Professional Documents
Culture Documents
carry current
generate EMI
all of the above
cause crosstalk
a.
b.
c.
d.
a.
b.
c.
d.
W per amp
mA per joule
s per W
amps per watt
a.
b.
c.
d.
vestigial sideband AM
SSB
FM
Suppressed-carrier AM
5.) The IEEE 802 spec for wireless LANs uses the:
a.
b.
c.
d.
infrared band
ISM band
UHF band
VHF band
10cm to 1m
10cm to 100m
10cm to 10m
Within 10ft
a.
b.
c.
d.
much lower
about the same
color CRTs use magnetic acceleration
much higher
FM
FSK
CDMA
AM
Avalanche Photodiode
Advanced Photodiode
Advanced Photo Detector
Avalanche Photo Detector
TDMA
CDMA
None of the above
Spread-spectrum
Bell Labs
AT&T
Lucent
Qualcomm
a.
b.
c.
d.
unique
common
orthogonal
rotating
FDDI
SONET
FTTC
FITL
a.
b.
c.
d.
CDMA
Frequency hopping
All of the above
TDMA
FM
SSB
Suppressed-carrier AM
Vestigial sideband AM
a.
b.
c.
d.
brightness
chroma
raster
contrast
multidirectional
none of the above
bidirectional
unidirectional
power-level adjustments
none of the above
antenna maintenance
orbital adjustments
B plastic
Both A and B
A glass
None of these
SC
SMA
ST
All of these
802.12
802.10
802.11
802.13
a.
b.
c.
d.
backdown
EIRP drop
Backoff
Power-down
Subscriber ID Module
Short Inbound Message
Subscriber ID Method
Subscriber-Initiated Message
an erg
a phonon
an e-v
a photon
ISM band
VHF band
UHF band
Infrared band
gain margin
excess gain
system margin
overdrive
0.2 dB
1 dB
0.02 dB
3 dB
2 to 16 nodes
2 to 4 nodes
2 nodes
2 to 8 nodes
MTSO
RF interface
Air interface
BSC
60.) Typically, repeaters are not required for fiberoptic cable lengths up to:
a.
b.
c.
d.
100 miles
100 Km
1000 miles
10 Km
IRE
EIA
FCC
IEEE
a.
b.
c.
d.
CDMA
TDMA
All of the above
Frequency Hopping
a.
b.
c.
d.
Red-Green Bandwidth
Red-Green Brightness
Red-Green Burst
Red-Green-Blue
900 MHz
800 MHz
1.9 GHz
12 GHz
power
high-gain antennas
all of the above
diversity
35,780 Km
357,800 Km
Depends on satellite velocity
5,578 Km
0.02 dB
1 dB
0.2 dB
3 dB
78.) The power per transponder of a typical Kuband satellite is in the range:
a.
b.
c.
d.
50 to 250 watts
500 to 2500 watts
Depends on its orbits
5 to 25 watts
a.
b.
c.
d.
POTS
Use built into an automobile
All of the above
Voice
4:3
525:625
3:4
625:525
0.4 dB per Km
4 dB per Km
40 dB per Km
Zero loss
dot
pixel
none of these
pic
10 ft
10 m
1 ft
1m
92.) A Soliton is a:
a.
b.
c.
d.
50
30
60
25
a.
b.
c.
d.
type of pulse
type of optical network
type of particle
defect in the glass
talking channels
voice channels
bearer channels
traffic channels
down-beam signal
direct-broadcast satellite
direct-broadcast system
decibels of signal
ring
mesh
star
repeater
Time-Delayed Duplex
Time Delay Difference
Time-Division Duplex
Total Distance Delay
obsolete
experimental
not possible
common
erlangs
number of users
number of blocked calls
calls
second generation
digital generation
third generation
first generation
excessive noise
a very wide microwave beam
a very narrow microwave beam
jitter
Intersymbol interference
Loss
Dispersion
All of the above
Chromatic Dispersion
Modal Dispersion
Waveguide Dispersion
All of the Above
SDH
Bit-synch
Bit stuffing
WDM
c. 1250
d. 1024
50
30
60
25
FSK
AM
CDMA
FM
smaller
distributed
bigger
higher-power
base-station class
maximum power level of a cell phone
signal classification (analog or digital)
code number of a cell phone
102 watts
103 watts
104 watts
101 watts
North America
Asia
Europe
All of these
multinet
TDD net
Scatternet
Micronet
require handoffs
require error detection
all of these
allow roaming
0.5 Km
As small as possible
2 Km
None of these
all of these
CSMA/CD
CDMA
CSMA/CA
a.
b.
c.
d.
4
2
Many
3
a.
b.
c.
d.
NTSC units
Umins
Foot-candles
IRE units
baseband type
IF type
Regenerative type
All of these
direct-sequence modulation
CDMA
All of these
Frequency hopping
a.
b.
c.
d.
a.
b.
c.
d.
Baseline current
E-H current
Dark current
Zero-point current
135.) In CDMA:
a. all frequencies are used in all cells
b. the frequency is selected by the mobile
phone
c. each cell uses half of the available
frequencies
d. each cell is assigned a frequency by the base
136.) MMDS stands for:
a. Multipoint Microwave Distribution System
b. Multiple Microwave Distribution Systems
c. Multichannel Multipoint Distribution
System
d. Multichannel Microwave Distribution
Systems
137.) Luminance is measured in:
a.
b.
c.
d.
Vestigial sideband AM
Suppressed-carrier AM
FM
SSb
Noise level
Jitter
All of these
Reliability
all of these
gigabit Ethernet
FDDI
High-speed Ethernet
a.
b.
c.
d.
Downlink
Footprint
Earth station
Plate
None of these
Standard Optical Network
Simple Optical Network
Synchronous Optical Network
QPSK
Frequency hopping
All of these
CDMA
all of these
multipath reception
attenuation due to weather
ducting