Professional Documents
Culture Documents
NIGERIA LIMITED
Project:
Document title:
6262 5020
PRE-CROSSING WORKS:
DSV POSITIONING AND SURVEY
PROCEDURES
Document Number:
OG-AA-K-2984
0
A
Rev.
14/05/02
15/04/02
Date
REVISION
Page 1/34
JNL
JNL
Orig
STOLT
JVA
JVA
Chk
STOLT
EK
EK
Appr
STOLT
AUTHORISED BY
Appr
SPDC
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
Revision:
A
Date of Issue:
28/03/02
PAGE 2
/ 28
OG-AA-K-2984
N. KOMAJDA
N. KOMAJDA
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
Revision:
0
Date of Issue:
14/05/02
PAGE 3
/ 34
OG-AA-K-2984
TABLE OF CONTENTS
1
INTRODUCTION
1.1
Objectives......................................................................................................................................................
1.2
Responsibilities..............................................................................................................................................
1.3
Definitions......................................................................................................................................................
1.4
References......................................................................................................................................................
2.1
Local Geodesy...............................................................................................................................................
2.2
2.3
2.4
32 Crossing Locations...............................................................................................................................
2.5
2.6
24 Crossing Locations...............................................................................................................................
2.7
Positional Information................................................................................................................................
PERSONNEL
15
EQUIPMENT
16
4.1
Surface Positioning.....................................................................................................................................
4.2
Sub-surface Positioning..............................................................................................................................
4.3
Gyrocompass...............................................................................................................................................
4.4
4.5
CTDS Sensor...............................................................................................................................................
18
5.1
DGPS Verification.......................................................................................................................................
5.2
Gyrocompass Calibration...........................................................................................................................
5.3
USBL Calibration.......................................................................................................................................
5.4
OPERATIONS
6.1
20
Positioning...................................................................................................................................................
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
Revision:
0
Date of Issue:
14/05/02
PAGE 4
/ 34
OG-AA-K-2984
6.2
As-built Survey............................................................................................................................................
6.3
Field Reporting...........................................................................................................................................
EQUIPMENT LIST
22
APPENDICES
23
8.1
8.2
8.3
8.4
8.5
8.6
8.7
8.8
8.9
8.10
8.11
NITEL FOC.................................................................................................................................................
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
Revision:
0
Date of Issue:
14/05/02
PAGE 5
/ 34
OG-AA-K-2984
INTRODUCTION
1.1
Objectives
The purpose of this document is to gather for all concerned personnel, the necessary
information and references for the positioning and survey operations onboard the
diving support vessel Stephaniturm for the diving operations on the proposed 32
OGGS RP-A to Bonny NLNG Trunkline and the proposed 24 Forcados/Yokri to
OGGS RP-A Spurline. The diving operations are to prepare the crossings of the
proposed pipelines with existing pipelines and cables. The crossed lines are to be
protected by grout mattresses installed by divers.
1.2
Responsibilities
Definitions
Company
Contractor
CM
CTDS
DCC
DGPS
DP
DSV
HHWS
km
KP
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
Revision:
0
Date of Issue:
14/05/02
PAGE 6
/ 34
OG-AA-K-2984
LAT
Lowest Astronomical Tide
LLWS
Lowest Low Water Spring
MSL
Mean Sea Level
NLNG
Nigeria Liquified Natural Gas Ltd
nm
Nautical Mile
OGGS
Offshore Gas Gathering System
QC
Quality Control
RP-A
Riser Platform A
SYMP
(Shell EA) Soft Yoke Mooring Platform
USBL
Ultra Short Base Line underwater acoustic positioning system.
All co-ordinates within this document are expressed in terms of the projection and
datum defined in Section 2.
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
1.4
Revision:
0
Date of Issue:
14/05/02
PAGE 7
/ 34
OG-AA-K-2984
References
Source
Document No
Stolt Offshore
Services
Stolt Offshore
Services
Stolt Offshore
Services
Stolt Offshore
Services
Stolt Offshore
Services
Racal Survey
(Malaysia) SDN
BHD (supplied by
Customer)
Racal Survey
(Malaysia) SDN
BHD (supplied by
Customer)
Racal Survey
(Malaysia) SDN
BHD
Racal Survey
(Malaysia) SDN
BHD
SPDC
OG-AA-K-2925
Date
OG-AA-K-2934
OG-AA-K-2902
09/10/01
OG-RP-K-2980
21/01/02
D-IS-03-997
March
2002
14/08/00
9043-0, INT-073
Rev.2
1999/030A/90430
/INT073/001 to
029, Rev 1
28/02/00
9043-0, INT-074
Rev.1
18/04/00
1999/030A/90430
/INT074/001 to
010, Rev 1
p9904005
18/04/00
SPDC
February
1997
February
1997
10/99
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
Revision:
0
Date of Issue:
14/05/02
PAGE 8
/ 34
OG-AA-K-2984
Local Geodesy
The following geodetic datum, spheroid and mapping projection parameters will be
used:
Datum:
Datum
Spheroid
Semi-major axis
Inverse flattening
:
:
:
:
Minna (Nigeria)
Clarke 1880 (modified)
6 378 249.145 m
293.465
:
:
:
:
:
:
Projection definition:
Grid name
Projection type
Central meridian
Latitude of origin
False Easting at CM
False Northing at
latitude of origin
Scale Factor at CM
2.2
: 0.99975
WGS 84 Definition:
Datum
Spheroid
Semi-major
axis
Semi-minor
axis
Inverse
flattening
Eccentricity
squared
: WGS 84
: WGS 84
: 6 378 137.0 m
: 6
356
752.3142 m
: 298.257 223
563
: 0.006 694 380
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
OG-AA-K-2984
Revision:
0
Date of Issue:
14/05/02
PAGE 9
/ 34
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
Revision:
0
Date of Issue:
14/05/02
PAGE 10
/ 34
OG-AA-K-2984
:
:
:
:
:
:
:
+111.916 metres
+87.852 metres
-114.499 metres
-1.87527 seconds
-0.20214 seconds
-0.21935 seconds
-0.03245 ppm
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
2.3
PAGE 11 /
34
OG-AA-K-2984
Easting
325792.0
332764.2
334018.2
335955.9
345754.9
351682.1
360566.8
386986.1
391869.0
397617.3
425770.7
426526.4
427247.5
427247.5
427968.6
428724.3
429324.3
430080.1
430802.9
430802.9
431525.7
432281.4
509347.4
517379.6
521806.1
531554.0
532089.2
531950.0
HHWS 531062.1
Last
531054.9
First
TP1
IP1
TP2
TP3
IP2
TP4
TP5
IP3
TP6
TP7
IP4
TP8
TP9
IP5
TP10
TP11
IP6
TP12
TP13
IP7
TP14
TP15
IP8
TP16
TP17
IP9
TP18
2.4
Revision:
0
Date of Issue:
14/05/02
Northing
84083.0
66396.0
63214.8
60397.5
46150.3
37532.3
32012.8
15600.3
12566.9
12589.1
12697.8
12700.7
12926.8
12926.8
13153.0
13155.9
13158.2
13161.1
12940.6
12940.6
12720.0
12722.9
13020.5
13051.5
19754.0
34513.7
35324.0
36285.0
42416.5
42465.9
Cum Length
0.00
19011.62
19011.62
25821.00
43112.70
43112.70
63734.42
94836.66
94836.66
106031.66
134185.27
134185.27
135685.27
135685.27
135685.27
137185.87
137785.87
137785.87
139285.57
139285.57
139285.57
140785.87
217852.45
217852.45
232601.33
250289.47
250289.47
252145.15
258340.56
258390.56
KP
0.000
19.012
19.012
25.821
43.113
43.113
63.734
94.837
94.837
106.032
134.185
134.185
135.685
135.685
135.685
137.186
137.786
137.786
139.286
139.286
139.286
140.786
217.852
217.852
232.601
250.289
250.289
252.145
258.341
258.391
32 Crossing Locations
Crossing
10.75 Texaco*
Easting
351715
Northing
39011
KP
52.43
Water Depth
22
Comment
OGGS RP-A
HHWS, Bonny
Interface
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
12.75 Texaco*
18 Texaco
NITEL Cable*
36 Agip
12 Agip
Crossing
10.75 Texaco*
12.75 Texaco*
18 Texaco
NITEL Cable*
36 Agip
12 Agip
Revision:
0
Date of Issue:
14/05/02
PAGE 12
/ 34
OG-AA-K-2984
361199
364309
384775
428928
429104
31620
29688
16974
13156
13156
Existing Pipeline /
Cable Bearing
177/357
053/233
064/244
090/270
358/178
000/180
64.48
68.14
92.23
137.39
137.57
Proposed 32
Bearing
135/225
122/302
122/302
122/302
090/270
090/270
20
20
21
23
23
Crossing
Angle
42
69
58
32
88
90
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
2.5
First
TP1
IP1
TP2
TP3
IP2
TP4
TP5
IP3
TP6
TP7
IP4
TP8
TP9
IP5
TP10
Last
Revision:
0
Date of Issue:
14/05/02
PAGE 13
/ 34
OG-AA-K-2984
Northing
158224.5
157392.9
156787.8
156560.9
155210.4
152429.0
144615.9
134285.8
133860.6
133473.3
133473.3
124223.0
121356.2
121356.4
121134.3
120433.6
84114.0
Bearing Radius
202.550
202.550
1500
249.740
249.740
15000
193.405
193.405
3499
207.643
207.643
8500
105.934
105.934
2000
149.989
149.989
KP Comment
0.000 Forcados/Yokri
0.900
0.900
2.136
6.036
6.036
20.784
31.404
31.404
32.273
32.273
32.273
47.362
47.362
47.362
48.900
90.843 OGGS RP-A
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
2.6
Revision:
0
Date of Issue:
14/05/02
PAGE 14
/ 34
OG-AA-K-2984
24 Crossing Locations
Crossing
NITEL Cable*
NITEL Cable*
SYMP to DP-B Umbilical
16 SYMP to DP-A
18 SYMP to DP-A
12 SYMP to DP-A
Crossing
NITEL Cable*
NITEL Cable*
SYMP to DP-B Umbilical
16 SYMP to DP-A
18 SYMP to DP-A
12 SYMP to DP-A
Easting
301128
318229
322923
322930
322954
322967
Northing
144489
97133
89007
88995
88953
88931
Existing Pipeline /
Cable Bearing
115/295
158/338
079/259
079/259
080/260
082/262
KP
20.91
75.81
85.192
85.206
85.254
85.280
Proposed 24
Bearing
193/013
150/330
150/330
150/330
150/330
150/330
Water Depth
18m
26m
22m
22m
22m
22m
Crossing
Angle
78
8
71
71
70
68
Department:
Stolt Offshore Services SA
Revision:
0
Date of Issue:
14/05/02
SURVEY
Document Title:
Stolt Document
Number
2.7
PAGE 15
/ 34
OG-AA-K-2984
Positional Information
The following table lists the platforms that may be used for DGPS and compass
verifications or calibrations:
Name
DP-A
WGS84
Latitude
Longitude
448 08.53N 52147. 14E
DP-B
448 22.54N
52050. 14E
89119.7
324782.1
DP-J
450 51.62N
51648. 71E
93689.7
317338.8
RP-A
325790.6
Comment
Platform Centre
(Heading = 46.49T)
Platform Centre
(Heading = 44.7T)
Platform Centre
(Heading = 44.92T)
Platform Centre
(Heading = 315.6T)
See Appendices 8.2 to 8.11 for as-found positions of existing pipelines and cables at
the crossings.
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
Revision:
0
Date of Issue:
14/05/02
PAGE 16
/ 34
OG-AA-K-2984
PERSONNEL
For the provision of positioning services for 24 hours per day, the following personnel
will be mobilised:
1 x Surveyor
1 x Survey technician
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
Revision:
0
Date of Issue:
14/05/02
PAGE 17
/ 34
OG-AA-K-2984
EQUIPMENT
This section details the positioning and survey equipment onboard the DSV.
The following equipment will be mobilised:
Surface positioning
Sub-surface positioning
Gyrocompass
Navigation and data
software
CTDS sensor
4.1
Surface Positioning
Differential GPS will provide the primary surface positioning onboard the DSV. The
differential delivery will be provided by Thales-GeoSolutions SkyFix Spot system.
The following SkyFix Reference Stations may be used.
Station Name
Port Gentil
Port Harcourt 1
Pointe Noire
Luanda
Abidjan
Station ID
900
910
940
945
955
Latitude
00 41' S
04 50' N
04 47' S
08 49' S
05 19' N
Longitude
008 46' E
007 00' E
011 52' E
013 14' E
004 01' W
Real-time differential GPS makes it possible to correct the readings of GPS receivers
operating in a given area with values corresponding to the errors actually observed at
a reference station.
The system is provided with the latest Thales QC and multi-reference software
package MultiFix3. The SkyFix/MultiFix3 system is interfaced to both the DP
systems of the DSV and to the survey navigation computer.
4.2
Sub-surface Positioning
An Ultra Short Base Line (USBL) Kongsberg Simrad HiPAP will be used to provide
sub-sea positioning. This system is permanently installed on the vessel. The
transponder may be hand-held by a diver.
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
4.3
Revision:
0
Date of Issue:
14/05/02
PAGE 18
/ 34
OG-AA-K-2984
Gyrocompass
The heading of the vessel will be provided by a SG Brown gyrocompass, which will
be interfaced to the navigation system.
4.4
The proposed integrated navigation package Eiva Navipac will be interfaced to the
surface positioning equipment, the gyrocompass and to the USBL acoustic surface
unit to provide real time position of the vessel.
This system is based on a Pentium II computer, a data storage unit with hard disk and
3.5 floppy disk , a printer, and a colour monitor for the helmsmans display (with full
back up).
All navigation data are stored on disk (HD and CD-ROM) for post processing
purposes if required.
The following will be displayed graphically:
the theoretical pipeline route;
positions of relevant existing structures: pipelines, cables and seabed
obstructions, etc.
The following items will be displayed numerically:
the actual position and heading of the vessel;
the Distance Off Line of the vessel reference point relative to the
proposed pipeline route;
the Distance Along Line of the vessel reference point relative to the
proposed pipeline route;
positions of all offsets (i.e. bell location).
The positioning information and graphical display from the integrated navigation
system will be displayed on remote screens (i.e. for helmsman) as required.
4.5
CTDS Sensor
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
Revision:
0
Date of Issue:
14/05/02
PAGE 19
/ 34
OG-AA-K-2984
DGPS Verification
One of the following methods will be used to verify the DGPS positioning system:
a total station set up on and referenced to co-ordinated points on the
shore will be used to observe the range and bearing to a reflector mounted onto
the GPS antenna on the vessel. The reflector position will be calculated and this
will be compared to the antenna position observed at the vessel. The shore and
vessel parties will ensure that they are using the same geodetic and projection
parameters;
the vessel will perform transit fixes around a platform (see Section 2.7
for positions of platforms near the work areas). The derived platform position
will be compared to the known position. The calibration method is outlined in
OG-AA-K-2902.
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
5.2
Revision:
0
Date of Issue:
14/05/02
PAGE 20
/ 34
OG-AA-K-2984
Gyrocompass Calibration
USBL Calibration
On arrival on site and prior to starting the operations, a sound velocity profile will be
observed with the CTDS probe. Medwin's or Wilson's formula will be used to
determine the speed of sound for the USBL system. Velocity profiles will be observed
at the commencement of operations and again when the vessel re-locates to the next
crossing.
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
Revision:
0
Date of Issue:
14/05/02
PAGE 21
/ 34
OG-AA-K-2984
OPERATIONS
Refer to the Pre-crossing Installation Procedures for details of the proposed dive
operations and tasks. The following sections outline the requirements of the survey
personnel onboard the DSV.
6.1
Positioning
As-built Survey
The purpose of this survey is to acquire data to determine the position and alignment
of the grout bags for use in the final as-built alignment sheets and report.
Upon completion of the installation at each crossing, the diver will take the hand-held
transponder to the extremities of the grout bag arrays to confirm their position and
orientation.
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
6.3
Revision:
0
Date of Issue:
14/05/02
PAGE 22
/ 34
OG-AA-K-2984
Field Reporting
A preliminary field report will be submitted onboard the survey vessel after
completion of the survey operations. The preliminary report will be inclusive of the
main results of the survey, and in particular those that could create the need for
remedial actions. It should contain the following:
1. Introduction;
2. Scope of Work;
3. Description of operations;
4. Summary of preliminary survey results;
5. Surface positioning and sub-surface positioning;
6. Note on equipment performance including positioning QC;
7. Sequence of Significant Events;
8. Mobilisation, trials and calibration results including the following:
Velocity sensor calibration certificates;
Statement of Readiness;
DGPS verification results;
Offset measurements and diagram;
Gyrocompass calibration and check results;
Surface and USBL system set-up parameters;
Personnel and equipment lists;
9. Health, Safety and Environment Report;
10. Chart and Drawing Index;
11. Completed Check Lists;
12. Conclusions and recommendations.
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
Revision:
0
Date of Issue:
14/05/02
PAGE 23
/ 34
OG-AA-K-2984
EQUIPMENT LIST
The equipment listed below will be installed and interfaced onboard the DSV:
Item
Thales GeoSolutions SkyFix Premier DGPS including:
Dual frequency GPS receivers (Trimble MS750)
Inmarsat Demodulators
MultiFix computers and MultiFix software version 3
Navigation equipment c/w computers with Eiva Navipac
software, printer and peripherals
USBL Simrad Acoustic Positioning System
Mini-transponders c/w charger
SG Brown Gyrocompass
Valeport CTDS probe Series 600
Online
1
2
1
6
3
1
Spare
1
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
Revision:
0
Date of Issue:
14/05/02
PAGE 24
/ 34
OG-AA-K-2984
APPENDICES
8.1
The following are to be checked and signed off during mobilisation on completion of
each item.
Item N
1
Item
Completed
()
Time/Date
DGPS
functional test
differential received
verification
USBL system
functional test
offsets measured
calibration
Gyrocompass
functional test
latitude and speed settings
calibration
On-line Navigation System:
Interfacing
Offsets measured
Field database input
Datum conversion test completed
CTD Probe
wet test
valid certificate
P.C./Surveyor
Customer Acceptance
___________________
___________________
Date ___________
Date ___________
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
8.2
Revision:
0
Date of Issue:
14/05/02
PAGE 25
/ 34
OG-AA-K-2984
The Niari determined the following co-ordinates for the 10.75 Texaco pipeline
during the pre-engineering and pre-lay survey undertaken on 28 October 2001:
#
1*
2
3
4
5
6
7
8
9
10
11
12
13*
Easting
352698
351912
351883
351841
351800
351760
351715
351645
351627
351610
351599
351580
349359
Northing
25734
38225
38315
38460
38567
38712
39011
39477
39600
39700
39800
39900
52537
Comment
Oloibiri Tank
Crossing
Middleton
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
8.3
Revision:
0
Date of Issue:
14/05/02
PAGE 26
/ 34
OG-AA-K-2984
The Niari determined the following co-ordinates for the 12.75 Texaco pipeline
during the pre-engineering and pre-lay survey undertaken on 28 October 2001:
#
1*
2
3
4
5*
Easting
352698
361039
361199
361231
371404
Northing
25734
31500
31620
31644
40068
Comment
Oloibiri Tank
Crossing
North Apoi
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
8.4
Revision:
0
Date of Issue:
14/05/02
PAGE 27
/ 34
OG-AA-K-2984
The Niari determined the following co-ordinates for the 18 Texaco pipeline during
the pre-engineering and pre-lay survey undertaken on 28 October 2001:
#
1*
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21*
Easting
352698
363540
363600
363700
363800
363900
364000
364100
364200
364300
364309
364400
364500
364600
364700
364800
364900
365000
365100
365150
375823
Northing
25734
29420
29455
29480
29510
29543
29570
29600
29637
29683
29688
29732
29761
29791
29831
29879
29920
29948
29980
30000
35895
Comment
Oloibiri Tank
Crossing
Funiwa
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
8.5
Revision:
0
Date of Issue:
14/05/02
PAGE 28
/ 34
OG-AA-K-2984
The following co-ordinates for the 36 Agip pipeline were determined by the Niari
during the pre-engineering and pre-lay survey undertaken on 29 October 2001:
#
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
Easting
428956
428959
428959
428962
428970
428976
428970
428955
428945
428940
428937
428934
428930
428928
428925
428920
428916
428931
428966
428980
429005
429026
429044
429046
Northing
11792
12000
12100
12200
12300
12400
12500
12600
12700
12800
12900
13000
13100
13156
13200
13300
13400
13500
13600
13700
13800
13900
14000
14100
Comment
Crossing
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
8.6
Revision:
0
Date of Issue:
14/05/02
PAGE 29
/ 34
OG-AA-K-2984
The following co-ordinates for the 12 Agip pipeline were determined by the Niari
during the pre-engineering and pre-lay survey undertaken on 29 October 2001:
#
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
Easting
429105
429106
429106
429107
429106
429105
429105
429106
429102
429104
429108
429110
429113
429119
429125
429125
429123
429122
429120
429115
429115
429111
429108
429103
Northing
12300
12400
12500
12600
12700
12800
12900
13000
13100
13156
13200
13300
13400
13500
13600
13700
13800
13900
14000
14100
14200
14300
14400
14500
Comment
Crossing
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
8.7
Revision:
0
Date of Issue:
14/05/02
PAGE 30
/ 34
OG-AA-K-2984
The following co-ordinates for the SYMP to DP-B Umbilical were determined by the
Niari during the post-lay survey undertaken 26 and 27 February 2002:
#
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
Easting
320902
320968
321018
321084
321113
321166
321251
321333
321427
321517
321609
321760
321832
321880
321939
322032
322115
322210
322290
322345
322439
322497
322598
322672
Northing
88710
88717
88724
88731
88733
88744
88751
88764
88771
88786
88797
88820
88828
88832
88841
88854
88861
88875
88887
88893
88917
88924
88942
88958
#
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
Easting
322730
322858
322925
322984
323060
323143
323244
323285
323340
323413
323500
323609
323674
323781
323869
323981
324122
324240
324318
324394
324485
324591
324707
Northing
88976
88993
89008
89018
89030
89049
89068
89075
89088
89101
89117
89140
89146
89169
89190
89208
89217
89217
89206
89195
89175
89151
89116
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
8.8
Revision:
0
Date of Issue:
14/05/02
PAGE 31
/ 34
OG-AA-K-2984
The following co-ordinates for the 16 SYMP to DP-A pipeline were determined by
the Niari during the post-lay survey undertaken 26 and 27 February 2002:
#
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
Easting
321398.1
321475.0
321573.7
321658.5
321748.6
321818.8
321911.4
321960.2
322002.7
322045.4
322101.0
322169.3
322238.8
322309.2
322395.4
322477.8
322532.5
322602.8
322681.8
322775.9
Northing
88761.1
88771.9
88785.7
88792.9
88807.5
88814.9
88826.9
88829.2
88839.0
88845.4
88850.0
88857.4
88867.7
88877.3
88891.3
88909.0
88918.3
88931.0
88947.2
88964.2
#
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
Easting
322868.4
322932.5
323035.2
323163.6
323266.6
323310.4
323398.2
323438.4
323500.6
323566.3
323667.9
323718.3
323771.1
323826.5
323939.1
324051.3
324146.2
324248.5
324344.6
324402.2
Northing
88980.9
88995.5
89014.7
89036.6
89058.1
89063.6
89082.3
89092.1
89100.3
89112.6
89129.7
89143.7
89150.8
89164.3
89185.5
89193.0
89195.0
89191.6
89179.0
89168.4
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
8.9
Revision:
0
Date of Issue:
14/05/02
PAGE 32
/ 34
OG-AA-K-2984
The following co-ordinates for the 18 SYMP to DP-A pipeline were determined by
the Niari during the post-lay survey undertaken 26 and 27 February 2002:
#
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
Easting
320868.7
321124.5
321172.9
321374.6
321445.5
321487.2
321550.0
321650.8
321717.1
321822.6
321903.8
321968.8
322032.0
322133.5
322251.7
322345.3
322394.9
322426.7
322485.0
322529.3
322629.8
Northing
88689.3
88721.4
88725.6
88749.2
88760.2
88766.5
88772.6
88780.9
88791.6
88803.5
88812.5
88822.4
88828.8
88842.4
88857.9
88866.5
88875.9
88880.3
88885.9
88890.8
88903.8
#
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
Easting
322704.9
322765.6
322860.1
322991.7
323174.0
323323.5
323484.1
323558.6
323647.3
323774.1
323923.1
324036.6
324176.0
324270.2
324338.5
324415.2
324552.8
324647.1
324761.0
324877.7
Northing
88916.5
88919.4
88935.5
88960.1
88988.9
89011.8
89038.8
89057.1
89065.8
89091.4
89113.8
89131.5
89144.2
89153.4
89148.6
89142.2
89121.8
89105.5
89085.6
89068.5
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
Revision:
0
Date of Issue:
14/05/02
PAGE 33
/ 34
OG-AA-K-2984
Easting
320864.0
321156.5
321361.2
321432.0
321525.3
321636.7
321773.4
321903.2
322026.9
322123.0
322180.6
322281.1
322373.2
322446.7
322539.3
322650.6
322718.1
322799.2
322949.5
323128.0
323254.0
323358.4
323432.4
Northing
88684.1
88719.2
88740.3
88749.5
88763.5
88770.1
88791.7
88805.0
88819.7
88830.6
88837.9
88849.5
88860.0
88872.1
88882.6
88895.2
88904.7
88909.6
88929.3
88949.1
88961.4
88973.4
88983.4
#
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
Easting
323560.7
323641.7
323773.9
323925.8
324028.9
324106.4
324224.0
324314.0
324521.6
324637.9
324768.9
324878.9
325042.5
325153.4
325332.0
325497.5
325572.0
325701.1
325828.7
325951.6
326039.8
326296.6
Northing
89001.3
89006.7
89021.3
89042.5
89051.1
89063.3
89084.0
89087.5
89104.8
89096.2
89076.7
89057.2
89042.1
89034.0
89016.9
88991.6
88970.5
88930.1
88886.8
88847.8
88817.8
88736.0
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
Revision:
0
Date of Issue:
14/05/02
PAGE 34
/ 34
OG-AA-K-2984
Easting
298823
298921
299011
299102
299191
299281
299377
299481
299586
299678
299769
299860
299950
300043
300133
300225
300316
300405
300495
300586
300676
300767
300857
300950
301040
Northing
145559
145513
145470
145430
145386
145345
145299
145248
145202
145158
145117
145075
145031
144992
144954
144911
144869
144827
144781
144742
144700
144656
144615
144573
144531
#
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
Easting
301128
301131
301220
301310
301404
301493
301584
301676
301767
301859
301946
302038
302129
302219
302312
302400
302500
302565
302656
302744
302837
302927
303018
303108
Northing
144489
144490
144446
144404
144363
144319
144281
144237
144194
144156
144110
144069
144027
143985
143944
143900
143852
143828
143784
143744
143702
143659
143615
143575
Easting
Northing
Easting
Northing
Department:
Stolt Offshore Services SA
Combines Stolt Comex Seaway and ETPM
SURVEY
Document Title:
Stolt Document
Number
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
317260
317297
317334
317373
317407
317444
317481
317518
317555
317590
317629
317664
317703
317740
317777
317811
317852
317887
317922
317963
317998
318037
318072
318109
318148
318182
318220
318229
318256
318293
PAGE 35
/ 34
OG-AA-K-2984
99573
99481
99389
99297
99203
99109
99015
98923
98829
98737
98643
98551
98458
98366
98272
98179
98086
97992
97899
97808
97714
97622
97528
97436
97342
97248
97156
97133
97062
96970
END OF DOCUMENT
Revision:
0
Date of Issue:
14/05/02
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
318332
318367
318404
318443
318480
318513
318552
318589
318623
318662
318699
318738
318775
318810
318849
318882
318921
318956
318995
319031
319398
319768
320134
320503
320872
321240
321535
321610
321978
322346
96878
96784
96692
96600
96506
96412
96318
96226
96132
96040
95948
95854
95762
95668
95578
95482
95390
95296
95204
95110
94182
93251
92321
91391
90463
89719
88788
88602
87674
86742