Professional Documents
Culture Documents
Version 1.0
Date: October, 2014
All specifications are subject to change without prior notice. Altai Technologies
assumes no responsibilities for any inaccuracies in this document or for any
obligation to update information in this document. This document is provided for
information purposes only. Altai Technologies reserves the right to change, modify,
transfer, or otherwise revise this publication without notice.
Contents
1. Executive Summary ........................................................................................... 4
2. AP configuration ................................................................................................ 4
2.1.
Outline .............................................................................................................. 4
2.2.
2.3.
2.4.
IP configuration ............................................................................................... 5
2.5.
2.6.
3. AC Configuration ............................................................................................... 7
3.1.
3.2.
3.3.
3.4.
1. Executive Summary
This guide is used to describe the configuration step of deploying a new AC in the
project.
This document will include below items:
1) AP configuration
2) AC configuration
2. AP configuration
2.1.
Outline
1) Collect AP information
AP model, AP Ethernet MAC address, installed location, planed channel
2) Firmware upgrade
Path: Administrator Firmware upgrade (Full Factory Reset)
3) IP configuration
Path: Configuration Network General
4) AP management VLAN configuration
Path: Configuration Network VLAN
5) Thin AP configuration
Path: Configuration Thin AP
2.2.
Collect AP information
default,
we
can
use
two
IP
to
login
AP:
192.168.1.222
and
2.3.
Firmware upgrade
2.4.
IP configuration
2.5.
2.6.
Thin AP configuration
2) When the AP use 2.4GHz radio and 5GHz radio for Wi-Fi access, then need
to enable thin AP and select Radio0(2.4G) and Radio1(5G) as Managed
Radio.
3. AC Configuration
3.1. Setup Preparation
When get a new AC, we need to configure interface for the AC via Console
cable first. Some console parameters: Baud_Rate-115200, Console 0 port for AC
Management Platform, Console 1 port for Access Platform, Putty or Xshell can be
the software terminal.
In the sample case, the network configuration as below:
Interface to Internet: 192.168.16.6/30, VLAN_ID: 140
Route: default gateway - 192.168.16.5
3.2.
The management platform is based on Linux, for vi editor, press " i " command
enter editing mode, after modify, press " Esc " to exit editing mode, press " Shift " +
" : " and input " wq " to save the modification and exit the vi editor.
1) Edit two files for tunnel (access.conf and forward.conf)
cwcos# vi /icac/conf/access.conf
1 127.0.0.1 4603
cwcos# vi /icac/conf/forward.conf
127.0.0.1 4603
3.3.
Note: in Access Platform, command for enter configuration mode: con ter, leave
the current configuration interface: exit
Sample as below:
3.4.
AC web configuration
After finish the configuration of management and access platform via CLI, we
can go to the AC web interface to configure the WLAN related items.
Outline:
4) AP Configuration
Create new AP group.
Configure the wireless setting (wireless mode, channel, transmit power level, etc)
of AP.
AC support import AP list, we can export the list and import it after the edition.
5) WLAN Groups
Create new WLAN group.
7) WLAN-VLAN Association
Set the Inner VALN as the WLAN VLAN(in the previous sample, it is 2000), set
the Outer VLAN as 0.