Professional Documents
Culture Documents
www.solidcam.com
SolidCAM 2014
CoordSys
www.solidcam.com
Radial movement levels are now on the main dialogue (instead of TAB)
SolidCAM 2014
Stock
www.solidcam.com
SolidCAM 2014
Setup
www.solidcam.com
SolidCAM 2014
Machine ID
www.solidcam.com
All data from *.PRP file transferred to *.VMID file (Controller Definition and
Working Style pages) - PRP is no longer used.
Much easier definition and editing
www.solidcam.com
SolidCAM 2014
Settings
www.solidcam.com
High precision for box (faceting) set to ON always during CoordSys definition
www.solidcam.com
Defaults through Settings for Feed Link, Lead in, Lead out
Add possibility to define defaults through Settings for Feed Link, Lead In and Lead Out
www.solidcam.com
SolidCAM 2014
Miscellaneous
www.solidcam.com
SolidCAM 2014
Tooltable
www.solidcam.com
Combine Milling and Turning STL Holders under one machine library
www.solidcam.com
If tool is marked as permanent it will be imported without any change in any field
www.solidcam.com
Option to rotate insert, when working in Insert only mode, by setting Insert Lead angle
www.solidcam.com
SolidCAM 2014
Geometry
www.solidcam.com
SolidCAM 2014
Transformation
www.solidcam.com
If Optimization of job loops is turned on in *.VMID, the sorting types which will be
affected by optimization, are marked by green color
www.solidcam.com
SolidCAM2014
iMachining
www.solidcam.com
To alter the hardness of a material, without changing its Ultimate Tensile Strength (UTS)
value (factor higher than zero results in faster cutting)
www.solidcam.com
Enables you to define a Floor offset that is separate from the Wall offset
www.solidcam.com
SolidCAM 2014
2.5D Mill
www.solidcam.com
New option Vertical for Ramping options in Face milling operation (instead of Helical)
www.solidcam.com
www.solidcam.com
Define depth of pocket per chain => possibility to machine pockets with same start level
but different depths, in same operation
www.solidcam.com
SolidCAM 2014
Toolbox
www.solidcam.com
SolidCAM 2014
www.solidcam.com
SolidCAM 2014
Drilling
www.solidcam.com
SolidCAM 2014
HSR/HSM
www.solidcam.com
Even if previous operations are not calculated , its possibe to select them for
further updated stock calculation in HSR Rest Roughing
www.solidcam.com
Take into account HSR/HSM operations when updating stock for further turning
operations
www.solidcam.com
SolidCAM 2014
Sim 5x
www.solidcam.com
SolidCAM 2014
Turning
www.solidcam.com
SC2013
SC2014
SC2014
without Lead in
with Lead in
SC2014
without Lead in
SolidCAM 2014
Probe
www.solidcam.com
If Controller doesnt support any of Probe cycles its possible now to disable it
www.solidcam.com
SolidCAM2014
Simulation
www.solidcam.com