Professional Documents
Culture Documents
1/4
Web Site
http://www.simplicity.com
1-888-588-2700
12 pieces given
The Pattern
SYMBOLS
GRAIN LINE Place on
straight grain of fabric
parallel to selvage
CENTER FRONT OR
BACK of garment.
NOTCHES
DOTS
10
11
CUTTING LINE
12
A
E
Sewing
SEW garment following Sewing Directions.
PIN or machine-baste seams matching notches.
STITCH 5/8" (1.5 cm) seams unless otherwise stated.
PRESS seams open unless otherwise indicated clipping when necessary so
seams will lie flat.
TRIM seams to reduce bulk, as shown below.
Trim enclosed
seams into layers
Cutting
Layouts
TO SHORTEN:
At lengthen or
shorten lines,
make an even
pleat taking up
amount needed.
Tape in place.
LENGTHEN OR
SHORTEN LINES
G
B
Cutting/Marking
ADJUST IF NEEDED
Make adjustments before placing
pattern on fabric.
TO LENGTHEN:
Cut pattern
between
lengthen or
shorten lines.
Spread pattern
evenly, the
amount needed
and tape to
paper.
pattern printed
side down
pattern printed
side up
Trim corners
C TOP
See
SPECIAL
CUTTING
NOTES
Notch outer
curves
AFTER CUTTING:
Transfer markings to WRONG side
of fabric before removing pattern.
Use pin and chalk method or
dressmakers tracing paper and
wheel.
If layout
shows a piece
extending past
fold, cut out all
pieces except
piece that
extends.
Open out
fabric to single
thickness. Cut
extending
piece on
RIGHT side of
fabric in
position
shown.
Mark small
a.
selvages indicating
direction of nap or
design. Fold fabric
crosswise with
RIGHT sides
together, and cut
along fold (a).
Turn one fabric
layer around so
arrows on both
layers go in the
same direction.
Place RIGHT sides
together (b).
SELVAGE
b.
SELVAGES
5
7
6
FOLD
FOLD
A DRESS
SELVAGES
USE PIECE 2
44" 45" (115CM)
WITH NAP
SIZES 3 4 5 6 7
SELVAGE
SELVAGES
USE PIECES 5 6 7
D TOP
Clip inner
curves
BEFORE CUTTING:
PRESS pattern pieces with a warm dry
iron. PRE-SHRINK fabric by pre-washing
washables or steam-pressing nonwashables.
E PANTS
info@simplicity.com
SELVAGE
General Directions
CROSSWISE FOLD
2391
SELVAGES
SELS.
58" 60" (150CM)
WITH NAP
ALL SIZES
2
FOLD
7
6
B DRESS
SELVAGE
USE PIECE 2
FOLD
44" 45" (115CM)
WITH NAP
SIZES 3 4 5 6 7
SELS.
2
SEL.
SEL.
SEL.
FOLD
2
FOLD
FOLD
2
2
SEL.
SEL.
SEL.
2
FOLD
FOLD
SELVAGE
SELVAGE
USE PIECE 3
FOLD
FOLD
SEL.
3
FOLD
SELVAGES
FOLD
SELVAGE
F PANTS
USE PIECES 5 6
FOLD
FOLD
SEL.
English
2391
2/4
G,H BAG
H POLYESTER FLEECE
CONTRAST BAND
SINGLE THICKNESS
USE PIECE 8
SELS.
44" 45" (115CM)
G POLYESTER FLEECE
USE PIECE 9
44" 45" (115CM)
EDGE
USE PIECE 11
EDGE
FOLD
11
EDGE
FOLD
Sewing Directions
1
2
FABRIC
KEY
5
RIGHT SIDE
WRONG SIDE
INTERFACING
LINING
SATIN STITCH
CHAIN STITCH
LAZY-DAISY STITCH
BACK
FRENCH KNOT
6
FRONT
Press.
8
TOP C, D
7. Open out both long edges of single fold bias tape and press it
flat. Fold tape in half, lengthwise, having raw edges even.
EMBROIDERY D
4. Cut guide for embroidery tissue pattern along solid lines. On
OUTSIDE, center embroidery guide on top front
approximately 2" (5cm) above lower edge or as you prefer.
Transfer markings to RIGHT side of front, using a washable
fabric pen or pencil.
Copyright 2010Simplicity Pattern Co., Inc. / Printed in U.S.A. / Simplicity is a registered trademark of Simplicity Pattern Co., Inc.
11. To make casing in front and back, with RIGHT sides together,
pin tape to upper edge, having raw edges even, turning under
ends at armhole edges.
Stitch in 3/8" (1cm) seam.
Trim seam.
English
2391
3/4
7
12
12. Turn casing to INSIDE; press.
Stitch close to inner edge.
13. Cut ribbon in half for ties. Insert ribbon through front and back
casings, having ends extend evenly. Tie ribbon into bows at
shoulders when garment is worn. If necessary, trim ends of
ties to a desired length.
13
14
15
9. FOR VIEW E, F- Fold leg band along fold line, with RIGHT
sides together, having raw edges even. Stitch ends of band.
Trim seam.
16
10. Turn band RIGHT side out; press. Baste raw edges together.
10
11
PANTS E, F
1
12
13
13. On OUTSIDE, top-stitch pants close to seam.
BAG G
INNER
LEG
SEAM
SIDE SEAM
CENTER
FRONT
CENTER
BACK
CUTTING INSTRUCTIONS
3
4
4. Fold pillowcase back in half, lengthwise, with RIGHT sides
together. Cut out four bag front and back sections.
Two will be used for bag and remaining two will be referred to
as bag facings.
SEWING DIRECTIONS
Copyright 2010Simplicity Pattern Co., Inc. / Printed in U.S.A. / Simplicity is a registered trademark of Simplicity Pattern Co., Inc.
English
2391
SEWING DIRECTIONS
4/4
3
7
6
6. Open out long edges of strap and turn them to WRONG side
so that they meet at the crease. Press.
7
7. Fold strap in half lengthwise, bringing pressed edges
together. Stitch close to both long edges.
8. On OUTSIDE, pin strap to upper edge of bag, centering ends
over side seam and small dot. Baste.
10
10. With RIGHT sides together, stitch bag front to back at side
and lower edges, leaving the corners free.
11
12. Stitch seams of bag facing same as for bag. Press under 1/4"
(6mm) on upper edge of bag facing.
13
12
10
10. Fold bag facing in half, with RIGHT sides together. Stitch
seam.
14
14. Turn bag RIGHT side out. Place a pin on zipper extension 1"
(2.5cm) beyond side seam. Sew several overcast stitches
across zipper teeth at pin. Trim away lower end of zipper
close to stitching.
Cut a piece of ribbon 3" (7.5cm) long. Wrap ribbon around
adjusted end of zipper, turning under and lapping one end of
ribbon. Stitch close to both edges of ribbon.
12
11
11. Bring seam to center and stitch across lower edge, leaving an
opening to turn.
12. With RIGHT sides together, pin facing to bag at upper edge,
matching centers. Stitch seam.
BAG H
1
CUTTING INSTRUCTIONS
13
13. Turn bag RIGHT side out. Slip-stitch opening edges of facing
together. Insert bag facing into bag; press.
BAG FACING
BACK
FRONT AND
BACK
Copyright 2010Simplicity Pattern Co., Inc. / Printed in U.S.A. / Simplicity is a registered trademark of Simplicity Pattern Co., Inc.
14