Professional Documents
Culture Documents
Product :
Cold Phos
active per 10/98
Product use :
Rust remover.
%:
CAS-nr :
OEL :
Symbol :
R-phrases :
Phosphoric acid
40 - 55
7664-38-2
1 mg/m3
34
Hazards Identification
Symbol:
CORROSIVE (C).
Risk phrases :
Causes burns.
Health Hazards
Routes of exposure :
Symptoms of exposure
Skin contact :
Eye contact :
In case of inhalation :
In case of swallowing :
severe irritation, redness, tearing, blurred vision, severe damage, corneal injury, burns.
nasal and respiratory irritation.
gastrointestinal irritation, nausea, vomiting, collapse, unconsciousness.
First-aid Measures
Skin contact :
After contact with skin, wash immediately with plenty of soap and water. If redness or
irritation persists: Seek medical advice.
Eye contact :
In case of contact with eyes, rinse immediately with plenty of water (at least 15 minutes)
and seek medical advice.
Issue date :
20/10/1998
Page 1 of 5
Supersedes :
10/10/1995
Cold Phos
Rinse mouth. Give at least two glasses of water to drink (dilution). NEVER give anything
by mouth to an unconscious person. Do NOT induce vomiting. Do NOT administer milk.
Give a magnesiumhydroxide solution (milk of magnesia). Seek medical advice.
Move person to fresh air. If breathing is difficult administer oxygen or apply artificial
respiration. Avoid physical exertion of the victim. Seek medical advice.
Inhalation :
Fire-fighting Measures
Note: See also " Stability and Reactivity "
Extinguishing media
Suitable :
NOT to be used :
Special precautions :
Protective equipment :
Explosion hazards :
Fire hazards :
Protective equipment
Small spills :
Large spills :
7
Handling :
Storage :
Keep container tightly closed. Keep from freezing. Keep away from: strong alkalies.
Skin :
Eyes :
Wear eye/face protection. Preferred type: Close-fitting safety goggles. If splashing is likely
to occur wear a full face-shield.
In case of insufficient ventilation, wear suitable respiratory equipment, suitable
respirator/filter: B (grey) / E (yellow) / P-2 (white).
Respiratory tract :
9
Appearance :
Colour :
Odour :
Clear liquid.
green.
None.
Boiling point :
Freezing/melting point :
105 C
< -10 C
1.29
Issue date :
20/10/1998
Supersedes :
10/10/1995
Page 2 of 5
Date printed : 13/11/2000
Cold Phos
None.
Auto-ignition temp. :
Explosion limits (%-vol) :
Not applicable.
lower :
upper :
None.
None.
Volatile component(s) :
Vapour pressure :
Evaporation rate :
Not applicable
As for water: 23 mbar (at 20 C).
Slower than ether.
pH :
Solubility in water :
1
Complete.
Further information :
None.
10
Chemical stability :
Hazardous polymerization :
Stable.
No polymerisation possible.
Conditions to avoid :
Materials to avoid :
Not applicable.
strong alkalies, strong mineral acids, bronze, brass and other copper alloys, metals like
magnesium, aluminium.
Not applicable.
11
Toxicological Information
Acute toxicity
Oral LD 50 (rat) :
Dermal LD 50 (rabbit) :
12
Ecological Information
BOD5 :
COD :
13
Disposal considerations
Waste disposal :
Spills and excess chemicals should be treated as chemical waste and disposed of in
accordance with all current special waste regulations. Contact a certified firm for proper
disposal.
14
Transport Information
1805 - III
Road :
ADR; class - item :
ADR Shipping name :
8 - 17c
PHOSPHORIC ACID, MIXTURE
Sea :
IMDG class :
IMDG page :
8204
Issue date :
20/10/1998
Page 3 of 5
Supersedes :
10/10/1995
Cold Phos
EmS / MFAG-table :
8 - 08
/ 700
Air :
ICAO/IATA-DGR
The IATA instruction is subject to annual revision. Contact your local supplier
Transport symbol
15
Regulatory Information
EU-labeling requirements :
Risk phrases :
CORROSIVE (C).
R 34.
Causes burns.
S 26, 45
In case of contact with eyes, rinse immediately with plenty of water (at least 15 minutes)
and seek medical advice. In case of accident or if you feel unwell, seek medical advice
immediately (show the label where possible).
Safety phrases :
National Regulations
* Denmark
National Regulations (DK) :
The use by persons under the age of 18 years is not allowed (DK-Ministery of Labour;
Publ. 594/92)
060104
1, Low hazard to water organisms (According to Annex 4 of VwVwS 06/1999 )
Zinc content :
0.8 % ( as Zn)
Finland
Product use :
Rust remover.
747
5
* Norway
YL-Gruppe :
Not applicable.
YL-Tall :
Not applicable.
16
Other information
20/10/1998
Page 4 of 5
Supersedes :
10/10/1995
Cold Phos
Issue date :
20/10/1998
Page 5 of 5
Supersedes :
10/10/1995