Professional Documents
Culture Documents
RESET E#5
M may , gat DIP Switch 101-1 tren MainBoard t Off --> On --> Off , tat roi
m cong tac chnh .
FT 4418/4421
CODE #29 LENS HOME POSITION ERROR
- Definition The lens home position sensor is still on (HIGH) 3.5 seconds after the lens
leaves the home position.
- Possible Causes Lens home position sensor open Lens drive motor defective
Main board defective
CODE #2A 4TH/5TH MIRROR HOME POSITION ERROR
- Definition The 4th/5th mirror home position sensor is still off (LOW) 2.5 seconds after
the 4th/5th mirror assembly moves to the home position.
- Possible Causes 4th/5th mirror home position sensor short 4th/5th mirror motor defect
Main board defect
CODE #2B 4TH/5TH MIRROR HOME POSITION ERROR
- Definition The 4th/5th mirror home position sensor is still on (HIGH) 2.5 seconds
after the 4th/5th mirror assembly leaves the home position.
- Possible Causes 4th/5th mirror home position sensor open 4th/5th mirror motor defective
Main board defective
CODE #52 FUSING WARM-UP ERROR
- Definition The temperature detected by the thermistor does not reach 175oC within
100 seconds after the main switch is turned on.
- Possible Causes Thermistor position error Fusing lamp open Thermofuse open
AC drive board defective Main board defective
CODE #53 FUSING OVERHEAT
- Definition The thermistor detects a temperature higher than 240oC.
- Possible Causes Thermistor short AC drive board defect Main board defect
CODE #55 FUSING THERMISTOR OPEN
- Definition The thermistor does not detect 2oC within 30 seconds after the main
switch is turned on.
- Possible Causes Thermistor open Main board defective
Fusing lamp open Thermofuse open
E70 (IN THE MAGNIFICATION INDICATOR)
TONER OVERFLOW SENSOR ON
- Definition Toner overflow sensor turns on
- Possible Causes Toner overflow Toner overflow sensor open Main board defective
CODE #80 DUPLEX AND COPIER BOARD COMMUNICATION
ERROR
- Definition The copier main board does not receive any signal from the duplex main
board.
2
FT 4418/4421
- Possible Causes board defective Copier main board defective
Duplex main board defective Optional dc power supply unit defective
2nd paper size switches shorted
CODE #81 INTERFACE BOARD ERROR
- Definition The interface board is not connected when the duplex unit is installed.
- Possible Causes Interface board installed incorrectly Interface board defective
Main board defective 2nd paper size switch shorted
CODE #82 JOGGER HOME POSITION ERROR
- Definition The output of the jogger home position sensor stays LOW while the duplex
main board is driving the jogger fences outward.
- Possible Causes Jogger home position sensor shorted Jogger motor defective
Duplex main board defective Copier main board defective
Interface board defective
CODE #83 JOGGER HOME POSITION ERROR
- Definition The output of the jogger home position sensor remains HIGH as the
duplex main board is driving the jogger fences inward.
- Possible Causes Jogger home position sensor open Jogger motor defective
Duplex main board defective Copier main board defective
Interface board defective
ABNORMAL CONDITION IN TONER DENSITY DETECTION
- Symptom The Auto ID indicator or the selected manual ID level blinks. (No SC Code
is indicated.)
- Definition If the Vsg goes below 2.5 volts or Vsp goes above 7.5 volts 5 times in a
row.
- Possible Causes Incorrect Vsg voltage Dirty ID sensor Low toner density
ID sensor defect Main board defect
Interface