Professional Documents
Culture Documents
Sa
mp
le
file
This pack provides images to build a basic Semi-detached House, larger house
with optional extension, Church and industrial building in 1:144 scale.
WARNING The construction of Fold Flat Terrain requires the use of sharp
scissors/knives and solvent-based glues, so are unsuitable for children under 14
and adult supervision is required.
You will need
A4 Coloured card 250 to 300 grm/m2 in Grey for the house and boundary walls, dark red or
brown for house roofs, green for the folds.
12 (300mm) steel rule
Sharp Knife (disposable ones are ideal, but change the blade after a couple of sheets)
Sharp Scissors (optional)
Biro pen preferably empty, but Black is OK.
A surface protected from knifes, glue and Biro scratches. A whole newspaper is ideal.
Solvent-based glue Bostic Clear is ideal. Water based e.g. PVA are unsuitable as they wet the
card and distort it.
Page 1
Printing
The files are based on 600 dpi resolution and if printed at this resolution should come out at the correct
size.
Painting
Some structures look better painted particularly hills/folds etc. This is best done with spray paints.
This should be done in a well-ventilated area using very thin coats, preferably just misting the surface to
avoid wetting and distorting the structure.
Storage Keep the models in a box file, folded flat and they will last a long time. Some of the authors
have lasted 8 years and are still going.
General Notes on Construction
Outlines - are thicker lines but not by much, too thick makes accuracy difficult. Cut as close to the
centre of the line as possible.
Fold markings meanings are shown below.
mp
le
file
Sa
Score down the fold with a Biro using the steel rule down the middle of the line. Having folded the
crease, run the end of the ruler over it to get a really sharp crease. Note at 1:144 it is best to score with
a knife those folds that are marked for scoring with a knife ONLY. Folds that need to move to fold up
must be scored with a biro!.
SEMI DETACHED HOUSES
This pack makes up Semi Detached Houses.
Construction of Houses
1.
2.
3.
4.
Cut out the wall. The windows can be left as is or cut out (not recommended at this scale).
Score all the creases and fold them. Use a knife for those marked as they will be glued and a biro
for the rest.
Cut out the roof tab slots.
Glue the apex wall flaps down to re-inforce the apex walls.
Score these
lines only
with a knife
Flap A
FIGURE S1
Page 2
5.
6.
7.
Glue the ends of the wall section together to form the base of the house using FLAP A.
Cut out Roof section and glue flaps down on the underside. Note score with a knife on the long fold
(see fig. S2) but use a biro on the tabs. DO NOT glue tab down see Fig. S2.
Glue the roof to the walls using TAB A of the wall section.
Score these
lines only
with a knife
GL
UE
TA
B"
A
" H
ER
E
mp
le
file
NOTE - Roof Sections for the Church Nave, Governors House and Mansion East Wing are all on
the same sheet.
BUILD INSTRUCTIONS
Sa
These are made almost exactly the same as the Semi Detached- House. Only the variations are listed
below.
Construction of Mansion east wing.
This is the same as the Governors house except the inner wall is glued as shown in the following figure.
Page 3
CHURCH NAVE
This is built the same way as the Governors house except:
CHURCH TOWER
This forms a square tower. The build is much like the rest except:
of
pri
n
ted
mp
En
d
le
file
Fold over the tower top, Cut out the battlements (crenulations), so both sides match but do not
glue. and unfold.
Glue the tower walls together.
Fold over the tower top and glue. This hides the flaps
Glue the roof support and the Roof flap D as shown in the diagram below.
ni
ns i
de
Sa
sec
tio
p
Fla
'D '
WORKSHOP/HANGER
1.
2.
3.
4.
Cut out the Front rear walls but not the widows.
Glue the flaps at the top and bottom of the walls to strengthen them. Score the creases with a
knife to make folding easier.
Glue walls together as for the Semi-Detached.
Cut out the roof section and fold as shown in figure 3
Page 4
View of roof
from un printed
side
Score with
knife this fold
Glue only this section to the roof
Figure 3
file
Glue roof to wall note. The edge of the roof should be in line with the long edge of the wall but
with a small overhang at the ends. The black triangles on the roof show the position of the
wall. It is possible to use a very soft pencil to mark the position on the roof so it can be erased
afterwards.
Sa
mp
le
5.
Page 5
ld
Fo
ld
Fo
wn
do
d
an
Gl
ue
ue
Gl
ue
ue
Gl
d
an
d
an
wn
do
wn
do
ld
Fo
ld
Fo
wn
do
Gl
Fo
ld
do
wn
an
d
Gl
ue
Gl
ue
Gl
ue
Gl
ue
an
an
an
wn
wn
wn
do
do
do
ld
ld
ld
Fo
Fo
Fo
file
le
mp
Sa
ld
Fo
ld
Fo
wn
do
d
an
Gl
ue
ue
ue
ue
Gl
Gl
Gl
d
an
d
an
wn
do
wn
do
ld
Fo
ld
Fo
wn
do
d
an
Fo
ld
do
wn
an
Gl
ue
Gl
ue
Gl
ue
Gl
ue
an
an
an
wn
wn
wn
do
do
do
ld
ld
ld
Fo
Fo
Fo
e
lu
d
an
d
ld
Fo
e
lu
G
d
an
d
ld
Fo
d
an
Gl
ue
d
an
ow
n
wn
do
ld
Fo
Gl
ue
d
an
ow
n
wn
do
FLAP B
ld
Fo
FLAP B
Fold Flat Terrain 1:144 scale semi Detached house - Wall sheet
B A Handley Jan 2008
FLAP B
FLAP B
FLAP B
mp
le
file
Sa
i fe
kn ind
ith h
w be
e l ue
r
o
Sc nd g
a
ife
kn ind
ith h
w be
e lue
r
o g
Sc n d
a
ife
kn ind
ith h
w be
e e
or glu
c
S nd
a
le
mp
Sa
i fe
kn ind
ith h
w be
e l ue
r
o
Sc nd g
a
i fe
kn ind
ith h
w e be
e
or l u
Sc nd g
a
ife
kn ind
ith h
w be
e lue
r
o g
Sc n d
a
file
ife
kn ind
ith h
w be
re lue
o
g
Sc n d
a
ife
kn ind
ith h
w be
e lue
r
o g
Sc n d
a
Flap B
i fe
kn ind
ith h
w be
re l u e
o
Sc nd g
a
ife
kn ind
ith h
w be
e lue
r
o g
Sc n d
a
Flap B
Flap B
i fe
kn ind
ith h
w be
e l ue
r
o
Sc nd g
a
i fe
kn ind
ith h
w be
e e
or glu
c
S nd
a
Score with
knife
Score with
knife
Score with
knife
Score with
knife
file
le
mp
Sa
CUT OUT
CUT OUT
ROOF OF TOWER
Glue underneath
Glu
Glue tabs
each side
CUT OUT
CUT OUT
CUT OUT
CUT OUT
le
mp
Sa
file
Church Nave
e be
hin
CUT OUT
FLAP D
CUT OUT
Glu
CUT OUT
nd
ehi
eb
CUT OUT
CUT OUT
ind
re
fo ws
be do
nd in
hi t w
be ou
e
lu g
G ttin
cu
e
Glu
Glu
e
Mansion Extention
Inner Wall
Mansion extention
beh
ind
Glue to wall
ind
CUT OUT
beh
re
fo ws
be do
nd in
hi w
be out
e
lu g
G ttin
cu
FLAP A
Glue
Gl u
e
Glu
e
beh
ind
Glue
Roof Support
Glue to wall
Tab A
Sc
Scor
e
with
kn
glue
and
knife
h
it
ore w
ife a
file
h kn
ife a
S c or
e wit
le
mp
Sa
e
d glu
e an
if
n
k
h
e wit
Scor
nd g
lue
Road Block
Score and fold down
the middle
Tab C
Hanger/Workshop
Copyright B A Handley Jan 2000
nd g
lue
Rear Wall
Tab D