Professional Documents
Culture Documents
If SPI ESL 2009 SP1 is uninstalled at any time (and this must be done
before you install a new version of SPI ESL, e.g. 2009 SP2), it will break
SPEL. Therefore, if this was done on any machine, the following should
be performed:
o Remove SPEL completely follow the steps in Appendix B of this
document, for SPEL only. You must uninstall the base version of
SPEL together with any Service Packs and Hot Fixes, all from
Control Panel, and follow Appendix B. It is not necessary to
remove SPEM.
o Re-install SPEL base version 2009, Service Pack SP2, and hot fix
HF10.
o If ESL is removed again for any reason, reapply the two steps
above, that is remove SPEL completely and re-install SPEL.
Intergraph believes that these steps will now resolve:
However, Intergraph would like to have more information about the SPI
ESL problem when the draft.exe fails with both SPI and SPEL. This only
happened once in our tests.
Note: Intergraph recommends that Customer upgrades to SPI ESL
2009 SP2 as this fixes the above problem completely.
1.1.2 Clean-up Steps after Removal
Under normal circumstances, uninstalling the product from Control Panel >
Add/Remove Programs, uninstalls the Intergraph product. However, in some
cases there could be traces of the product left behind, causing a subsequent
re-installation to fail, or if the re-installation succeeds, some aspect of the
application may not work. In these cases, use the steps listed in the relevant
product Appendix of this document to completely remove the product before
re-installing it.
If an Intergraph product is not covered in the Appendices, you can always
use the Windows MS Installer Cleanup Utility (available from
h.
i.
j.
k.
Notes:
1. If you need to install a new SPI-ESL Service Pack (SP) or Hot Fix (HF),
follow these steps:
Remove SPP&ID (one entry for SP/HF, then one entry for base
version in Add/Remove Programs)
Remove SSK
Install SSK
3. If you install a new SPI SP and/or HF, you need to remove and reinstall SPP&ID. Follow these steps (same as in Note 2 above, after
installing the new SPI SP and/or HF):
Remove SPP&ID (one entry for SP/HF, then one entry for base
version in Add/Remove Programs)
Remove SSK
Install SSK