mm
(Unannealed)
ASTM D648
18.6kg
4.6kg
ASTM D1525
5kg, 50/h
IEC 60695-10-2
FMVSS 302
UL94
mm
class
class
class
class
UL 746B
Note) Typical values are only for material selection purpose, and variation within normal tolerances are for various colors.
Values given should not be interpreted as specification and not be used for part or tool design.
All properties, except melt flow rate are measured on injection molulded specimens and after 48 hours storage at 23, 50% relative humidty.
LUPOY NS5000C
Injection Molding, PC/ABS
Description
Application
Automotive(Interior)
Electrical
Comparative Tracking Index(CTI)
Surface Resistivity
Volume Resistivity
Arc Resistance
Dielectric Strength, 1mm
Dielectric Constant (10 6 Hz)
Solution A
23
23
23
23
IEC 60112
IEC 60093
ASTM D257
ASTM D495
ASTM D149
ASTM D150
Volts
Ohm
Ohmm
Ohmcm
kV/mm
sec
Note) Typical values are only for material selection purpose, and variation within normal tolerances are for various colors.
Values given should not be interpreted as specification and not be used for part or tool design.
All properties, except melt flow rate are measured on injection molulded specimens and after 48 hours storage at 23, 50% relative humidty.
Rear
Middle
Front
Unit
Value
hrs
%
kg/cm2
rpm
80~100
4~6
0.02
250 ~ 275
240 ~ 270
245 ~ 275
245 ~ 275
245 ~ 275
50 ~ 70
40 ~ 70
Note) Back Pressure & Screw Speed are only mentioned as general guidelines.
These may not apply or need adjustment in specific situations such as low shot sizes, thin wall molding and gas-assist molding.