Professional Documents
Culture Documents
02 |
| 03
Marking
Nominal
protection
factor 1)
FFP1
FFP2
FFP3
P1
P2
P3
P1
P2
P3
TH1P
TH2P
TH3P
TM1P
TM2P
TM3P
4
12
50
4
12
48
5
16
1000
10
50
500
20
200
2000
50
2000
1) Values have been taken from the EN 529:2005 and BGR 190.
Additional national and local regulations must be followed.
Keep in mind that the performance indicated by the nominal protection
factor can only be achieved when the respiratory protective device is
worn correctly and has been properly maintained. Make sure you choose
the size that fits best for your face. Also, a respirator should only be worn
on cleanly shaven faces, as facial hair in the sealing area causes leakage.
04 |
You can see in table 1 that with a needed minimum protection factor of 30 for lead dust, you will need to use a
P3-filter or together with a half mask, a full face mask,
or PAPR. In the case where the contaminants are present in both particle and gas form, the nominal protection factor must be established for each one separately.
For the selection of filtering devices, the higher protection factor must be applied. The concentration of gases
is measured in ppm (parts per million= volume of the
substance within 1 m3 of air) or mg/m3 (= weight of the
substance within 1 m3 of air) and the concentration of
particles (dust) only in mg/m3. While mg/m3 deals with
weight and ppm with volume, there is no direct calculation for mg/m3 to ppm. Higher concentrations are often
indicated in % by volume, 10,000 ppm = 1 vol. %.
4. What is the maximum concentration of the contaminant for which I can use respiratory protection?
You can determine the maximum permissible concentration by multiplying the nominal protection factor (as
found in table 1) by the Occupational Exposure Limit
(OEL).
Maximum permissible concentration =
nominal protection factor x OEL
Example: Determining the maximum permissible concentration2)
Contaminant:
OEL:
Respirator:
Chlorine dioxide
0.1 ppm (Occupational Exposure Limit)
Full face mask with combination filter B-P2
Values and terms of calculation have been taken from the EN529:2005
and BGR 190. Additional national and local regulations must be followed.
Values of OEL based on AGW according to German regulations and
there of time-weighted average values over a reference period and
not any short term exposure limits.
| 05
Gaseous substances:
Colour
Filter
code
type
AX3)
A
B
E
K
CO4)
Hg5)
NO6)
Reactor7)
P
3)
Contaminants present
AX filters may only be used as supplied from factory. Reuse and use
against gascompounds is absolutely impermissible.
4)
CO filters for one time use only. Must be disposed after use. Special guidelines according to local regulations apply.
5)
Hg Filters can only be used for a maximum of 50 hours according to
EN 14387.
6)
NO filters for one time use only. Must be disposed after use.
7)
Reactor filters: special guidelines according to local regulations apply.
06 |
Filter
type
Filter
class
Gas filter
1
2
3
Particle filter
1
Combined filter
1-P2
2-P2
1-P3
2-P3
8)
9)
Protection
against
Maximum permissible
concentration
of toxic substance
| 07
08 |
Acetaldehyde
Acetamide
Acetic Acid
Acetic anhydride
Acetone
Acetoncyanohydrine
Acetonitrile
Acetyl chloride
Acrolein
Acrylamide
Acrylic acid
Acrylnitrile
Aldrin
Allyl chloride
1-Allyloxy-2,
3-epoxypropane
Allylpropyldisulfide
Filter
Colour
ppm
OEL
mg/m 3
type
code
50
10
5
500
20
0.1
10
carcinogen
carcinogen
91
25
21
1200
34
0.25
30
(cat. 2)
0.25 E
(cat. 3B)
AX (P3)
A-P3
B [E] (P2)
A (P2)
AX (P3)
A (P2)
A (P3)
B-P2
AX (P3)
A-P3
A (P2)
A (P3)
A-P3
AX (P3)
A (P2)
12
B (P2)
Contaminants
Aluminium
(respirable dust)
Aluminium hydroxide
Aluminiumoxide
(respirable dust)
Aluminium oxide
(fume)
o-Aminoazotoluol
1-Aminobutane
2-Aminobutane
4-Aminodiphenyl
3-Amino9-ethylcarbazol
2-Amino2-methylpropane
1-Aminopropane
2-Aminopropane
2-Aminopyridine
Amitrole
Ammonia
Ammonia in
water
Ammoniasolution 25%
Ammonium nitrate
Anilin e
Anthracene
9,10-Anthraquinone
Antimony
Antimony penta
chlorid
Antimony trioxide
Antimony hydrogen
ANTU
Arsenic acid
Arsenic pentoxide
Arsenic acid
Arsenic trioxide
Arsenic hydrogen
Asbestos
Auramine
Aziridine
Azo colorant
B
Barium chloride
Beechwood dust
Benzaldehyde
Benzidine and
its salts
Benzene
Benzene in water
Filter
Colour
ppm
OEL
mg/m 3
type
code
P2
3
3
P2
P2
P2
2
2
6,1
6,1
A (P3)
A (P2)
AX (P2)
A (P3)
A (P3)
AX (P3)
20
12
0.2 E
14
K(P2)
K (P2)
A-P3
A (P2)
K (P3)
K (P2)
20
14
K (P2)
7,7
NO-P3
A (P3)
A-P3
A (P2)
P2
B-P2
carcinogen
carcinogen
carcinogen
carcinogen
carcinogen
0.005
carcinogen
carcinogen
(cat. 2)
0.3
0.3 E
(cat. 1)
(cat. 1)
(cat. 1)
(cat. 1)
0.016
(cat. 1)
(cat. 2)
P3
B (P3)
B-P3
P3
P3
P3
P3
B (P3)
P3
A-P3
K (P3)
A (P3)
0.5 E
5
P2
P3
A (P2)
A (P3)
3.2
A (P3)
A (P3)
| 09
10 |
Contaminants
OEL
ppm
Benzine in water
Benzo[a]pyrene carcinogen
p-Benzochinone carcinogen
Benzo[e]pyrene
Benzylamine
Beryllium
carcinogen
Biphenyl
carcinogen
Bis(tributylzinn)oxide 0.002
Bitumen
Borax
Boroxide
Boric acid
Bromine
Bromobenzene
Bromochlorocarcinogen
methane
2-Bromo-2-chloro-1, 5
1,1-trifluorethane
Bromoform
2-Bromopentane
Brown coal tars
1,3-Butadiene
carcinogen
n-Butane
1000
n-Butanal
1-Butanol
100
2-Butanol
2-Butanone peroxide
1,4-Butane sultone
2,4-Butane sultone
2-Butenal (trans)
1-n-Butoxy-2,
3-epoxypropane
1-tert-Butoxy-2,
3-epoxypropane
2-Butoxyethanol 20
2-Butoxyethylacetone 20
1-Butyl acetat e 200
2-Butyl acetate
200
tert-Butyl acetate 200
n-Butyl acrylate
2
Butyl formiate
tert-Butyl
hydroperoxide
1-Butyl mercaptan 0.5
n-Butyl methacrylate
tert-Butyl peracetate
p-tert-Butyl phenol 0.08
Butyl stearate
p-tert-Butyltoluol
Filter
Colour
mg/m 3
type
code
(cat. 2)
(cat. 3B)
(cat. 1)
(cat. 3B)
0.05
0.5
1
0.7
(cat. 3B)
A (P2)
A (P3)
A-P3
A (P3)
A (P2)
P3
A-P2
B-P3
A-P3
P2
P2
B-P2
B (P3)
A (P2)
B (P2)
A (P2)
A (P2)
41
AX (P3)
(cat. 1)
2400
310
A (P3)
A (P2)
A-P3
AX (P3)
AX (P3)
A (P2)
A (P2)
A (P2)
B (P2)
A (P3)
A (P3)
A (P3)
A (P3)
A (P3)
98
130
950
950
950
11
A (P2)
A (P2)
A (P2)
A (P2)
A (P2)
A (P2)
A (P2)
B (P2)
1.9
0.5
B (P2)
A (P2)
B (P2)
A-P2
A (P2)
A (P3)
Contaminants
OEL
ppm
mg/m 3
C
Cadmium
Cadmium chloride
Cadmium oxide
Cadmium sulfate
Calcium arsenate
Calcium bisulfide
solution
Calcium chromate
Calcium cyanamide
1E
Calcium hydroxide
Calcium oxide
Camphor
2
13
E-Caprolactam
5E
Carbaryl
5E
Carbon disulfide
5
16
Carbon monoxide 30
35
Carbon tetrachloride 0.5
3.2
Carbon
tetrachloride in water
caustic potash (>5%)
Caustic soda
p-Chloraniline
Chlorbenzene
10
47
2-Chloro-1
bromoethane
Chlordane
0.5
Chlordecone
Chlorine
0.5
1.5
Chlorine dioxide 0.1
0.28
Chloroacetic acid 1
4
Chloroacetic acid 1
5
ethyl esther
Chloroethane
40
110
2-Chloroethanol 1
3.3
N-Chloroformyl-
morpholin
Chlorienated
0.1
1.1
biphenyls (chlorine content 42%)
Chlorienated
0.05
0.7
biphenyls (chlorine content 54%)
Chlorienated
carcinogen (cat. 2)
camphene (chlorine content 60%)
3-Chloro-2
methyl-1-propene
1-Chloronaphthaline
1-Chloro-1-nitropropane
Chloroform
0.5
2.5
Chloroform
in water
2-Chloroprene
carcinogen (cat. 2)
4-Chlor-o-toluidine
Filter
Colour
type
code
P3
P3
P3
P3
P3
E-P2
P3
P2
P2
P2
A-P2
A-P2
B (P2)
B (P3)
CO
A (P3)
A (P3)
P2
P2
A-P3
A (P2)
A (P3)
A (P3)
A (P3)
B (P3)
B (P2)
A-P3
A (P2)
AX (P3)
A (P3)
A (P3)
A (P3)
A (P3)
A-P2
A (P2)
A (P2)
A NO-P3
AX (P3)
AX (P3)
AX (P3)
A-P3
| 11
12 |
Contaminants
OEL
ppm
5-Chlor-o-toluidine
1-Chlorpentane
1-Chlorpropane
2-Chlorpropene
Chlortrifluoride
Chromium carbonyl
Chromium oxychloride carcinogen
Chromic acid
carcinogen
anhydrid
Citric acid
Coal tar
Cobalt
carcinogen
Cobalt acetate
tetrahydrate
Coconut oil
Copper
Copper chloride
(solution)
Copper sulfate
(solution)
Cotton dust
Cristobalite
carcinogen
(respirable dust)
Cumene
20
Cyanoacrylate2
methyl ester
Cyanogen bromide
Cyanogen chloride
Cyanuric chloride
Cyanuric chloride
(suspension in water)
Cyclohexane
200
Cyclohexanol
50
Cyclohexanone
20
Cyclohexene
Cyclohexylamine 2
1,3-Cyclopentadiene
Cyclopentanone
D
DDT
Decaborane
0.05
n-Decane
n-Decanol
Demeton
0.01
Demeton methyl 0.5
Diacetyl peroxide
2,4-Diaminoanisole
3,3'-Diaminobenzidine
3,3'-Diamino
benzidine-tetrahydrochloride
4,4'-Diamino
carcinogen
diphenyl methane
Filter
Colour
mg/m 3
type
code
(cat. 2)
(cat. 2)
A-P3
A (P2)
AX (P2)
AX (P2)
B (P2)
CO (P3)
B (P3)
P3
(cat. 2)
P2
A-P3
P3
P2
0.1
0.1
P2
P2
P2
0.1
P2
1.5 E
(cat. 1)
P2
P2
100
9.2
A (P2)
B (P2)
B-P3
B (P3)
B-P2
B-P2
700
210
80
8.2
A (P2)
A-P2
A (P2)
A (P2)
A (P2)
AX (P3)
A (P2)
1
0.25
0.1
4.8
A (P3)
B-P2
A (P2)
A (P2)
A B (P3)
A B (P3)
B-P3
A (P3)
A (P3)
A (P3)
(cat. 2)
A (P3)
Contaminants
OEL
ppm
1,2-Diaminoethane
2,4-Diaminotoluene
Diatomaceous
earth, calcinated
Diatomaceous
earth, uncalcinated
Diazinon
Diazomethane
Dibenzoyl peroxide
Dibenzylamine
Dibenzylether
Diboran e
1,2-Dibromo
3-chlorpropane
1,2-Dibroomethane carcinogen
Dibutyl ether
Dibutyl phthalate
3,3'-Dichlorbenzidine carcinogen
1,2-Dichlorbenzene 10
1,3-Dichlorbenzene 3
1,4-Dichlorbenzene 20
1,4-Dichloro-2-butene
2,2'-Dichloro
10
diethyl ether
2,2'-Dichloro
diethyl sulfide
Dichloro
diisopropyl ether
Dichloro
dimethyl ether
1,1-Dichloroethane 100
1,2-Dichloroethane
1,1-Dichloroethene 2
1,2-Dichloroethene 200
(cis)
1,2-Dichloroethene 200
(trans)
Dichlormethane 75
Dichlormethane
in water
1,2-Dichloro
methoxyethane
1,1-Dichloro
1-nitroethane
2,4-Dichloro
2-propanol
1,3-Dichloro
propionic acid
Filter
Colour
mg/m 3
type
code
0.3 A
A (P2)
A-P3
P2
4E
P2
0.1 E
5E
A (P2)
B (P3)
B-P2
A (P2)
A (P2)
B (P2)
A (P3)
(cat. 2)
(cat. 2)
61
20
120
58
A (P3)
A (P2)
A (P2)
A (P3)
A (P2)
A (P2)
A-P2
A (P3)
A (P3)
B (P3)
A (P2)
A (P3)
410
8
800
AX (P3)
A (P3)
AX (P3)
AX (P3)
800
AX (P3)
260
AX (P3)
AX (P3)
A (P3)
A NO-P3
A (P2)
A (P3)
A (P3)
A (P2)
| 13
14 |
Contaminants
OEL
ppm
1,2-Dichloro-1,
1000
1,2,2-tetrafluoroethano
2,4-Dichlortoluene 5
Dichlorvos
0.11
Dicyclohexyl
methane-4,4' -diisocyanate
Dicyclohexyl
peroxide
Dicyclopentadiene 0.5
Dieldrin
Diesel in water
Dieselfuel
Diethanolamine
Diethylamine
5
2-Diethylamino
5
ethanol
Diethylcarbamid
acid chloride
Diethyl carbonate
Diethyleneglycole 10
Diethylentriamine
Diethylether
400
N,N-Diethyl
hydroxylamine
Diethyl oxalate
Diethyl phtalate
Diethyl sebacate
Diethyl sulfate
carcinogen
Diethyl sulfide
Difluorobromomethane
Difluorodibromo
methane
Diglycidyl ether
carcinogen
1,2-Dihydroxybenzene
1,3-Dihydroxybenzene 4
1,4-Dihydroxybenzene carcinogen
Diisobutylketone
Diisopropylamine
Diisopropylether 200
Dilauroyl peroxide
3,3'-Dimethoxy
benzidine
1,1-Dimethoxyethane
1,2-Dimethoxyethane
Dimethoxymethan 1000
N,N-Dimethyl
10
acetamide
Dimethylamine
2
1-(Dimethylamino)
-2-propanol
N,N-Dimethylaniline 5
3,3'-Dimethyl
benzidine
Filter
Colour
mg/m 3
type
code
7100
AX (P3)
30
1
A (P2)
A (P3)
A B (P3)
B-P3
2.7
0.25 E
15
24
A-P2
A (P3)
A (P2)
A (P2)
A-P2
AX (P3)
A (P2)
B (P3)
44
1200
A (P2)
A (P2)
A (P2)
AX (P3)
A (P2)
(cat. 2)
A (P2)
A (P2)
A (P2)
A (P3)
B (P2)
AX (P3)
AX (P3)
(cat. 3B)
20 E
(cat. 2)
850
A (P3)
A-P2
A-P2
A-P2
A (P2)
A B (P2)
A (P2)
B (P2)
A (P3)
3200
36
AX (P3)
A (P2)
AX (P3)
A (P2)
3.7
K (P2)
A (P2)
25
A (P3)
A (P3)
Contaminants
OEL
ppm
_,_-Dimethylbenzyl-
hydroperoxide
2,2-Dimethylbutane 200
2,3-Dimethylbutane 200
1,3-Dimethyl
butyl acetate
Dimethyl
1,2-Dinitrobenzene
1,3-Dinitrobenzene
1,4-Dinitrobenzene
1,5-Dinitronaphthalene
2,6-Dinitronaphthalene
4,6-Dinitro-o-kresole
2,3-Dinitrotoluene
2,4-Dinitrotoluene
2,5-Dinitrotoluene
2,6-Dinitrotoluene carcinogen
3,4-Dinitrotoluene carcinogen
3,5-Dinitrotoluene
1,4-Dioxane
20
1,3-Dioxolan
100
Dipentene
20
Diphenyl ether
1
Diphenyl ether/
biphenylcompound
Diphenylmethan-4,
4'-diisocyanate
Diphenylmethan-4,
4'-diisocyanate,
liquid (50 C)
Filter
Colour
mg/m 3
type
code
B-P2
720
720
AX (P3)
AX (P3)
A (P2)
B (P3)
A (P2)
A (P3)
B (P3)
A (P2)
1900
6.1
AX (P3)
K (P2)
30
A (P2)
K (P3)
K (P3)
A (P2)
3.6
B (P2)
3000
(cat. 2)
(cat. 2)
(cat. 2)
73
310
110
7.1
AX (P2)
A (P3)
B (P3)
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A (P3)
A (P2)
A (P2)
A-P2
A-P2
0.05
B (P2)
B-P2
| 15
16 |
Contaminants
OEL
ppm
Diphosphorus
pentasulfide
Dipropylamine
Dipropylene
glycolmethyl ether
Dipropyl ether
Disulfur dichloride
Di-sec-octyl phthalate
Disulfiram
Di-tert-butylperoxide
1,2-Divinylbenzene
1,3-Divinylbenzene
Dodecylbenzenel
E
Endrin
Enflurane
20
EPN
1,2-Epoxybutane
1,2-Epoxypropane carcinogen
Ethanol
500
Ethanolamine
1
2-Ethoxyethanol 5
Ethyl acetate
400
Ethyl acrylate
5
Ethylamine
5
Ethylbenzene
100
Ethyl carbamate
Ethylene glycol
10
Ethylene glykol5
monoisopropyl ether
Ethylene oxide
carcinogen
Ethyl formate
100
2-Ethyl-1-hexanol 20
2-Ethylhexylamine
Ethyl mercaptan 0.5
Ethyl propionate
F
Fenthion
Ferbam
Ferrovanadium
(dust)
Fibers (inorg.)
Fluoride
1
Fluorobenzene
Formaldehyde
0.3
Formamide
Formic acid
5
Furan
Furfurol
carcinogen
Furfurylalcohol
10
G
Premium gasoline
Filter
Colour
mg/m 3
type
code
P2
A B (P2)
A (P2)
10
2E
A (P2)
B (P2)
A (P2)
B (P2)
B (P2)
A (P2)
A (P2)
A (P2)
0.1 E
150
0.5
(cat. 2)
960
2,5
19
1500
21
9.4
440
26
22
A (P3)
AX (P3)
A (P3)
AX (P3)
AX (P3)
A (P2)
A (P2)
A (P2)
A (P2)
A (P2)
K (P2)
A (P2)
A-P3
A (P2)
A (P2)
(cat. 2)
310
110
1.3
AX (P3)
AX (P3)
A (P2)
A (P2)
AX (P3)
A (P2)
0.2 E
A-P3
A (P2)
P2
1.6
0.37
9,5
(cat. 3B)
41
P2
B (P3)
A (P2)
B (P3)
A (P2)
B [E] (P2)
AX (P2)
A (P3)
A (P2)
A (P2)
Contaminants
OEL
ppm
Regular gasoline,
lead free
Gelatine
Glutaraldehyde
0.05
Glycerine
Glycidol
carcinogen
Glyoxal
Graphite
Graphite,
Heptachlor
n-Heptane
500
2-Heptanone
3-Heptanone
10
4-Heptanone
Hexachlorobenzene
Hexachloroethane 1
Hexamethylen
diamin
1,6-Hexa0.005
methylene diisocyanate
Hexamethylene-
tetramin
Hexamethyl
phosphoric triamide
n-Hexane
50
n-Hexanol
50
2-Hexanone
5
1-Hexen
2-Hexen
Hexylenglycol
10
Hydrazine
carcinogen
Hydrazoic
0.1
acid
Hydrochloric acid 32% 2
Hydrochloric acid
fuming 37%
Hydrogen bromide 2
Hydrogen chloride 2
Hydrogen cyanide 1.9
Hydrogen cyanide
in water
Hydrogen fluoride 1
Hydrogen peroxide 0.5
Hydrogen selenide
Hydrogen sulfide 5
Hydroxylamine
4-Hydroxy-420
methyl pentan-2-on
Filter
Colour
mg/m 3
type
code
A (P2)
0.21
50
(Kat. 2)
P2
A (P2)
A (P2)
A (P3)
AX (P2)
P2
P2
0.5 E
2100
238
47
9.8
P2
A-P3
A (P2)
A (P2)
A (P2)
A (P2)
A (P2)
A-P2
A-P2
0.035
B-P3
B K (P2)
A (P3)
180
210
21
A (P2)
A (P2)
A (P3)
AX (P2)
A (P2)
49
(cat. 2)
0.18
A (P2)
A (P2)
K (P3)
B (P2)
B [E]-P2
B [E]-P2
6.7
3
2.1
B [E] (P2)
B [E]-P2
B (P3)
B (P3)
0.83
0.71
0.05 E
7.1
96
B [E] (P3)
CO [NO]-P3
B (P3)
B (P3)
B [K] (P2)
A (P2)
| 17
18 |
Contaminants
OEL
ppm
I
Iod
Iodmethane
Iron chloride
Iron oxide
Isobutyraldehyde
Isoflurane
Isooctane
500
Isophoron
0.005
di-isocyanate
Isopropyl acetate 100
Isopropyl chloride
Isopropyl nitrate
Isopropyl oil
J
Jet fuel F34
K
Kerosene
Kerosene in water
L
Lactic acid
Lead
Lead(II)acetate-
Trihydrat
Lead arsenate
Lead chromate
Lead nitrate
Linseed oil
Lindane
Lithium hydride
M
Magnesiumchloride
(solution)
Magnesiumhydroxide
(solution)
Magnesiumoxide
Magnesiumsulfate
Malathion
Maleic acid
Maleic acid
0.1
anhydride
Manganese
Mercapto
acetic acid
2-Mercaptoethanol
Mercury
Mercury chloride
(solution)
Filter
Colour
mg/m 3
type
code
3
0.81
480
6.1
2400
0.046
B-P2
AX (P3)
B (P2)
P2
CO (P3)
P2
A (P2)
A (P2)
A (P2)
AX (P3)
AX (P3)
A (P2)
B (P3)
420
A (P2)
AX (P2)
A NO-P2
A (P3)
A (P2)
A (P2)
A (P2)
0.15
P2
P2
P2
0.15
0.1
0.025 E
P3
P3
NO-P3
P2
A-P3
P3
P2
P2
15 E
0.41
P2
P2
A (P2)
A-P2
A-P2
0.5 E
P2
B (P3)
0.1
0.1 E
B (P3)
Hg-P3
P3
Contaminants
OEL
ppm
Methacrylonitrile
Methacrylic acid 5
Methanol
200
Methoxychlor
2-Methoxyethanol 5
2-Methoxyethyl
5
acetate
1-Methoxy-2100
propanol
2-Methoxy-15
propanol
1-Methoxy-250
propylacetate
2-Methoxy-15
propylacetate
Methyl acetate
200
Methyl acrylate
5
Methylamine
10
N-Methylaniline
0.5
Methyl bromide
2-Methylbutane
1000
Methylcyclohexane 200
Methylcyclohexanol 6
4,4'-Methylene
bis(2-chloranilin)
4,4'-Methylene-bis
(N,N-dimethylanilin)
Methyl ethyl ketone 200
Methylformate
50
N-Methyl hydrazine
Methyl isobutyl ketone 20
Methyl isocyanate 0.01
Methyl mercaptan 0.5
Methyl methacrylate 50
N-Methyl-2,4,6carcinogen
N-tetranitroanilin
2-Methylpentan
200
3-Methylpentan
200
4-Methylpentan-2-ol 20
4-Methylpent5
3-en-2-on
2-Methyl-1-propanol 100
2-Methyl-2
-propanthiol
Methylpropionate
Methylpropylketone
N-Methyl-220
pyrrolidone (vapor)
Methyl mercury
carcinogen
Methylstyrene
100
Methyl-tert.-butylether 50
Mevinphos
0.01
Michlers Ketone
Filter
Colour
mg/m 3
type
code
18
270
15 E
16
25
A (P3)
A (P2)
AX (P3)
A (P2)
A (P2)
A (P2)
370
A (P2)
19
A (P2)
270
A (P2)
28
A (P2)
610
18
13
2.2
3000
810
28
0.02
AX (P3)
A (P2)
K (P2)
A (P3)
AX (P3)
AX (P3)
A (P2)
A (P2)
A (P3)
0.1 E
A (P3)
600
120
83
0.024
1
210
(cat. 3B)
A (P2)
AX (P3)
B (P3)
A (P2)
B (P3)
B (P2)
A (P2)
A NO-P3
720
720
85
20
AX (P2)
AX (P2)
A (P2)
A (P2)
310
A B (P2)
AX B (P2)
82
A (P2)
A (P2)
A (P2)
(cat. 3B)
490
180
0.093
Hg (P3)
A (P2)
AX (P3)
A-P3
A (P3)
| 19
20 |
Contaminants
OEL
ppm
mg/m 3
Mineral fiber
Monochloro
dimethyl ether
Morpholine
10
36
Motor oils,
used
N
Naled
1E
Naphta
Naphthalene
carcinogen (cat. 2)
1-Naphthylamine 0.17
1E
2-Naphthylamine carcinogen (cat. 1)
1,5-Naphthylene-
0.05
diisocyanate
Nickel
carcinogen (cat. 1)
Nickel, sulfidic ores carcinogen (cat. 1)
Nickel carbonate carcinogen (cat. 1)
Nickel(II)-chloride carcinogen (cat. 1)
Nickel oxide
carcinogen (cat. 1)
Nickel compounds carcinogen (cat. 1)
in the form of respirable droplets
Nickel sulfide
carcinogen (cat. 1)
Nickel tetracarbonyl
Nicotine
0.5
Nitric acid
1
2.6
Nitric acid 65%
1
2.6
Nitric acid 90%
1
2.6
5-Nitroacenaphthene
2-Nitro-4
aminophenol
4-Nitroaniline
carcinogen (cat. 3A)
Nitrobenzene
1
4-Nitrobiphenyl
Nitroethane
100
310
Nitrogen dioxide carcinogen (cat. 3B)
Nitrogen monoxide
Nitroglycerine
carcinogen (cat. 3B)
Nitroglycol
0.05
0.32
Nitromethane
carcinogen (cat. 3B)
1-Nitronaphthalene
2-Nitro-p
phenylendiamine
1-Nitropropane
25
92
2-Nitropropane
carcinogen (cat. 2)
Nitropyrene
(Mono,Di,Tri,Tetra)
Nitrogen gases
N-Nitrosodi
ethanolamin
N-Nitrosodi
ethylamine
Filter
Colour
type
code
P3
AX (P3)
A (P2)
A-P3
A-P2
A (P2)
A-P2
A-P3
A-P3
B (P3)
P3
P3
P3
P2
P3
P3
P3
CO-P3
A (P3)
B NO-P3
NO-P3
NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
NO-P3
NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
NO-P3
A NO-P3
A NO-P3
Contaminants
OEL
ppm
mg/m 3
N-Nitrosodi-i
propylamine
N-Nitrosodi
methylamine
N-Nitrosodi
n-butylamine
N-Nitrosodi
n-propylamine
N-Nitrosoethyl
phenylamine
N-Nitrosomethyl-
ethylamine
N-Nitrosomethyl-
phenylamine
N-Nitrosomorpholine
N-Nitrosopiperidine
N-Nitrosopyrrolidine
2-Nitrotoluene
carcinogen (cat. 2)
3-Nitrotoluene
carcinogen (cat. 3B)
4-Nitrotoluene
carcinogen (cat. 3B)
n-Nonane
O
Oakwood dust
5
n-Octane
500
2400
n-Octanol
20
106
1-Octen
Oil
Osmium tetraoxide
Ozone
carcinogen (cat. 3B)
P
Palmitic acid
Paraldehyd
Paraquat dichloride
0.1 E
Parathion (-ethyl)
0.1 E
Pentaborene
0.005
0.013
Pentachloroethane 5
42
Pentachloronaphthaline
Pentachlorophenol
n-Pentane
1000
3000
n-Pentanol
20
73
n-Pentylacetate
50
270
Perchloroethylene carcinogen (cat. 3B)
Perchloroethylene
in water
Peracetic acid
Permethrin
Petrol
Phenol
2
7.8
Phenolphthalein
Filter
Colour
type
code
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A NO-P3
A (P2)
P3
A (P2)
A (P2)
A (P2)
P2
A-P3
B (P3)
A (P3)
NO-P3
P2
A (P2)
A (P3)
A (P3)
B-P3
A (P3)
A-P2
A-P3
AX (P3)
A (P2)
A (P2)
A (P3)
A (P3)
B (P2)
A (P2)
A (P2)
A-P3
A (P2)
A (P2)
| 21
22 |
Contaminants
OEL
ppm
p-Phenylendiamine
Phenylhydrazine carcinogen
Phenyl isocyanate 0.01
N-Phenyl-2
naphthylamine
Phosgene
0.02
Phosphorous oxychloride 0.2
Phosphorous pentachloride
Phosphorous pentoxide
Phosphorous acid
Phosphorous trichloride 0.5
Hydrogen phosphide 0.1
Phthalic anhydride
Polyviny lchloride
Potassium chloride
Potassium chromate carcinogen
Potassium cyanide
Potassium hydroxide
(anhydrous)
Potassium
sulfate
Propanal
2-Propanol
200
n-Propanol
1,3-Propane sultone
2-Propanthiol
Propargyl alcohol 2
2-Propen-1-ol
2
iso-Propenyl50
benzene
-Propiolactone
Propionic acid
10
Propoxur
Pyridine
carcinogen
Q
Quarz
carcinogen
Fused quartz
R
Rotenone
(standard)
S
Salicylic acid
Sodium azide
Sodium benzoate
Sodium chlorate
Sodium chloride
Filter
Colour
mg/m 3
type
code
0.1 E
(cat. 3B)
0.05
A (P3)
A (P3)
B (P2)
A-P3
0.082
1.3
1E
2E
2
2.8
0.14
(cat. 2)
B (P3)
B (P2)
B-P2
P2
P2
B (P2)
B (P3)
A-P2
P2
P2
P2
B-P3
P2
P2
500
4.7
4.8
250
AX (P2)
A (P2)
A (P2)
A-P3
AX B (P2)
A (P3)
A (P3)
A (P2)
31
2E
420
0.34
A (P3)
B (P2)
B (P3)
A (P2)
A NO-P3
1E
(cat. 3B)
AX (P3)
A (P2)
B (P2)
A (P2)
A (P2)
(cat. 1)
0.3 A
P2
A P2
A (P3)
0.2
A (P2)
P3
P2
P2
P2
Contaminants
OEL
ppm
hydrogen carbonate
Sodium hydroxide
(anhydrous)
Sodium silicate solution
Sodium sulfate
Sodium thiosulfate
Sulphur dichloride
Sulphur dioxide
0.5
Sulphur pentafluoride
Sulphuric acid
Sulphuric acid
Selenium, amorphous
Silver
Silica fume
Silica acids,
colloidal amorphous
Silicone carbide
(fibre-free)
Stearic acid
Strontiumchromate
Strychnine
Styrene
20
Sulfotep
0.0075
Sulfuryl chloride
T
Talc (free of
carcinogen
asbestos fibers)
Tannic Acid
Tantalum
Tar fumes
Tartaric acid
Tellurium and
compounds
TEPP
0.005
Tetra ethyl lead
Turpentine oil
carcinogen
1,1,2,2-Tetra
bromoethane
2,3,7,8-Tetrachloro-
dibenzo-p-dioxine
1,1,1,2-Tetrachloro-2, 200
2-difluoroethane
1,1,2,2-Tetrachloro-1, 200
2-difluorethan
Filter
Colour
mg/m 3
type
code
(cat. 2)
3.8
0.05 E
P3
B-P3
B (P3)
P2
P2
1.3
0.1
P2
P2
P2
B-P2
E (P3)
B (P2)
P2
B-P2
0.05 E
0.1 E
0.01 E
0.3 A
0.3
4E
B-P2
P2
P3
P3
P2
P2
P2
P2
P2
86
0.1
10
A (P2)
P3
A (P3)
A (P2)
A (P3)
B-P2
(cat. 3B) P2
P2
P2
A-P3
P2
P3
0.06
0.05
(cat. 3A)
A (P3)
A (P3)
A (P2)
A (P3)
A (P3)
1700
A-P2
1700
A-P2
| 23
24 |
Contaminants
OEL
ppm
1,1,2,2-Tetra1
chloroethane
Tetraethyl silicate 10
Tetrahydrofuran
50
Tetrahydrothiophene 50
1,2,4,5-Tetra
methylbenzene
Tetramethyl
succinnitrile
Tetranitromethane carcinogen
Tetraphosphorus
4,4'-Thiodianiline
Thiourea
Thionyl chloride
Thiram
Tin(IV) chloride
Titanium dioxide
o-Toluidine
p-Toluidine
Toluene
50
Toluoene in water
2,4-Toluylen0.005
diisocyanate
2,6-Toluylen
0.005
diisocyanate
Tributylphosphate 1
Tributyltin benzoate 0.002
Tributyltin chloride 0.002
Tributyltin fluoride 0.002
Tributyltin linoleate 0.002
Tributyltin
0.002
methacrylate
Tributyltin
0.002
naphthenate
1,2,4-Trichlorobenzene 0.5
2,3,4-Trichloro-1-butene
1,1,1-Trichloroethane 200
1,1,2-Trichloroethane10
1,1,1-Trichloroethane
in water
Trichloroethylene carcinogen
Trichloroethylene
in water
Trichloronaphthalene
Trichloronitromethane 0.1
2,4,5-Trichloro
phenoxyacetic acid
1,2,3-Trichloropropane carcinogen
, , -Trichlorotoluene carcinogen
Tridymite
carcinogen
Triethanolamine
Triethylamine
1
Triethylentetramine
Filter
Colour
mg/m 3
type
code
A (P3)
86
150
180
A (P2)
A (P2)
B (P2)
A (P2)
A-P2
(cat. 2)
0.01
1E
2E
3
190
0.035
NO-P3
P3
B (P3)
B (P3)
B (P2)
B (P2)
B-P2
P2
A (P3)
A-P3
A (P2)
A (P2)
A B (P3)
0.035
A B (P3)
11
0.05
0.05
0.05
0.05
0.05
A (P2)
B-P3
B-P3
B-P3
B-P2
B-P3
0.05
B-P2
3.8
1100
55
A (P2)
A (P3)
A (P2)
A (P3)
A (P2)
(cat. 1)
A (P3)
A (P3)
0.68
10
A-P2
A NO-P3
B (P2)
(cat. 2)
(cat. 2)
(cat. 1)
4.2
A (P2)
B (P3)
P2
A (P2)
A (P2)
A (P2)
Contaminants
OEL
ppm
mg/m 3
Trimanganese tetroxide
0.5
Trimellitic
0.04
anhydride (fume)
Trimethylamine
2
4.9
2,4,5-Trimethylaniline
1,2,3-Trimethylbenzene 20
100
1,2,4-Trimethylbenzene 20
100
1,3,5-Trimethylbenzene 20
100
3,5,5-Trimethyl-2- 2
11
cyclohexen-1-one
2,4,4-Trimethyl
1-pentene
Trimethyl phosphate
2,4,7-Trinitrofluorenone
2,4,6-Trinitrophenol
0.1 E
2,4,6-Trinitrotoluene 0.011
0.1
Tri-p-cresyl phosphate
U
n-Undecane
V
Vanadium pentoxide
0.05
Vinyl acetate
5
18
Vinyl bromide
Vinyl chloride
3
7.77
4-Vinyl-1,2
cyclohexendiepoxid
W
Warfarin
0.5
White spirit
500
960
Wood oil
Wood dust
Xylidine
carcinogen (Kat. 3A)
Xyloene
100
440
Xylene in water
Y
Yttrium
Z
Zinc chromate
Zinc sulfate
Filter
Colour
type
code
| 25
P2
A (P3)
B (P2)
A-P3
A (P2)
A (P2)
A (P2)
A (P2)
A (P2)
A (P3)
A NO-P3
A NO-P3
A NO-P3
A (P2)
A (P2)
A P3
A (P2)
AX (P3)
AX (P3)
A (P3)
A-P3
A (P2)
P2
P3
A-P3
A-P3
A (P2)
A (P2)
P2
P3
P2
P2
26 |
| 27
D-2306-2009
MEXICO
SUBSIDIARIES:
AUSTRALIA
www.draeger.com
FRANCE
SINGAPORE
90 46 529 | 07.09-2 | Marketing Communications | UUU | PR | ED | Printed in Germany | Chlorine-free environmentally compatible | Subject to modifications | 2009 Drger Safety AG & Co. KGaA
HEADQUARTERS: