Professional Documents
Culture Documents
1
Installation and Users Manual
Document number (A4) 205041 rev 1 (0911)
Ap
ve
pro
Ap
ve
pro
Copyright
Manufactured by
Instrumentarium Dental
Nahkelantie 160 (P.O. Box 20)
FI-04300 Tuusula
FINLAND
Tel. +358 45 7882 2000
Fax. +358 9 851 4048
For service, contact your local distributor.
Ap
ve
pro
Ap
ve
pro
205041
Reviewed: Ikkel Kalle 13.11.09 10:39:39
Approved: rynen Teemu 17.11.09 10:24:55
See the PaloDEx Group Oy PDM system to determine the status of this document. Printed out: 08.02.10 10:33:46
ed
ov
r
p
p
Contents
1 Introduction..............................................................................................................3
1.1 General ...........................................................................................................3
2 Installing and setting up Instrumentarium Dental TWAIN ........................................4
2.1 Before Installation............................................................................................4
2.2 Installation .......................................................................................................4
2.3 Selecting Instrumentarium Dental devices ......................................................5
3 Using Instrumentarium Dental TWAIN.....................................................................9
4 Instrumentarium Dental TWAIN Setup ..................................................................12
Software License ......................................................................................................14
205041
Reviewed: Ikkel Kalle 13.11.09 10:39:39
Approved: rynen Teemu 17.11.09 10:24:55
See the PaloDEx Group Oy PDM system to determine the status of this document. Printed out: 08.02.10 10:33:46
ed
ov
r
p
p
1 Introduction
1.1 General
Instrumentarium Dental TWAIN is interface software for acquiring, processing
and viewing dental digital images via compatible third-party dental imaging
software (hereafter called application). Examples of this type of application
include dental imaging software from other equipment manufactures, practice
management software and special imaging software such as cephalometric
tracing.
Instrumentarium Dental Dental TWAIN supports the following Instrumentarium
Dental imaging devices:
Express
Snapshot
OP30
This manual describes how to install and use the Instrumentarium Dental
TWAIN.
Before installing the Instrumentarium Dental TWAIN or using the imaging
device refer to the documentation supplied with the imaging device.
Windows 7, Windows Vista and Windows XP operating systems support
Instrumentarium Dental TWAIN. Refer to the documentation supplied with
Windows for information about the Windows environment.
NOTE: If the Instrumentarium Dental imaging device(s) are used with a 3rd party
dental imaging software not produced by Instrumentarium Dental nor supported
by Instrumentarium Dental, the 3rd party dental imaging software must comply
with all applicable local laws and regulations on dental imaging software. This
includes, for example, the Medical Device Directive 93/42/EEC and/or FDA if
applicable.
205041
Reviewed: Ikkel Kalle 13.11.09 10:39:39
Approved: rynen Teemu 17.11.09 10:24:55
See the PaloDEx Group Oy PDM system to determine the status of this document. Printed out: 08.02.10 10:33:46
ed
ov
r
p
p
2.2 Installation
1. Insert the Instrumentarium Dental TWAIN CD into the CD-ROM drive of
the PC connected to the device.
2. The installation program will start automatically. If the installation program
does not appear, double-click the setup.exe file on the CD to start the
Instrumentarium Dental TWAIN installation.
3. Follow the on-screen instructions to install Instrumentarium Dental
TWAIN.
NOTE: It is recommended that you reboot the PC before using the
Instrumentarium Dental TWAIN for the first time.
205041
Reviewed: Ikkel Kalle 13.11.09 10:39:39
Approved: rynen Teemu 17.11.09 10:24:55
See the PaloDEx Group Oy PDM system to determine the status of this document. Printed out: 08.02.10 10:33:46
ed
ov
r
p
p
Description
An example of typical TWAIN
popup menu in the
application. There are
commands for acquiring the
image and selecting the
TWAIN source.
Another example: Scan
Image- and Select Scanner
Source commands are in the
File menu.
Open the TWAIN option and select the source (Select Source or Select
Scanner Source).
205041
Reviewed: Ikkel Kalle 13.11.09 10:39:39
Approved: rynen Teemu 17.11.09 10:24:55
See the PaloDEx Group Oy PDM system to determine the status of this document. Printed out: 08.02.10 10:33:46
ed
ov
r
p
p
2. From the TWAIN option select the scanners (devices) (Acquire or Scan
image).
Click Yes.
205041
Reviewed: Ikkel Kalle 13.11.09 10:39:39
Approved: rynen Teemu 17.11.09 10:24:55
See the PaloDEx Group Oy PDM system to determine the status of this document. Printed out: 08.02.10 10:33:46
ed
ov
r
p
p
When the intraoral device is selected the Setup button will become
enabled. Click the Setup button to open the device specific setup window.
Refer to the documentation supplied with the device for information on the
device options and settings.
Select the required extraoral device, and click OK.
When the extroral device is selected the Setup button will become
enabled. Click the Setup button to open the device specific setup window.
Refer to the documentation supplied with the device for information on the
device options and settings.
205041
Reviewed: Ikkel Kalle 13.11.09 10:39:39
Approved: rynen Teemu 17.11.09 10:24:55
See the PaloDEx Group Oy PDM system to determine the status of this document. Printed out: 08.02.10 10:33:46
ed
ov
r
p
p
If the application supports 16-bit transfers, select this for better image
quality.
205041
Reviewed: Ikkel Kalle 13.11.09 10:39:39
Approved: rynen Teemu 17.11.09 10:24:55
See the PaloDEx Group Oy PDM system to determine the status of this document. Printed out: 08.02.10 10:33:46
ed
ov
r
p
p
Note that the image area (gray area above the buttons and sliders) is
empty.
205041
Reviewed: Ikkel Kalle 13.11.09 10:39:39
Approved: rynen Teemu 17.11.09 10:24:55
See the PaloDEx Group Oy PDM system to determine the status of this document. Printed out: 08.02.10 10:33:46
ed
ov
r
p
p
205041
Reviewed: Ikkel Kalle 13.11.09 10:39:39
Approved: rynen Teemu 17.11.09 10:24:55
See the PaloDEx Group Oy PDM system to determine the status of this document. Printed out: 08.02.10 10:33:46
10
ed
ov
r
p
p
Select the Capture multiple images, and return them at once check box
to add multiple images to a Instrumentarium Dental TWAIN queue, and
then return (send) them all to the application at the same time.
This can be used, for example, when taking intraoral bite-wing series and
full mouth surveys.
NOTE: Activating either of these options will disable the brightness,
contrast and gamma sliders. If you need to use these sliders to adjust the
images both of these options must be disabled (unchecked).
4. Click the Return Image button to return (send) the captured image to the
application.
WARNING: The image will be permanently lost if you click the Close
button and then the OK button to confirm that you wish to close
Instrumentarium Dental TWAIN.
205041
Reviewed: Ikkel Kalle 13.11.09 10:39:39
Approved: rynen Teemu 17.11.09 10:24:55
See the PaloDEx Group Oy PDM system to determine the status of this document. Printed out: 08.02.10 10:33:46
11
ed
ov
r
p
p
205041
Reviewed: Ikkel Kalle 13.11.09 10:39:39
Approved: rynen Teemu 17.11.09 10:24:55
See the PaloDEx Group Oy PDM system to determine the status of this document. Printed out: 08.02.10 10:33:46
12
ed
ov
r
p
p
Technical Information
Supported Platforms:
Windows 7, Windows Vista , Windows XP
Standard Windows TWAIN source as defined by the TWAIN Working Group
Committee in the TWAIN Specification version 1.9 for Instrumentarium Dental
Digital X-ray Systems.
205041
Reviewed: Ikkel Kalle 13.11.09 10:39:39
Approved: rynen Teemu 17.11.09 10:24:55
See the PaloDEx Group Oy PDM system to determine the status of this document. Printed out: 08.02.10 10:33:46
13
ed
ov
r
p
p
Software License
SOFTWARE LICENSE
THIS DOCUMENT IS A LEGAL AGREEMENT BETWEEN YOU, AS THE
<LICENSEE>,
AND Instrumentarium Dental (THE <LICENSOR>) GOVERNING YOUR RIGHT
TO USE THE
Instrumentarium Dental TWAIN SOFTWARE MODULE (<Software>).
1. Subject-matter of the Software License
This Software License governs the use of the Software. Software means the
software product specified above including new versions or updates of the
Software made generally available to other licensees of such Software free of
charge, if any.
2. Software License Grant
2.1 Licensor hereby grants you a non-exclusive and non-transferable license to
use during the term of this Software License (i) the Software, in object code form
only and in accordance with the terms of this Software License and (ii) manuals
and other documentation related to the Software. You have no right to sublicense
the Software and you are under the obligation to return the same to Licensor
upon the expiration or termination of this Software License.
2.2 You are entitled to use each licensed Software only on a single computer or
terminal at any one time and, if necessary for use on such computers or terminals,
to modify the Software or merge them into another program, all portions of the
program continuing to be subject to this Software License in full. Licensor shall
not be held liable for any damages resulting directly or indirectly from a
modification or merger of the Software made by you, even if such modification or
merger was approved by Licensor.
2.3 You are granted no rights hereunder other than those expressly set out
hereinabove and, consequently, all other activities related to the Software are
prohibited. Such prohibited activities include but are not limited to (i) the deleting,
adding to, copying, modifying or transferring the Software or any part thereof, or
any copy or merged portion thereof, in whole or in part, except as expressly
provided for herein or authorized in advance by Licensor in writing and (ii) the
renting or leasing of the Software to another party.
205041
Reviewed: Ikkel Kalle 13.11.09 10:39:39
Approved: rynen Teemu 17.11.09 10:24:55
See the PaloDEx Group Oy PDM system to determine the status of this document. Printed out: 08.02.10 10:33:46
14
ed
ov
r
p
p
4. Copyright
4.1 The Software shall be delivered subject to all restrictions and protections
provided for under the applicable copyright and other laws and treaties. Except
as otherwise may be agreed by Licensor in writing, you have no right to
reproduce or otherwise duplicate the Software or any part thereof for any purpose
or to allow any third parties to do the same without the prior written consent of
Licensor. Notwithstanding the above, you may make one copy of the Software for
205041
Reviewed: Ikkel Kalle 13.11.09 10:39:39
Approved: rynen Teemu 17.11.09 10:24:55
See the PaloDEx Group Oy PDM system to determine the status of this document. Printed out: 08.02.10 10:33:46
15
ed
ov
r
p
p
205041
Reviewed: Ikkel Kalle 13.11.09 10:39:39
Approved: rynen Teemu 17.11.09 10:24:55
See the PaloDEx Group Oy PDM system to determine the status of this document. Printed out: 08.02.10 10:33:46
16
ed
ov
r
p
p
205041
Reviewed: Ikkel Kalle 13.11.09 10:39:39
Approved: rynen Teemu 17.11.09 10:24:55
See the PaloDEx Group Oy PDM system to determine the status of this document. Printed out: 08.02.10 10:33:46
17
ed
ov
r
p
p
205041
Reviewed: Ikkel Kalle 13.11.09 10:39:39
Approved: rynen Teemu 17.11.09 10:24:55
See the PaloDEx Group Oy PDM system to determine the status of this document. Printed out: 08.02.10 10:33:46
18
ed
ov
r
p
p