Professional Documents
Culture Documents
Some variation
may occur. However, the essential information in the illustrations is always correct.
Removal
Note!If the car is equipped with Four-C (Continuously
Controlled Chassis Concept), replace the spring.
See:Spring front, replacement.
Removing the spring strut
Remove:
the wheel
the anti-roll bar
link from the
spring strut.
Note!The
measurements are
taken so that the same
camber angle can be
obtained when
installing.
Remove:
Check that
the shock absorber
support plate (1), the
spring seat (2) and the
rubber bump stop with
boot (3) are undamaged.
Replace if necessary.
Installation
Note!For tightening torques, see Tightening torque
Installing the spring
Install:
the
the
the
the
Install:
Install the
spring strut on the
wheel spindle. Use
new screws and
new nuts
Adjust the
spring strut and
wheel spindle to
the measured
value.
Note!Ensure that
measurement is
performed at same
points as when
removing.