Professional Documents
Culture Documents
Introduction Install the USB drivers Download required files Check FTM mode Install
QPST & Backup qcn Restore qcn Reinstall stock ROM Comments
On this page, we will install QPST and set it up in order for your Orange San Francisco II to
communicate with your computer.
1.
On your PC, download qpst.zip to you desktop. Once completed, extract it.
2.
Open the folder Install QPST (from the zip you just extracted) and
run setup.exe (or setup) to install. Follow the on screen instructions.
4.
5.
Tap Applications.
6.
Tap Development.
7.
8.
Switch off your phone, remove the battery, wait 5 seconds, and then reinsert.
9.
Hold the Volume down and Power on button at the same time, for 10 seconds.
10.
Troubleshooting
If your phone boots as normal, it is likely that you did not press the required buttons correctly,
or you did not disconnect your phone from your computer. Try booting into FTM mode again.
11.
12.
Click Start -> All Programs -> QPST -> QPST Configuration
13.
Click the Ports tab, and then click the button Add New Port ...
Click the Ports tab then the Add New Port... button.
14.
Click on COM - USB/QC Diagnostic and click OK. In our case, there was the number 9
after COM, as seen in the picture below. You may have a different number, which is fine.
15.
16.
Click the Backup tab and then the second Browse button.
Click the Backup tab and then click the second Browse button.
17.
You should now be presented with a Window asking you where to save a file. Save the
file to your Desktop, and name it osf2
18.
19.
Wait until you see "Memory Backup Completed" in the Status box.
20.
Go to your Desktop and check the file size of osf2. Make sure it is NOT 0 KB in file size.
You can do this by simply hovering over the file with your mouse, as seen below. For us, the file
size was 153 KB, however it may be different for you, which is fine - just make sure it is greater
than 0 KB.
Check the file size of osf2 by hovering your mouse over the file. Make sure it is greater than 0
KB.
21.
22.
Click Start -> All Programs -> QPST -> QPST Configuration
23.
24.
25.
Click the only COM device listed and then click the Disable button.
26.