Professional Documents
Culture Documents
PROTECTIVE COATINGS
RECOMMENDED
USES
TECHNICAL DATA
COLOUR, DRY FILM
FINISH, DRY FILM
VOLUME SOLIDS
(ASTM D2697)
SPECIFIC GRAVITY
THEORETICAL
SPREADING RANGE
RECOMMENDED DFT
RANGE (DRY FILM
THICKNESS)
RECOMMENDED WFT
RANGE (WET FILM
THICKNESS)
FLASH POINT
FLEXIBILITY
Yellowish Green
Smooth / Matt
56 2%
1.55 0.05
14.0 11.2 M2/LTR
40 50 Microns/Coat
72 90 Microns/Coat
38C
Good
DRYING TIME
Drying time @ 30C (Temperature, humidity, air movement, film thickness and number of coats
all affect the drying time.)
TOUCH DRY
DRY TO RECOAT/OVER
COAT
HARD DRY
Rev. 05/10
Page 1/3
30 45 minutes
12 hours
24 hours
www.national-paints.com
ADVANTAGES
NATIONAL ZINC
CHROMATE PRIMER
APPLICATION INSTRUCTION
New Steel: All surfaces to be coated should be clean, dry and free
from any contamination. Oil and grease should be removed by
solvent cleaning as per SSPC-SP1. Abrasive blast cleaning to Sa
2.5 or mechanical cleaning using hand/power tool to minimum of
St 2 standard should be done.
Repair/Maintenance: Existing paints system should be dry and free
from salt and other contaminants. Corroded and/or damaged areas
should be blast cleaned to Sa 2 or power tool cleaned to St 3.
SURFACE PREPARATION
APPLICATION DATA
APPLICATION METHOD
CLEANING/THINNING
THINNER (VOLUME)
CONV. SPRAY REQUIREMENTS
AIRLESS SPRAY REQUIREMENTS
NOZZLE SIZE
MIXING RATIO (BY VOLUME)
POT LIFE @ 30c (100 ml)
SYSTEM
No. of coats x DFT (micron)
RECOMMENDED SYSTEM
To be applied on prepared surface.
1 x 40
1 x 40
2 x 35
2 x 35
ADDITIONAL DATA
SHELF LIFE @ 30C
Rev. 05/10
Page 2/3
www.national-paints.com
NOTE: We warranty only the quality of our product and this data sheet is based on results obtained from experience and tests.
We reserve the right to change data without prior notice. For surface preparation, safety details refer specifier and safety
data.
This data sheet supersedes all previous issued.
Issued: 0608
Rev. 05/10
Page 3/3
www.national-paints.com